2020 Ford Ranger Recalls, Ratings & Complaints

Incident: October 5, 2026 · Filed: October 12, 2026

I have clicking dashboard blend door ford SS50629/51313. Its the climate control housing box .I have no defrost on driver side or heat.ford knows but wont do a recall.

Filed: October 4, 2026

Supposedly, Ford knows that the 10-speed transmission has problems and they have done stuff for the F-150 models, but they aren't doing nothing for the Ranger models. Transmission slips and eventually fails causing a very expensive replacement

Incident: August 1, 2026 · Filed: September 28, 2026

I own a 2020 Ford Ranger equipped with dual-zone automatic climate control, with approximately 50,000 miles. The HVAC system has developed a failure that prevents the driver’s side from producing adequate heat. When both temperature controls are set to maximum heat and MAX defrost is selected, the driver’s side produces cold air with significantly reduced airflow compared with the passenger side, which produces hot air with strong airflow. I have tested the dashboard vents, floor vents and windshield defroster. The driver’s side consistently produces colder air and reduced airflow in all three modes. Previously, I heard repeated clicking or knocking noises from behind the dashboard. The temperature controls no longer appear to operate correctly on the driver’s side. I am concerned that this failure will prevent the driver’s side of the windshield from defrosting and defogging adequately during cold weather, potentially obstructing my visibility while driving. Ford has issued service message SSM 51313, NHTSA document 10230940, concerning temperature-control failures and clicking noises in certain 2019–2020 Rangers. The bulletin directs replacement of the air distribution housing/heater assembly for the described condition. I contacted Ford customer service regarding assistance with this repair, but Ford declined to provide financial assistance. I am reporting this as a potential safety defect because the HVAC failure may compromise windshield visibility in freezing or humid conditions.

Incident: September 4, 2026 · Filed: September 4, 2026

Left rear leaf spring broke at the axel. When left the house truck was acting funny. Crossed a RR track and the truck became eratic/hard to steer. Pulled into shop across the street. They inspected the truck and found the broken spring. No rust, just a clean break.

Incident: August 14, 2026 · Filed: August 28, 2026

While driving my 2020 Ford Ranger, the transmission has repeatedly exhibited unexpected and unintended gear changes, including sudden downshifts or gear changes without driver input, hesitation, and abrupt loss of power during acceleration. These problems have occurred during highway merging, pulling into traffic, and city driving. On 08/14/2026, while accelerating to pull into traffic, the vehicle suddenly lost power, creating a hazardous situation as vehicles approached from behind. I have also experienced instances in which the transmission unexpectedly shifted or hesitated without warning, causing the vehicle to lurch or slow unpredictably in traffic. This condition creates a serious safety hazard because an unexpected loss of power or unintended gear change can prevent the vehicle from accelerating when needed, such as when merging, passing, pulling into traffic, or avoiding a collision. The unpredictable behavior increases the risk of a crash and endangers both the driver and surrounding motorists. The vehicle was taken to Crossroads Ford of Indian Trail on 08/14/2026, where it was diagnosed with a failed or failing 10R80 automatic transmission. At the time, the vehicle had approximately 57,500 miles and was approximately 5 years and 7 months old, which is 7 months beyond the manufacturer's bumper-to-bumper warranty. I have maintained the vehicle according to Ford's recommended service schedule throughout my ownership. I am aware that Ford has issued prior service bulletins and customer satisfaction programs related to 10R80 transmission issues, including TSB 18-2274, 20-2339, 22-2139, 23-2250, and 24-2254, although I have not confirmed whether any of them directly apply to this VIN. I am filing this complaint because the symptoms I experienced—unexpected gear changes, hesitation, lurching, and sudden loss of power—present an immediate safety risk to me, my passengers, and other drivers on the road.

Incident: May 4, 2026 · Filed: August 11, 2026

1. Transmission is going out dealership never said a word about the 6 recalls on it one being transmission 2. Front seat belts are in backwards and the child safety hook in back seat has a recall on it that the 3 of the 6 I know of Ford had told alm to replace the entire transmission before they ever sold it they did not do that they didn't take care of any of the recalls

Incident: August 9, 2026 · Filed: August 11, 2026

I was traveling south on I-35 going up a long steep hill and my transmission started to hard shift and then I would lose power and when I would accelerate, I had no power it would just stall out so I merged to the right side in case I had to pull over because I thought the engine had died. When I reached my destination, I looked under my truck to discover fluid on the under carriage at that point I knew the transmission had blown a seal or a high-pressure hose. So, I left the truck there and the next day had it towed back to my house. There were times I had slowed down so much that traffic almost hit me.

Incident: June 1, 2026 · Filed: July 29, 2026

Coolant intrusion defect that affects other 4 cyl ecoboost Ford engines occurred on this regularly serviced per Ford recommendations vehicle as well. Engine failure at highway speeds could cause a severe accident as the engine can seize when coolant mixes with the oil. The vehicle has been inspected by a Ford dealership. The only warning sign that there was a problem was a coolant temperature threshold exceeded warning.

Incident: July 21, 2026 · Filed: July 22, 2026

The truck is currently at a certified ford dealer for diagnosis with a drive train fault. I suspect it is transmission-related, but was not given the history of all stored, pending and history of the codes. The truck exhibits unprovoked forward acceleration/violent lunging when braking to a stop and when driving at low speeds, making intersection control dangerous. It also has severe delayed gear engagement, causing high engine RPM spikes followed by sudden gear slamming, creating a sudden loss of acceleration power while attempting to merge into active highway traffic. The transmission symptoms have been repeatedly reported to and reproduced by certified Ford franchises (Mullinax Ford and Coggin Deland Ford). Technicians previously performed superficial adaptive memory software clears (KAM resets) rather than fixing the physical mechanical defect, which has persisted. The vehicle has been inspected multiple times by factory-trained dealership technicians. The initial symptoms first appeared on May 25, 2023, when the vehicle had 38,575 miles (fully within the factory powertrain warranty window). Persistent symptoms include: 1. Harsh gear engagement/slamming at various speeds. 2. Delayed shifting with sudden RPM spikes before catching gears. 3. Sudden low-speed lurching and acceleration when slowing down. The vehicle has now triggered an active "Drivetrain Fault" warning lamp on the dashboard illumination cluster.

Incident: April 17, 2026 · Filed: July 14, 2026

Transmission replacement needed. Truck has been at dealership going on 3 months with continued delays. It was acknowledged cooperate was covering replacement now story changed that owner/myself having to pay $4000+. Cooperate covering $000 . Current owner/myself bought 2 years ago with 13000 miles and has only put 6000 miles on it. Dealership and cooperate admitted to known problem assured coverage however put fixing on hold because they are behind due to staffing issues. I have been bounced around to 3 different people at dealership who have taken case over. Dealership and cooperate blaming each other for lack if communication and delays.