NHTSA vehicle safety data

2006 Chevrolet Malibu Recalls, Ratings & Complaints

The 2006 Chevrolet Malibu has 9 NHTSA recall campaigns and 1,118 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Chevrolet dealer.

NHTSA recall and complaint data for the 2006 Chevrolet Malibu, plus NCAP crash-test ratings. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2006 Chevrolet Malibu owner complaints

Owners have filed 1,118 complaints with NHTSA about the 2006 Chevrolet Malibu, describing incidents dated December 12, 2005 to October 24, 2026.

Most-cited components

Steering 812 complaints
Electrical System 142 complaints
Fuel/Propulsion System 96 complaints
Service Brakes 69 complaints
Exterior Lighting 63 complaints
Engine 58 complaints

Of the 1,118 complaints on file, 42 report a crash and 6 a fire; across all 1,118 complaints, owners report 26 injuries (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11773598 · Filed October 26, 2026
I was driving at a busy time of the day and my steering wheel became almost impossible to turn, and it felt as though my whole car turned off but I gave it gas and went to nearest place I could pull over and noticed my radio was showing that steering fluid or something like that was on the digital…
ODI #11771886 · Filed October 18, 2026
I got the car on June 12th on June 16th when I had a severe car vacation not deploy and the seatbelt did not buckle when I bought the car they stated in the paperwork that the airbags have never been deployed and or never been deactivated and I had to find out the hard way 4 days later and due to…
ODI #11768146 · Filed September 30, 2026
When i drive the car power steering goes out totally and bings when it goes out.

Read all 1,118 complaints

Owner-reported

2006 Chevrolet Malibu mileage at failure

900 of the 1,118 complaints on file for the 2006 Chevrolet Malibu give the vehicle's mileage when the problem happened.

Mileage at failure by component, from owners' complaints to NHTSA
Component	Median	Middle half	Based on
Steering	Median 90,000 miles	Middle half 60,000–130,000 miles	Based on 674 complaints
Electrical System	Median 100,000 miles	Middle half 60,000–130,000 miles	Based on 97 complaints
Fuel/Propulsion System	Median 85,000 miles	Middle half 65,000–125,000 miles	Based on 69 complaints
Service Brakes	Median 75,000 miles	Middle half 50,000–120,000 miles	Based on 53 complaints
Exterior Lighting	Median 75,000 miles	Middle half 35,000–110,000 miles	Based on 50 complaints
Engine	Median 100,000 miles	Middle half 65,000–120,000 miles	Based on 45 complaints

A component's median is its 50th percentile, and its middle half runs from its 25th to its 75th percentile.

Owners give the mileage themselves, often as a round number, and NHTSA doesn't check it. A complaint that names several components counts under each one, and mileages that can't be right, such as 999,999, or 50 miles on a five-year-old car, are left out.

These figures describe the complaints owners filed. They don't predict when a particular vehicle will have a problem, and vehicles that never had one aren't counted.

Most complaints NHTSA received since May 17, 2021 give no mileage. So that they aren't undercounted, each one received since then that gives a mileage also stands in for those that gave none, which can put a component's median above most of the mileages it is based on.

Mileage from NHTSA's complaints file of October 31, 2026. How these figures are worked out

Sudden Loss of Electric Power Steering

NHTSA #15V064000 · Steering — Electric Power Assist System · NHTSA notice

Reported February 4, 2015 · General Motors LLC

Potentially affected: 69,633 vehicles

Repair completion: 55.68% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign 14772 · Owners notified February 24, 2015 · Vehicles built April 1, 2006 – June 30, 2006 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

General Motors LLC (GM) is recalling certain model year 2006-2007 Chevrolet Malibu and Malibu Maxx vehicles manufactured April 1, 2006, to June 30, 2006, and 2006-2007 Pontiac G6 vehicles manufactured April 18, 2006, to June 30, 2006. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.

Safety consequence

If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.

Manufacturer remedy

GM will notify owners, and dealers will replace the torque sensor assembly, free of charge. The recall began February 24, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020 or Pontiac customer service at 1-800-762-2737. GM's number for this recall is 14772. Note: This is an expansion of recall 14V-153 to cover additional vehicles built between April 1, 2006 and June 30, 2006.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Steering Shaft Inadequate Support of U-Joint

NHTSA #14E044000 · Steering · NHTSA notice

Reported July 21, 2014 · Dorman Products, Inc.

Potentially affected: 7,304 vehicles

Repair completion: 30.35% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Owners notified September 8, 2014

Defect description

Dorman Products, Inc. (Dorman) is recalling certain replacement intermediate steering shafts sold under the Dorman, OE Solutions, and Solutions brand names, part numbers 425-167, 2425167, and 7-3074, for installation on 2004-2012 Chevrolet Malibu, 2005-2010 Pontiac G6, and 2007-2009 Saturn Aura vehicles. The affected steering shafts may have a yoke that inadequately supports the u-joint bearing resulting in a premature failure.

Safety consequence

A joint bearing that fails prematurely may cause separation of the u-joint resulting in a complete loss of steering control, increasing the risk of a crash.

Manufacturer remedy

Dorman will notify owners, and dealers will refund the purchase price or replace the steering shafts, free of charge. The recall began in September 2014. Owners may contact Dorman customer service at 1-800-523-2492.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Brake Lights may or may not Randomly Illuminate

NHTSA #14V252000 · Electrical System — Wiring · NHTSA notice

Reported May 14, 2014 · General Motors LLC

Potentially affected: 2,440,524 vehicles

Repair completion: 59.64% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign 13036 · Owners notified August 18, 2014 · Vehicles built May 26, 2005 – June 9, 2006 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.

Safety consequence

Any of the above failure conditions increases the risk of a crash.

Manufacturer remedy

GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Transmission Shift Cable may Fracture/Rollaway

NHTSA #14V224000 · Power Train — Automatic Transmission · NHTSA notice

Reported April 30, 2014 · General Motors LLC

Potentially affected: 1,131,113 vehicles

Repair completion: 53.63% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign 14152 · Owners notified June 27, 2014 · Vehicles built May 16, 2003 – October 5, 2007 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.

Safety consequence

If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.

Manufacturer remedy

GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Sudden Loss of Electric Power Steering

NHTSA #14V153000 · Steering — Electric Power Assist System · NHTSA notice

Reported March 31, 2014 · General Motors LLC

Potentially affected: 1,373,177 vehicles

Repair completion: 60.08% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign N140115 · Owners notified July 17, 2014 · Vehicles built May 26, 2005 – March 31, 2006 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.

Safety consequence

If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.

Manufacturer remedy

GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

AFTERMARKET FUEL PUMPS

NHTSA #11E009000 · Fuel System, Gasoline — Delivery — Fuel Pump · NHTSA notice

Reported February 28, 2011 · TI GROUP AUTOMOTIVE SYSTEMS, LLC

Potentially affected: 4,887 vehicles

Owners notified February 22, 2011

Defect description

TI AUTOMOTIVE IS RECALLING CERTAIN FUEL PUMPS, PART NUMBERS TU456 AND TU303, SOLD UNDER VARIOUS BRAND NAMES AS AFTERMARKET AND REPLACEMENT EQUIPMENT FOR THE MOTOR VEHICLES LISTED ABOVE. THE DEFECTIVE FUEL PUMP MAY SEIZE, STOPPING THE FUEL FLOW TO THE ENGINE CREATING A STALLING CONDITION.

Safety consequence

A VEHICLE CRASH COULD OCCUR SHOULD THE ENGINE STALL WHILE IN USE.

Manufacturer remedy

TI AUTOMOTIVE WILL NOTIFY OWNERS OF RECORD AND WILL REPLACE ANY DEFECTIVE FUEL PUMP WITH A NEW OR REWORKED FUEL PUMP FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 22, 2011. OWNERS MAY CONTACT TI AUTOMOTIVE AT 1-866-867-3759 OR LOG ON TO WWW.RECALLRESPONSE.COM.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET AND REPLACEMENT FUEL PUMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

FMVSS 108/AFTERMARKET COMBINATION LAMPS

NHTSA #09E012000 · Exterior Lighting · NHTSA notice

Reported April 7, 2009 · SABERSPORT

Potentially affected: 16,270 vehicles

Owners notified May 11, 2009

Defect description

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Safety consequence

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Manufacturer remedy

SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

LEATHER SEAT COVERS/AIR BAG SENSING SYSTEM

NHTSA #06V417000 · Air Bags — Frontal · NHTSA notice

Reported October 31, 2006 · GENERAL MOTORS CORP.

Potentially affected: 794 vehicles

Manufacturer campaign 06102 · Owners notified November 6, 2006 · Vehicles built August 1, 2005 – August 31, 2005 (per NHTSA)

Defect description

CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.

Safety consequence

IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. IN EITHER CASE, IN THE EVENT OF A CRASH THAT REQUIRES AIR BAG DEPLOYMENT, A FRONT PASSENGER'S LEVEL OF INJURY MAY BE INCREASED.

Manufacturer remedy

BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED IN GM'S LETTER TO OWNERS. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS SHOULD CONTACT GM AT 1-877-477-1022 TO BEGIN THE PROCESS OF REPURCHASING THEIR VEHICLE.

Notes

GM RECALL NO. 06102.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

TIRE INFORMATION LABEL/FMVSS 110

NHTSA #05V486000 · Equipment — Other — Labels · NHTSA notice

Reported October 19, 2005 · GENERAL MOTORS CORP.

Potentially affected: 2,351 vehicles

Manufacturer campaign 05091 · Owners notified November 29, 2005

Defect description

CERTAIN VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE TIRE LABEL TABLE SPECIFIED THE 15 INCH SPARE FOR THE FRONT DISC/REAR DRUM BRAKE SYSTEM AND IT SHOULD SPECIFY A 16 INCH SPARE TIRE SIZE.

Safety consequence

A 15" DIAMETER REPLACEMENT SPARE TIRE CAN NOT BE INSTALLED ON THE FRONT AXLE DUE TO A FIT INTERFERENCE WITH THE BRAKE CALIPER.

Manufacturer remedy

OWNERS WILL BE MAILED A CORRECTED LABEL WITH INSTALLATION INSTRUCTIONS OR THE CUSTOMERS COULD HAVE THEIR DEALERS TO INSTALL THE LABEL FOR THEM. THE RECALL BEGAN ON NOVEMBER 29, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.

Notes

GM RECALL NO.05091.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

2006 Chevrolet Malibu 4-DR.

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 5, Passenger: 5

Side Crash

Not Rated

Driver: 4, Passenger: 5

Side Pole

Not Rated

Rollover

Not Rated

Safety Technology

2006 Chevrolet Malibu 4-DR. w/SAB

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 5, Passenger: 5

Side Crash

Not Rated

Driver: 5, Passenger: 4

Side Pole

Not Rated

Rollover

Not Rated

Safety Technology

1,118 owner complaints have been filed with NHTSA for the 2006 Chevrolet Malibu.

Steering

ODI #11773598

Incident: October 24, 2026 · Filed: October 26, 2026

I was driving at a busy time of the day and my steering wheel became almost impossible to turn, and it felt as though my whole car turned off but I gave it gas and went to nearest place I could pull over and noticed my radio was showing that steering fluid or something like that was on the digital part of my radio, so I googled what could the problem be and it said the steering is being recalled or something like that for steering problems, I am driving the car as little as possible because that was very scary especially driving through main street in my town, thank god i was only going 25 miles an hour or this could have really caused major problems. Please let me know what to do next [XXX] [XXX] thank you INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Air Bags; Seat Belts; Unknown or Other

ODI #11771886

Crash

Incident: June 16, 2026 · Filed: October 18, 2026

I got the car on June 12th on June 16th when I had a severe car vacation not deploy and the seatbelt did not buckle when I bought the car they stated in the paperwork that the airbags have never been deployed and or never been deactivated and I had to find out the hard way 4 days later and due to the transmission shift gear cable when I was driving the car it went out of control and I had to work well that day

Steering

ODI #11768146

Incident: August 5, 2024 · Filed: September 30, 2026

When i drive the car power steering goes out totally and bings when it goes out.

Steering

ODI #11726385

Incident: September 1, 2025 · Filed: March 23, 2026

The contact owns a 2006 Chevrolet Malibu. The contact stated that while pulling out of a parking space, the vehicle lost power steering functionality, causing the steering wheel to become difficult to turn. The power steering warning light was illuminated. The vehicle was pushed back into the parking space. The contact stated that the failure was intermittent. The contact stated that the steering gear was previously replaced due to a similar failure. The contact associated the failure with NHTSA Campaign Number: 15V064000 (Steering); however, the VIN was not included. The manufacturer was contacted and informed the contact that the VIN was not associated with the recall. The vehicle was not repaired. The failure mileage was approximately 158,000.

Steering; Electrical System

ODI #11715484

Incident: January 17, 2026 · Filed: February 4, 2026

The power steering went out on the car as I was driving down the highway going 65 mph

Steering

ODI #11715231

Incident: January 1, 2026 · Filed: February 3, 2026

The contact owns a 2006 Chevrolet Malibu. The contact stated that while driving at an undisclosed speed, the vehicle experienced a loss of power steering assist. There were three audible dings with the message "Power Steering" displayed on the instrument panel. The contact reset the steering wheel and the battery, but the failure persisted. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact related the failure to NHTSA Campaign Number: 15V064000 (Steering); however, the VIN was not included in the recall. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was unknown.

Steering

ODI #11711435

Incident: January 15, 2026 · Filed: January 16, 2026

The contact owns a 2006 Chevrolet Malibu. The contact stated that while driving at an undisclosed speed, the steering wheel failed to turn in the intended direction. The power steering failure warning light was illuminated. The vehicle was driven to the independent mechanic, where it was diagnosed with STRG shaft torque failure. The contact was informed that the STRG shaft torque needed to be replaced. The vehicle was not repaired. The contact was advised to contact the dealer. The contact was made aware of NHTSA Campaign Number: 14V153000 (Steering). The dealer was made aware of the failure but provided no assistance. The contact was informed that the recall repair was performed in 2015. The manufacturer was not made aware of the failure. The failure mileage was approximately 125,000.

Steering; Electrical System

ODI #11703181

Incident: November 12, 2025 · Filed: December 5, 2025

My power steering goes in and out as I'm driving depending on the speed. I have trouble swerving if needed because the power steering is not working correctly all the time.

Steering

ODI #11701822

Incident: November 26, 2025 · Filed: November 27, 2025

Power steering warning light appeared then steering wheel tightened while slowing down to make a turn into my apartment. This occured two times in 3 weeks.

Steering

ODI #11673589

Incident: July 15, 2023 · Filed: July 15, 2025

The contact owns a 2006 Chevrolet Malibu. The contact stated while driving at an undisclosed speed, an alarm sounded, and the message "Power Steering Failure" was displayed. No warning light was illuminated. The contact pulled over to the shoulder of the road to restart the vehicle however, the failure persisted. The local dealer was contacted; however, the vehicle was not diagnosed or repaired. Another local dealer was contacted and informed the contact that the vehicle was previously repaired under NHTSA Campaign Number: 14V153000 (Steering); however, the contact stated that the vehicle was never repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 118,000.

Other Chevrolet Malibu model years

Check your 2006 Chevrolet Malibu VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Chevrolet Malibu at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Chevrolet VIN