NHTSA vehicle safety data

2005 GMC Sierra 1500 Recalls & Complaints

The 2005 GMC Sierra 1500 has 3 NHTSA recall campaigns and 177 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized GMC dealer.

NHTSA recall and complaint data for the 2005 GMC Sierra 1500. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2005 GMC Sierra 1500 owner complaints

Owners have filed 177 complaints with NHTSA about the 2005 GMC Sierra 1500, describing incidents dated February 16, 2005 to May 2, 2025.

Most-cited components

Electrical System 67 complaints
Service Brakes 50 complaints
Steering 18 complaints
Air Bags 14 complaints
Engine 14 complaints
Power Train 11 complaints

Of the 177 complaints on file, 4 report a crash and 9 a fire; across all 177 complaints, owners report 5 injuries (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11675355 · Filed July 22, 2025
See attached document for complaint.
ODI #11541802 · Filed August 31, 2023
Instrument panel stops working from time to time. My Guages go crazy. My rpm and speedometer mess up and can't tell how fast I'm going. This has been going on for a few years now. My airbag sensor light is on and was In a light wreck few months ago. Hit pretty hard on front end of truck and yet…
ODI #11497157 · Filed December 12, 2022
The brakes , air bag, wheel hubs, lights, alignment, power steering. brakes coming to a stop instantly stops the vehicle. Air bag light comes on. Wheels hubs towed in from top. Light switch will not turn light off when driving. Alignment, steering wheel goes everywhere. Front tire getting wore out…

Read all 177 complaints

Owner-reported

2005 GMC Sierra 1500 mileage at failure

157 of the 177 complaints on file for the 2005 GMC Sierra 1500 give the vehicle's mileage when the problem happened.

Mileage at failure by component, from owners' complaints to NHTSA
Component	Median	Middle half	Based on
Electrical System	Median 70,000 miles	Middle half 50,000–100,000 miles	Based on 59 complaints
Service Brakes	Median 60,000 miles	Middle half 35,000–100,000 miles	Based on 48 complaints

A component's median is its 50th percentile, and its middle half runs from its 25th to its 75th percentile.

Owners give the mileage themselves, often as a round number, and NHTSA doesn't check it. A complaint that names several components counts under each one, and mileages that can't be right, such as 999,999, or 50 miles on a five-year-old car, are left out.

These figures describe the complaints owners filed. They don't predict when a particular vehicle will have a problem, and vehicles that never had one aren't counted.

Mileage from NHTSA's complaints file of October 31, 2026. How these figures are worked out

REPLACEMENT WHEEL HUB ASSEMBLIES

NHTSA #07E106000 · Wheels — Hub · NHTSA notice

Reported December 17, 2007 · FEDERAL-MOGUL CORPORATION

Potentially affected: 130,000 vehicles

Owners notified February 7, 2008

Defect description

CERTAIN FEDERAL-MOGUL REPLACEMENT WHEEL HUB ASSEMBLIES WITH THE BRAND NAMES: NATIONAL, CARQUEST P/NOS. 515020, 515021, 515025, 515053, 515054, 515059, AND 515060, SHIPPED BETWEEN JANUARY 23, 2006, AND DECEMBER 20, 2007, SOLD FOR LIGHT DUTY AND MEDIUM DUTY TRUCKS. THE INBOARD RETENTION NUT USED TO MAINTAIN HUB BEARING ASSEMBLY CAN LOOSEN RESULTING IN AN ABS LIGHT INDICATION, NOISE, AND/OR WHEEL SEPARATION.

Safety consequence

WHEEL SEPARATION CAN RESULT IN A VEHICLE CRASH.

Manufacturer remedy

FEDERAL-MOGUL WILL NOTIFY CUSTOMERS AND WILL REPLACE THE HUB ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 7, 2008. OWNERS CAN CONTACT FEDERAL-MOGUL TOLL-FREE AT 877-489-6659.

Notes

THIS RECALL ONLY PERTAINS TO REPLACEMENT NATIONAL, CARQUEST WHEEL HUB ASSEMBLIES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS OR FORD.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

AFTERMARKET HUB ASSEMBLIES

NHTSA #06E050000 · Service Brakes, Air · NHTSA notice

Reported June 6, 2006 · FEDERAL-MOGUL CORPORATION

Potentially affected: 6,800 vehicles

Defect description

CERTAIN FEDERAL-MOGUL NATIONAL AND CARQUEST AFTERMARKET HUB ASSEMBLIES, P/N 515058, SOLD FOR USE ON 2001-2006 GENERAL MOTORS 1500 AND 2500 4WD TRUCKS. ON THE SUBJECT HUB ASSEMBLIES, THE ABS SENSOR CORD DEPARTS FROM THE HUB ASSEMBLY AT A 90 DEGREE ANGLE. AS A RESULT, THERE IS A FIT ISSUE WITH THE BRAKE ROTOR DUST SHIELD INTERFERING WITH THE ABS SENSOR CORD. IF THE HUB ASSEMBLY IS INSTALLED DESPITE THIS INTERFERENCE, THE GAP BETWEEN THE ABS SENSOR AND THE TONE WHEEL MAY BE ALTERED. THIS MAY WEAKEN THE OUTPUT OF THE ABS SENSOR. DIMINISHED OUTPUT COULD RESULT IN AN UNWANTED ABS ACTIVATION AT LOW SPEEDS AND STOPPING DISTANCE COULD BE AFFECTED.

Safety consequence

IF STOPPING DISTANCE IS LIMITED, A VEHICLE CRASH COULD OCCUR.

Manufacturer remedy

FEDERAL-MOGUL WILL NOTIFY ITS OWNERS AND WILL EITHER CREDIT THE CUSTOMERS ACCOUNT OR REPLACE THE UNIT. THE RECALL IS EXPECTED TO BEGIN DURING JUNE 2006. OWNERS CAN CONTACT FEDERAL-MOGUL CUSTOMER SERVICE AT 1-800-563-8507 EXT 3530.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET NATIONAL AND CARQUEST HUB ASSEMBLIES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

AFTERMARKET FUEL FILTERS/FUEL LEAK

NHTSA #06E043000 · Fuel System, Gasoline · NHTSA notice

Reported May 19, 2006 · HONEYWELL INTERNATIONAL, INC.

Potentially affected: 88,303 vehicles

Owners notified October 18, 2006

Defect description

CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.

Safety consequence

THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.

Manufacturer remedy

HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

try.vin has no NCAP crash-test rating on file for the 2005 GMC Sierra 1500. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

177 owner complaints have been filed with NHTSA for the 2005 GMC Sierra 1500.

Wheels; Firerelated

ODI #11675355

Fire

Incident: May 2, 2025 · Filed: July 22, 2025

See attached document for complaint.

Electrical System; Air Bags

ODI #11541802

Incident: January 6, 2017 · Filed: August 31, 2023

Instrument panel stops working from time to time. My Guages go crazy. My rpm and speedometer mess up and can't tell how fast I'm going. This has been going on for a few years now. My airbag sensor light is on and was In a light wreck few months ago. Hit pretty hard on front end of truck and yet neither one of my airbags deployed.

Steering; Air Bags; Service Brakes

ODI #11497157

Incident: May 10, 2022 · Filed: December 12, 2022

The brakes , air bag, wheel hubs, lights, alignment, power steering. brakes coming to a stop instantly stops the vehicle. Air bag light comes on. Wheels hubs towed in from top. Light switch will not turn light off when driving. Alignment, steering wheel goes everywhere. Front tire getting wore out . Power steering leaking oil.

Air Bags

ODI #11421595

Incident: June 8, 2021 · Filed: June 21, 2021

My srs air bag light was first intermediate now it stays on all the time I am so in fear of my life while driving my 2005 GMC Sierra sle ext-cab my truck is now 16 years old and this safty light recently came on I purchased a srs scanner and it shows (OPEN FRONTAL LOOP) I NEED ANY RECALL INFORMATION FOR I CAN GET IT REPAIRED

Electrical System

ODI #11354089

Incident: September 9, 2020 · Filed: September 10, 2020

STARTED MY TRUCK AND THE FAILURE ELECTRICAL SYSTEM CAME ACROSS I PUSHED IN THE BOTTON THAT CHANGES IT AND CAME BACK ON THEN IT SAID TIGHTEN FUEL CAP WASHER FLUID LOW I HIT THE BUTTON AGAIN IT WENT OF BUT BATTERY LIGHT STAYED ON AND GAUGE READ ABOUT 10 VOLTS.MY TRUCK RAN FINE AND STARTED WHEN I GOT TO MY FIRST THEN AT THE SECOND STOP IT SAID THE SAME , I PUT IN REVERSE BACKED OUT PUT IT DRIVE AND THE CLUSTER QUICK WORKING THE AC QUIT YOU COULD ROLL THE WINDOWS DOWN NOR DID THE LOCKS WORK AND IT DID NOT ANY POWER WHEN PUSHED DOWN THE GAS PED2 TO COME UP A HILL IT FELT LIKE IT SHIFTED WHEN YOU LET OFF THE PEDAL YOU COULD FEEL JERK, GO HOME TURNED IT AND WOULD NOT START OR MAKE ANY SOUND NOT EVEN THE CLICKING ON THE STARTER, SO I LEFT HOME AND CAME BACK ABOUT 4 HOURS LATER AND IT STARTED BUT THE VOLT READ ABOUT 10 VOLTS. I HAD THE BATTERY TESTED AND IT TEST GOOD. THIS WAS ON SEPTEMBER 9, 2020 I HAVE PUT THE BATTERY BACK IN YET.

Steering; Exterior Lighting; Seat Belts

ODI #11337285

Incident: May 19, 2012 · Filed: July 3, 2020

THE STEERING IS EXTREMELY LOSE WHERE I CAN TURN THE WHEEL ALMOST HALF WAY BEFORE IT TURNS THE TIRES. THE HEADLIGHTS MOVE CONSTANTLY AFTER BEING ADJUSTED AND MAKE IT NEARLY IMPOSSIBLE TO SEE AT NIGHT. THE 4WHEEL DRIVE BOX IS CONSTANTLY THROWING THE TRUCK INTO 4WHEEL AUTO AND 4WHEEL LOW WITHOUT WARNING, WHATCHA IS VERY DANGEROUS WHEN ENTERING THE INTERSTATE

Exterior Lighting

ODI #11326111

Incident: May 12, 2020 · Filed: May 27, 2020

PASSENGER HEADLIGHT WILL NOT TURN ON. BOTH LOWBEAM AND HIGH BEAM DON?T TURN ON. BULB IS IN WORKING CONDITION, FUSES ARE NOT BLOWN, CAN?T SEEM TO FIND A SOLUTION. THIS MAKES THE VEHICLE VERY DANGEROUS WITH NO RIGHT SIDE VISIBILITY. UNKNOWN REASON BEHIND THE PROBLEM. *TR

Suspension

ODI #11244207

Incident: February 16, 2005 · Filed: August 15, 2019

WHEN BOUGHT NEW, BETWEEN 40 AND 60 MPH THERE IS A BOUNCING IN THE SUSPENSION. FIX WAS TO PLACE 400 LBS JUST BEHIND THE TAILGATE. I PUT 330 LBS ACROSS THE REAR AXIAL WITH GOOD BALANCED TIRES. BEEN THIS WAY SINCE 2005 AND IT'S A STUPID FIX.

Electrical System

ODI #11218538

Incident: May 30, 2019 · Filed: June 7, 2019

THE PASSIVE ALARM SYSTEM IS MALFUNCTIONING APROX EVERY 10 CRANKS. WHEN THIS HAPPENS YOU ARE STUCK FOR AT LEAST A HOUR BEFORE IT WILL START. DEALERSHIP CAN NOT FIND THE PROBLEM AND A COMPLAINT WAS MADE TO GMC COMPLAINT DEPARTMENT I HAVE CHANGED NUMEROUS PARTS M SWITCHES AND BOXES ,

Air Bags

ODI #11210594

Incident: May 12, 2019 · Filed: May 29, 2019

TL* THE CONTACT OWNS A 2005 GMC SIERRA 1500. THE CONTACT STATED THAT THE AIR BAG WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO REFERRED THE CONTACT TO NHTSA. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE FAILURE MILEAGE WAS 156,000.

Other GMC Sierra 1500 model years

Check your 2005 GMC Sierra 1500 VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your GMC Sierra 1500 at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a GMC VIN