NHTSA vehicle safety data

2003 Ford Ranger Recalls, Ratings & Complaints

The 2003 Ford Ranger has 5 NHTSA recall campaigns and 243 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Ford dealer.

NHTSA recall and complaint data for the 2003 Ford Ranger, plus NCAP crash-test ratings. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2003 Ford Ranger owner complaints

Owners have filed 243 complaints with NHTSA about the 2003 Ford Ranger, describing incidents dated November 1, 2002 to July 14, 2025.

Most-cited components

Structure 43 complaints
Vehicle Speed Control 40 complaints
Service Brakes 34 complaints
Engine 27 complaints
Air Bags 25 complaints
Suspension 23 complaints

Of the 243 complaints on file, 37 report a crash and 11 a fire; across all 243 complaints, owners report 43 injuries and 1 death (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11673556 · Filed July 15, 2025
Ford knows about the problems with the dual clutch and they are refusing to fix them. I have been giving the run around om trying to get my car fixed. I am a disabled veteran and all I get is they can't help. I just found out about these cars have this problem and ford has know about his problem for…
ODI #11527592 · Filed June 18, 2023
Truck has no spare tire, totally missing the assembly and bracket originally used to hold the tire (have a junk one in the bed). The crossmember under the truck is about 50% intact is getting ready to fall off. Brake lines and rocker panals rotted out as well. Holes in the frame starting and a patch…
ODI #11517056 · Filed April 14, 2023
The frame of my truck has rotted through. The strap that holds the gas tank has nothing to connect to, i think the tank could fall to the ground under the right circumstances. The frame has a large whole in it and i fear it will break very soon. I had to remove the spare tire because i feared it…

Read all 243 complaints

Owner-reported

2003 Ford Ranger mileage at failure

182 of the 243 complaints on file for the 2003 Ford Ranger give the vehicle's mileage when the problem happened.

Mileage at failure by component, from owners' complaints to NHTSA
Component	Median	Middle half	Based on
Structure	Median 85,000 miles	Middle half 50,000–120,000 miles	Based on 33 complaints
Vehicle Speed Control	Median 50,000 miles	Middle half 9,000–100,000 miles	Based on 30 complaints

A component's median is its 50th percentile, and its middle half runs from its 25th to its 75th percentile.

Owners give the mileage themselves, often as a round number, and NHTSA doesn't check it. A complaint that names several components counts under each one, and mileages that can't be right, such as 999,999, or 50 miles on a five-year-old car, are left out.

These figures describe the complaints owners filed. They don't predict when a particular vehicle will have a problem, and vehicles that never had one aren't counted.

Mileage from NHTSA's complaints file of October 31, 2026. How these figures are worked out

NHTSA defect investigations

NHTSA's investigations file lists the 2003 Ford Ranger in 1 investigation. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Preliminary Evaluation PE05-066: BRAKE LIGHTS INOPERATIVE
Closed March 24, 2006

Open and recently closed NHTSA defect investigations

SPEED CONTROL DEACTIVATION SWITCH/OVERHEATS

NHTSA #09V399000 · Vehicle Speed Control · NHTSA notice

Reported October 13, 2009 · FORD MOTOR COMPANY

Potentially affected: 4,500,000 vehicles

Ford campaign 09S09 · Owners notified October 27, 2009 · Vehicles built January 5, 1994 – December 5, 2002 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Safety consequence

A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.

Manufacturer remedy

FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.

Notes

FORD'S RECALL CAMPAIGN NUMBER IS 09S09.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

FMVSS 108/REPLACEMENT HEADLAMPS/AMBER REFLECTOR

NHTSA #09E025000 · Exterior Lighting — Headlights · NHTSA notice

Reported May 11, 2009 · DOPE, INC.

Potentially affected: 42,540 vehicles

Owners notified July 28, 2009

Defect description

DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Safety consequence

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Manufacturer remedy

DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY DOPE, INC.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

FMVSS 108/AFTERMARKET COMBINATION LAMPS

NHTSA #09E012000 · Exterior Lighting · NHTSA notice

Reported April 7, 2009 · SABERSPORT

Potentially affected: 16,270 vehicles

Owners notified May 11, 2009

Defect description

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Safety consequence

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Manufacturer remedy

SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

FMVSS 108/AMBER SIDE REFLECTORS

NHTSA #06E065000 · Exterior Lighting · NHTSA notice

Reported July 17, 2006 · AJ MOTORSPORT

Potentially affected: 3,593 vehicles

Owners notified July 31, 2006

Defect description

CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Safety consequence

LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.

Manufacturer remedy

AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.

Notes

THIS RECALL ONLY PERTAINS TO AJ MOTORSPORT AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

FMVSS 108/AMBER SIDE REFLEX REFLECTORS

NHTSA #06E049000 · Exterior Lighting · NHTSA notice

Reported May 24, 2006 · CK MOTORSPORT, INC.

Potentially affected: 27,176 vehicles

Owners notified July 1, 2006

Defect description

CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Safety consequence

WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Manufacturer remedy

CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY THE VEHICLE MANUFACTURERS.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

2003 Ford Ranger Supercab

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 4, Passenger: 4

Side Crash

Not Rated

Driver: 4, Passenger: Not Rated

Side Pole

Not Rated

Rollover

Safety Technology

1 investigation

2003 Ford Ranger Regular Cab

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 4, Passenger: 4

Side Crash

Not Rated

Driver: 5, Passenger: Not Rated

Side Pole

Not Rated

Rollover

Safety Technology

1 investigation

243 owner complaints have been filed with NHTSA for the 2003 Ford Ranger.

Power Train

ODI #11673556

Incident: July 14, 2025 · Filed: July 15, 2025

Ford knows about the problems with the dual clutch and they are refusing to fix them. I have been giving the run around om trying to get my car fixed. I am a disabled veteran and all I get is they can't help. I just found out about these cars have this problem and ford has know about his problem for years.. they need to fix this. They again to be held according selling bad products to the public.

Structure; Wheels; Service Brakes

ODI #11527592

Incident: April 10, 2023 · Filed: June 18, 2023

Truck has no spare tire, totally missing the assembly and bracket originally used to hold the tire (have a junk one in the bed). The crossmember under the truck is about 50% intact is getting ready to fall off. Brake lines and rocker panals rotted out as well. Holes in the frame starting and a patch was already needed on the frame (drivers side rear). As well as a loose bed. The truck is very clean on top but underneath is rotting away like it has 200000 miles on it(truck is at 77,000). I want to remove the rust and coat it but im scared of punching through cause spots are brittle.

Suspension; Structure

ODI #11517056

Incident: April 4, 2023 · Filed: April 14, 2023

The frame of my truck has rotted through. The strap that holds the gas tank has nothing to connect to, i think the tank could fall to the ground under the right circumstances. The frame has a large whole in it and i fear it will break very soon. I had to remove the spare tire because i feared it would fall off the truck. I had to replace both connectors that held the leaf springs to the frame,and was told there wasn't much left to connect them to.

Electrical System; Air Bags; Unknown or Other

ODI #11515429

Incident: April 4, 2023 · Filed: April 4, 2023

Airbag warning light always on.

Structure

ODI #11479411

Incident: July 12, 2022 · Filed: August 15, 2022

The contact owns a 2003 Ford Ranger. The contact stated that while driving at 65 MPH, an abnormal, rattling noise began to emit from the rear of the vehicle without warning. Upon inspection, the contact discovered that the rear cross members had rotted out due to severe corrosion. The contact also stated that the fuel tank was no longer being supported due to the failure. An independent mechanic inspected the vehicle and deemed the vehicle unsafe to drive. The dealer nor the manufacturer had yet to be notified of the failure. The vehicle had yet to be repaired. The failure mileage was approximately 79,000.

Suspension

ODI #11417993

Incident: April 20, 2021 · Filed: May 21, 2021

I had been noticing some squeaking form the rear of my 2003 Ford Ranger. I thought it was my breaks. It turned out that the mounts for the rear springs had rusted out. My mechanic also noticed a hole, in the frame, resulting from rust. The hole is located on the inside surface of the frame on the passenger side just forward of the passenger compartment. Since the hole was discovered I stopped using the Ranger due to safety concerns.

Structure

ODI #11417607

Incident: May 10, 2021 · Filed: May 18, 2021

THE CONTACT OWNS A 2003 FORD RANGER. THE CONTACT STATED WHILE HER HUSBAND WAS DRIVING AT AN UNDISCLOSED SPEED, THE SPARE TIRE DETACHED FROM UNDERNEATH THE VEHICLE. THE VEHICLE WAS DRIVEN BACK TO THE RESIDENCE AND INSPECTED. THE DRIVER NOTICED THAT THE UNDERCARRIAGE AND SUB-FRAME WERE SEVERELY CORRODED. THE CONTACT TOOK THE VEHICLE TO THE LOCAL DEALER TO BE DIAGNOSED. THE MECHANIC STATED THAT THE SUB-FRAME HAD RUSTED OUT AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT YET REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 131,000

Engine; Fuel/Propulsion System

ODI #11384261

Incident: December 18, 2020 · Filed: December 20, 2020

WHEN AT STOP LIGHT ENGINE RPMS GO UP HIGH WHERE IT IS HARD TO HOLD VEHICLE STILL WITH BRAKES.

Suspension; Electrical System; Structure

ODI #11360843

Incident: September 23, 2020 · Filed: September 23, 2020

BODY, FRAME AND SUSPENSION HAVE ALL BEEN RUSTED OUT. BUMPER RECENTLY JUST FELL OFF DUE TO RUST (WHILE PARKED). DOORS WON'T SHUT COMPLETELY DUE TO RUST, WHICH HAS LED TO THE INTERIOR LIGHT REMAINING ON OR PERIODICALLY TURNING ON THROUGHOUT THE DAY/NIGHT AND KILLING THE BATTERY. ENTIRE TRUCK IS ONE BIG PILE OF RUST ON WHEELS.

Suspension

ODI #11354894

Incident: December 24, 2019 · Filed: September 14, 2020

CHASSIS ROTTING OUT. LOST SPARE TIRE CARRIER AND REAR FRAME SUPPORT. SPRING PERCH ROTTED OFF CHASSIS. OTHER AREAS ARE BEGINNING TO ROT OUT ON FRAME RAILS! THINGS CAME APART IN MOTION BUT WAS ABLE TO SAFELY REMOVE UPON STOPPING

Other Ford Ranger model years

Check your 2003 Ford Ranger VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Ford Ranger at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Ford VIN