2009 GMC Sierra 1500 Recalls, Ratings & Complaints

Incident: January 4, 2026 · Filed: February 11, 2026

This letter serves as a formal notice of concern and demand for accountability regarding the 2009 GMC Sierra LD, VIN [XXX] , owned by [XXX] . There are numerous documented complaints and safety investigations concerning premature tie rod failure in 2009 GMC Sierra models. While the 2009 model year may not have been subject to a sweeping, industry-wide recall specific to tie rods in the 1500 series, it is undeniably and consistently associated with premature steering component failure — including both inner and outer tie rods. The refusal to proactively address this defect, assign a broader recall, or take ownership of the recurring issue reflects a troubling disregard for consumer safety. Documented and Reported Issues Include: • Premature Wear: Tie rods becoming loose or failing between 50,000–100,000 miles, resulting in steering wander and excessive play in the steering wheel. • Clunking/Knocking Noises: Audible front-end knocking at low speeds, a well-known symptom of failing tie rod joints. • Severe Safety Risk: Instances where tie rods have separated or become dangerously compromised, directly affecting steering control. • Uneven Tire Wear: Excessive inner or outer tire edge wear caused by steering instability. • Recall 14V-246000: A related recall acknowledging improper tightening of tie rods where they thread into the steering gear rack — a defect that could cause separation and loss of steering control. The common symptoms — steering vibration, looseness, clunking when turning, and vehicle pulling due to misalignment — are not minor inconveniences. They represent serious safety hazards that endanger drivers, passengers, and the public. It is unacceptable for GMAC and General Motors to minimize or compartmentalize this issue when patterns clearly demonstrate a systemic steering component weakness in this model year. The presence of Recall 14V-246000 further demonstrates that the manufacturer was aware of tie rod-related risks ! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident: October 3, 2025 · Filed: November 4, 2025

Early October my passenger side airbag deployed and I was sitting in the drivers seat and had just put the key into the key hole but did not turn the key to start the vehicle. 3 weeks later I was going into the passenger side of the vehicle and the key was in my pocket and the drivers side airbag deployed. Both times the vehicle was not started and the airbags deployed I called GMC and they had the vehicle towed to a dealer to investigate why the airbags deployed. They said it was a sensor that was corroded and that’s why the airbags deployed. I asked GMC, why didn’t the sensor left the driver know that it was going bad, just like it notifies the driver if you have low tire pressure or needs an oil change. I had no notifications that the airbags were going to deploy. I’m so grateful that no one was driving the vehicle when they deployed. GMC said the vehicle is not safe to drive so they had it towed from my house to the dealership and then back to my house however they said they are not taking responsibility for the deployment and said it’s my responsibility to get the airbags fixed. I told GMC that I was filing a complaint with you all. Thank you for looking into this matter.

Incident: July 8, 2013 · Filed: August 18, 2025

The contact owns a 2009 GMC Sierra 1500. The contact stated that while driving at highway speeds, the vehicle hesitated while depressing the accelerator pedal. The traction control and check engine warning lights were illuminated. The contact used a code reader and discovered a misfire in cylinder #4, and performed a compression test, which verified that cylinder #4 was failing to maintain compression. The vehicle was taken to a dealer where it was discovered that there was a failure with the lifter in cylinder #4. The vehicle was not repaired and remained with the dealer for additional diagnostic tests. The manufacturer was notified of the failure but offered no assistance. The contact was referred to the NHTSA Hotline to report the failure. The failure mileage was approximately 56,000.

Incident: June 5, 2016 · Filed: June 18, 2025

To Whom It May Concern, I am submitting this report regarding repeated engine and valve lifter failures in my 2009 GMC Sierra 1500 with a 5.3L V8 engine, VIN: [XXX] . 1. Component/System Malfunctioned: Both the original engine and a replacement engine—professionally installed by a Chevrolet dealership—experienced valve lifter failure related to the Active Fuel Management (AFM) system. The most recent failure was sudden and unexpected. The engine may be available for inspection upon request. 2. Safety Risk: Engine failure puts driver and passenger safety at serious risk, particularly if the vehicle loses power unexpectedly while in motion. In both instances, the failure created unsafe driving conditions. 3. Reproduction/Confirmation: The issue was confirmed by a Chevrolet dealership during the initial engine failure and again more recently on the current engine, which is now exhibiting the same failure. 4. Inspection Status: The vehicle has been inspected by the same dealership that performed the original engine replacement. To my knowledge, it has not been inspected by GM corporate, police, or insurance representatives. 5. Warning Signs: There were no warning lamps, messages, or clear symptoms prior to the failure. The problem occurred without advance notice and did not provide an opportunity to address it before damage occurred. This is the second engine failure my truck has suffered from the same issue, even after dealership installation of a new motor. I urge the NHTSA to investigate whether this represents a broader defect in GM 5.3L AFM-equipped engines. It is unacceptable that repeated critical failures can occur in these engines with no warning and no resolution, even after following proper replacement procedures. Thank you for your attention. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident: January 1, 2020 · Filed: March 11, 2025

Allison transmission - random hard shifts, random multiple DTC's, random limp mode. Clear codes and works fine until it doesn't. Might have to clear codes 3-4 times a day or it might make it a week before it goes into limp mode again.

Incident: December 23, 2024 · Filed: December 23, 2024

General Published an article about the Takata Airbag recall stating that the dashboard would be inspected prior to doing the recall work and if already cracked or damaged the dashboard would not be replaced. My dash board is like new with no damage or cracks. The dealer told me (contrary to this article) that if their service men damaged my dashboard while doing the recall replacement I would be responsible for any replacement even if my dashboard is in perfect condition prior to the work. I find this unacceptable and will not have my airbag replaced under these conditions. The dealer/GM should be responsible for any damage they cause during the repair.

Incident: December 29, 2023 · Filed: January 7, 2024

TCM and electrical transmission grounded out TCM IN MY RESEARCH a lot of people are having issues with these. Dealers are of no help “backordered” so having to rebuild them. This is an expensive failure!

Incident: July 29, 2023 · Filed: July 31, 2023

While driving on Saturday, July 29th, I went to make a right turn @ intersection of Nottingham Way onto Ledo Rd. The vehicle started jerking and suddenly shutoff. I had no power steering, No power brakes. I had to manually steer and stop the truck into the median, while avoiding oncoming traffic. I got the vehicle to stop. I tried to restart and the engine turned over, but would not start. I contacted the local Chevrolet dealership, and was told they don't work on anything older than 2013 vehicles. I had the truck towed to the house. After further investigation, there was a service bulletin 14515B, that replaced 14515A. The Safety recall stated CHASSIS ELECTRONIC CONTROL MODULE INTERNAL CONTAMINATION. So GM is aware of this issue, that could have caused an accident. The local dealership is denying that my truck is involved in this recall. They knew of the problem and never contacted me about this issue. This is a severe SAFETY issue. GM should be responsible for repairing a defective Control module as they knew of contamination as of January 2015. This almost cause multiple head on collisions.

Incident: May 2, 2022 · Filed: May 2, 2023

Door panel gets loose over time catching on inside of door frame making it difficult to open a door. This is a safety hazard in the case of an emergency so I removed my door panel completely.

Incident: April 23, 2023 · Filed: April 25, 2023

The contact's father owns a 2009 GMC Sierra. The contact stated that while his father was making a left turn at 20 MPH, another vehicle from the opposite direction ran the red light and struck the contact's father's driver's side front end. The TPMS warning light was illuminated. None of the air bags deployed upon impact. The contact's father suffered rib, pelvis, and spine fractures and was transported to the hospital by ambulance. A police report was filed. The vehicle was towed to a tow yard but was not yet inspected or deemed totaled by the insurance company. The manufacturer was not made aware of the failure. The failure mileage was unknown.