NHTSA vehicle safety data

2008 GMC Sierra 1500 Recalls & Complaints

The 2008 GMC Sierra 1500 has 2 NHTSA recall campaigns and 381 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized GMC dealer.

NHTSA recall and complaint data for the 2008 GMC Sierra 1500. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2008 GMC Sierra 1500 owner complaints

Owners have filed 381 complaints with NHTSA about the 2008 GMC Sierra 1500, describing incidents dated November 19, 2007 to July 27, 2026.

Most-cited components

Air Bags 243 complaints
Unknown or Other 41 complaints
Electrical System 31 complaints
Structure 25 complaints
Latches/Locks/Linkages 23 complaints
Engine 20 complaints

Of the 381 complaints on file, 12 report a crash and 5 a fire; across all 381 complaints, owners report 16 injuries (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11759983 · Filed August 27, 2026
The contact owns a 2008 GMC Sierra 1500. The contact stated that while driving at approximately 30 MPH and towing a camper, the vehicle began to bounce while navigating curves. The traction control warning light illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed…
ODI #11757393 · Filed August 17, 2026
The contact owns a 2008 GMC Sierra 1500. The contact stated that while driving 5 MPH with her husband and grandson inside the vehicle and entering the driveway at the residence, there was an abnormally loud explosion coming from inside the vehicle and the driver’s side seat belt tightened…
ODI #11726399 · Filed March 23, 2026
I was driving down the highway at 70 mph, when there was a loud bang followed by a gun powder smell. My seatbelts went tight...hazard lights automatically came on...radio went dead...and the Airbag light came on. The pretensioners in both driver and passenger seats had deployed. I pulled over and…

Read all 381 complaints

Owner-reported

2008 GMC Sierra 1500 mileage at failure

193 of the 381 complaints on file for the 2008 GMC Sierra 1500 give the vehicle's mileage when the problem happened.

Mileage at failure by component, from owners' complaints to NHTSA
Component	Median	Middle half	Based on
Air Bags	Median 85,000 miles	Middle half 50,000–125,000 miles	Based on 79 complaints

A component's median is its 50th percentile, and its middle half runs from its 25th to its 75th percentile.

Owners give the mileage themselves, often as a round number, and NHTSA doesn't check it. A complaint that names several components counts under each one, and mileages that can't be right, such as 999,999, or 50 miles on a five-year-old car, are left out.

These figures describe the complaints owners filed. They don't predict when a particular vehicle will have a problem, and vehicles that never had one aren't counted.

Mileage from NHTSA's complaints file of October 31, 2026. How these figures are worked out

NHTSA defect investigations

NHTSA's investigations file lists the 2008 GMC Sierra 1500 in 3 investigations. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Engineering Analysis EA21-002: Desiccated Air Bag Inflator Rupture
Open since September 17, 2021
Engineering Analysis EA08-010: NON-CRASH ENGINE COMPARTMENT FIRES
Closed September 8, 2008
- Recall 08V-441
Preliminary Evaluation PE08-010: NON-CRASH ENGINE COMPARTMENT FIRES
Closed June 12, 2008

Open and recently closed NHTSA defect investigations

Passenger Frontal Air Bag Inflator May Explode

NHTSA #21V050000 · Air Bags — Frontal — Passenger Side — Inflator Module · NHTSA notice

Reported February 5, 2021 · General Motors, LLC

Potentially affected: 2,641,272 vehicles

Repair completion: 44.01% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign N212328760 · Owners notified March 1, 2021 · Recall influenced by NHTSA's Office of Defects Investigation

Recall group: Takata airbag inflators

Defect description

General Motors, LLC (GM) is recalling certain 2007-2011 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, Yukon XL, and 2009-2011 Chevrolet Silverado 2500, Silverado 3500, GMC Sierra 2500 and Sierra 3500 vehicles originally sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, GM is recalling certain 2007-2008 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, Yukon XL vehicles originally sold, or ever registered, in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." These vehicles are equipped with non-desiccated passenger frontal inflators containing phase-stabilized ammonium nitrate (PSAN) propellant. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Safety consequence

An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

Manufacturer remedy

GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 22, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed on March 1, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328760.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Passenger Frontal Air Bag Inflator May Explode

NHTSA #21V052000 · Air Bags — Frontal — Passenger Side — Inflator Module · NHTSA notice

Reported February 5, 2021 · General Motors, LLC

Potentially affected: 557,023 vehicles

Repair completion: 54.81% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign N212328780 · Owners notified September 20, 2021 · Recall influenced by NHTSA's Office of Defects Investigation

Recall group: Takata airbag inflators

Defect description

General Motors, LLC (GM) is recalling certain 2009 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500, Sierra 3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Additionally, GM is recalling certain 2007-2008 Cadillac Escalade, Escalade ESV, and Escalade EXT, Chevrolet Avalanche, Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming or "Zone C." These vehicles are equipped with non-desiccated passenger frontal inflators containing phase-stabilized ammonium nitrate (PSAN) propellant. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Safety consequence

An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

Manufacturer remedy

GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 23, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed on September 20, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020, Cadillac customer service at 1-800-458-8006, and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328780.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

try.vin has no NCAP crash-test rating on file for the 2008 GMC Sierra 1500. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

381 owner complaints have been filed with NHTSA for the 2008 GMC Sierra 1500.

Traction Control System; Engine

ODI #11759983

Incident: July 27, 2026 · Filed: August 27, 2026

The contact owns a 2008 GMC Sierra 1500. The contact stated that while driving at approximately 30 MPH and towing a camper, the vehicle began to bounce while navigating curves. The traction control warning light illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed that the engine variable displacement lifter pins had failed. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 157,000. The VIN was unavailable.

Seat Belts

ODI #11757393

3 injuries

Incident: June 15, 2026 · Filed: August 17, 2026

The contact owns a 2008 GMC Sierra 1500. The contact stated that while driving 5 MPH with her husband and grandson inside the vehicle and entering the driveway at the residence, there was an abnormally loud explosion coming from inside the vehicle and the driver’s side seat belt tightened unexpectedly. The contact was able to park the vehicle. The contact sustained bruising to the chest. The contact looked at her husband and became aware that the passenger’s side seat belt had tightened and there was blood dripping on the left side of the face, and her grandson had a bruise on the inner thigh. The contact took her husband to the Emergency Room for several fractured ribs. The contact’s grandson smelled an abnormal burning odor and became aware that the front passenger’s side seat belt was smoking. There was no warning light illuminated. The vehicle was towed to the dealer to a dealer to be diagnosed. The vehicle was diagnosed with a seat belt pre-tensioner failure. The contact was informed that the seat belt pre-tensioner needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and opened a case. The failure mileage was 208,809.

Seat Belts

ODI #11726399

Incident: March 3, 2026 · Filed: March 23, 2026

I was driving down the highway at 70 mph, when there was a loud bang followed by a gun powder smell. My seatbelts went tight...hazard lights automatically came on...radio went dead...and the Airbag light came on. The pretensioners in both driver and passenger seats had deployed. I pulled over and shut the truck off, to get out and inspect it. There was no warning, and luckily I was composed enough to not wreck into anyone or anything. I see there have been a few similar incidents, so I'm glad this isn't just a solitary incident.

Fuel System, Diesel

ODI #11724596

Incident: February 23, 2026 · Filed: March 16, 2026

The contact owns a 2008 GMC Sierra 1500. The contact stated that while the vehicle was parked in the garage, diesel fuel started leaking onto the garage floor. The contact recently purchased the vehicle, inspected the source of the leak, and discovered that the fuel lines were completely rusted. Additionally, the contact stated that after refueling the vehicle, the fuel level lowered to half a tank the following day, creating a hazard. The vehicle was towed to a dealer but had not yet been diagnosed. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 163,000.

Air Bags

ODI #11691910

Incident: October 7, 2025 · Filed: October 7, 2025

The contact owns a 2008 GMC Sierra 1500. The contact received notification of NHTSA Campaign Number: 21V050000 (Air Bags). The local dealer was contacted and informed the contact about the disclaimer about the dashboard possibly being damaged. The dealer informed the contact that there were no loaner vehicles, but then called back and offered a loaner. The manufacturer was contacted and filed a clai,m and referred the contact to another local dealer. The contact called the other local dealer, Ferman Chevrolet of Tarpon Springs (43520 US Hwy 19 N, Tarpon Springs, FL 34689), who confirmed there was a disclaimer related to the recall repair. The contact had not experienced a failure.

Air Bags

ODI #11683498

Incident: August 27, 2025 · Filed: August 27, 2025

The contact owns a 2008 GMC Sierra 1500. The contact received notification of NHTSA Campaign Number: 21V050000 (Air Bags); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

Electrical System

ODI #11682921

Incident: April 7, 2025 · Filed: August 25, 2025

Odometer Fraud. The contact purchased a 2008 GMC Sierra 1500. The contact discovered a mileage discrepancy after the purchase. The vehicle was a private sale. At the time of purchase, the vehicle mileage was 126,498. It was later discovered that the mileage on the title was approximately 250,205.

Air Bags

ODI #11682073

Incident: October 10, 2020 · Filed: August 21, 2025

I have contacted Blaise Alexander in muncy pa 17756 in 2020 or 2021 and they told me that the part was on back order they would contact me when the part has come in 5 years later they still have not contacted me I have reached out by phone through email and Facebook messenger to set up a time to fix my 2008 gmc sierra and haven’t heard anything well last week my service air bag soon light came on and I am very nervous about that so I will not drive the truck I would like to file a formal complaint and have this taken care of please

Air Bags; Visibility/Wiper

ODI #11666843

Incident: June 13, 2025 · Filed: June 13, 2025

Driving down the road on way home from work airbags blew out. The one in the steering wheel and the one on the passenger side. It busted windshield on passenger side. Shards of stuff all over dash on passenger side. That airbag popped 2 times.

Air Bags

ODI #11664061

Crash

Incident: March 25, 2025 · Filed: May 31, 2025

Air bags did not deploy when another vehicle hit truck on front passenger side at 35-40 mph

Other GMC Sierra 1500 model years

Check your 2008 GMC Sierra 1500 VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your GMC Sierra 1500 at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a GMC VIN