2018 Toyota RAV4 Recalls, Ratings & Complaints

Incident: October 15, 2026 · Filed: October 15, 2026

All warning lights came on and started flashing, steering wheel locked completely and total system failure. Car suddenly died and I had no control of it. Engine started smoking with black smoke. I got out of car and engine immediately caught fire starting at the bottom left driver side of engine and within a few minutes vehicle was completely engulfed with flames. It exploded and car was gone.

Incident: May 1, 2025 · Filed: October 6, 2026

The contact owns a 2018 Toyota RAV4. The contact stated that while driving at various speeds and turning right or left, the vehicle lost power and failed to accelerate as needed while depressing the accelerator pedal. The cause of the failure was not yet determined. The local dealer and manufacturer were notified of the failure, but no assistance was provided. The contact was informed that the vehicle was not covered under an extended coverage associated with a fuel system failure. The failure mileage was 78,000.

Incident: September 13, 2026 · Filed: September 13, 2026

Cooper tires 225/65R17. Purchased 4 tires in June. From installation the tires were bouncy. The garage said it was the struts, so I replaced the struts, but the problem persists. 2 weeks later I took the car back. They said there was nothing wrong with t he tire. They rebalanced them. But that did not fix the problem. I took the car to a different garage and they told me the tires where bad and advised me to take them back to wherebI purchased them. I did. After they had my car for 6 hours they said there was nothing wrong with the tires. I insisted that they inspected them again. After 3 more hours they informed me that the tires were separating and they were defective. They replaced the tires with another brand.

Incident: June 20, 2026 · Filed: August 3, 2026

Before o had taken my RAV4 into Toyota for the recall a AAA tech. had replaced the battery after jump starting it. There was nothing wrong with the sensors or anything else but after the battery was replaced all the electric sensors that are for lane change warnings and cruise control etc. stopped working. I took vehicle into Toyota of Santa Maria and was told that I needed to pay for the sensors that had failed. They told me that I was responsible and I do not believe I am when AAA had just replaced my battery and only after that did the sensors have an issue. I do not feel safe driving my car now because all the sensors aren’t working anymore.

Incident: March 15, 2026 · Filed: July 28, 2026

The contact owns a 2018 Toyota Rav4. The contact stated that while in reverse(R), the rear-view camera was black and failed to operate as intended. The vehicle was taken to a dealer where it was diagnosed and determined that the camera was inoperable and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and a complaint was filed. The failure mileage was approximately 40,000.

Incident: July 10, 2026 · Filed: July 10, 2026

The hands free feature over the cars microphone/stereo is unusable; leaving vehicle owners frustrated, and more likely to operate cellphones outside of standard hands free practices. I have been on numerous phone calls where people have told me that they were unable to hardly hear a thing I was saying. To remedy this problem I have 1. Tried speaking up (even yelling) 2. Turning off HVAC systems 3. Positioning my body closer to the microphone 4. Bringing the car to a slow or stop to reduce road noise. 5. Calling myself to see if I can hear myself. 6. Talked with someone who owns the same car (year/model/spec/trim) and they were hardly audible as they called me over their hands free system.

Incident: June 19, 2026 · Filed: July 5, 2026

While I am driving my Toyota RAV4, the car will suddenly shut off and I can restart it and keep driving as the month is going on. The incidents are happening more often and now the dashboard is going black. I’ve had a couple of warning signs on the dashboard. I brought the car to Toyota and Pep Boys. Both of them checked the electrical systems and everything looks good according to their testing.

Incident: June 12, 2025 · Filed: June 27, 2026

My lift tailgate is malfunctioning. Continued forced opening can cause the hinges to crack and messes with the alignment and closing of the tail gate making it a safety issue.

Incident: June 21, 2026 · Filed: June 21, 2026

We were part of a 4 car collision on the freeway. A Ford Expedition that was slammed into then slammed into our RAV. The airbags never deployed and an error code came up saying fail for airbags.

Incident: May 1, 2026 · Filed: May 28, 2026

Severe, chronic rainwater intrusion through the vehicle's front cowl and body seams, resulting in catastrophic flooding of the passenger-side cabin floorboards. This issue occurs even when all sunroof drains are completely clear and functional. Toyota has issued Technical Service Bulletin 0055-24 acknowledging body seam and cowl leaks for this vehicle type. The passenger-side floorboard houses critical electrical wire harnesses and sits adjacent to the Supplemental Restraint System (SRS/Airbag) control module. Chronic standing water on the floorboard presents an immediate risk of electrical short-circuits, potentially causing sudden vehicle stalling, electrical component fires, or the uncommanded deployment/failure of the vehicle's airbag safety systems. Furthermore, the thick foam insulation beneath the carpet remains saturated, creating an immediate, toxic mold hazard within an enclosed passenger cabin, severely impacting occupant health and air quality. The manufacturer and dealership have left the vehicle unrepaired for over 30 days, refusing to remediate this safety hazard.