2023 Ford Ranger Recalls, Ratings & Complaints

Incident: March 21, 2026 · Filed: August 9, 2026

Appx 73000 Miles truck developed shudder (felt like transmission jumping gears) under moderate acceleration. Gently Drove home, no other shudder. Called dealer who said to drive it in. Noted a missfire warning on phone app, also stated to gently drive to dealer. On way dealer up hill at ~60 mph (on 70mph freeway) shudder returned, slowed to 55mph, heard spark plug(s) eject and much louder noises. Stopped and had towed to dealer (tow truck drove onto roll back.. very noisy, dealer stated sounded terrible when drove into shop. Engine repair quoted at ~10k (disassembly,machine, sleeve cyinders, new parts) Ford extended warranty refused claim.

Incident: June 19, 2026 · Filed: June 30, 2026

Received safety recall 25S72 sync software and had repaired in Feb. 2026. Same issue has already resurfaced. Many issues are related to this. Sync software affects B/U camera, Ford pass will not work, phones will not sync, internal components will not work properly. IE: Radio, etc. Was repaired during warranty period but now a few weeks out of warranty and dealer will not repair again without a healthy charge. I just wanted to report since initial repair failed again so quickly. Thanks

Incident: December 28, 2025 · Filed: January 15, 2026

The contact owns a 2023 Ford Ranger. The contact stated that while idling at the red traffic light, the brake pedal was depressed; however, the vehicle was accelerating unintendedly. The contact continuously depressed the brake pedal; however, the vehicle accelerated unintendedly at approximately 1 MPH and crashed into the rear of another occupied vehicle. There was no injury sustained. The air bags did not deploy. No police report was filed. The contact and the other driver pulled into a gas station and exchanged the vehicle's insurance information. The contact stated that there was no visible damage on either vehicle. The vehicle was taken to the dealer to be diagnosed. The dealer informed the contact that no failure was found. The contact noticed that the dealer service report stated that the contact had stated that the vehicle was experiencing rough shifting while idling; however, the contact had only described the incident to the dealer and had not mentioned rough shifting while idling. The manufacturer was notified of the failure, and the contact requested buy-back assistance. The manufacturer informed the contact that the buy-back request was denied because neither the State where the vehicle was purchased, nor the State where the contact resided, required the buyback of the vehicle. Additionally, the contact was advised to take the vehicle to another dealer for a diagnostic test. The vehicle was not diagnosed or repaired. The failure mileage was approximately 38,000.

Incident: October 13, 2025 · Filed: November 21, 2025

Brake pad fell off while driving, it hasn’t been serviced by anyone else except the manufacturer. It’s a manufacturer failure and a safety issue. The dealer ship refused to provide an inspection report of the vehicle

Incident: August 11, 2023 · Filed: August 11, 2025

The contact owns a 2023 Ford Ranger. The contact stated that while the vehicle was turned off, the fuel pump erroneously activated, sending fuel to the engine. The contact had to restart and turn off the vehicle for the fuel pump to shut off. The failure occurred intermittently, but frequently. The dealer was contacted regarding a possible recall; however, the contact was unable to speak with a representative. The manufacturer was not made aware of the failure. The failure mileage was approximately 50.

Incident: March 28, 2025 · Filed: March 28, 2025

The contact owns a 2023 Ford Ranger. The contact stated while driving at an undisclosed speed, the vehicle inadvertently decelerated to 40 MPH, and the vehicle then shifted into 4WD-Low independently. As a result of the failure, the vehicle dramatically decelerated and skidded to a complete stop. The 4WD warning light was illuminated. The vehicle was taken to the dealer, who observed water damage to the fuse box which caused electrical failures. The contact was informed that the fuse box needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 10,000.

Incident: January 27, 2025 · Filed: January 27, 2025

in normal drive mode the transmission downs shifts thru the gears and skips from 3 to 1. becuase of that skip it feels like you got rear ended by another car. if your not prepared for it you could let off the brakes which could cuase you to hit the person in front. in sport mode it downshifts thru all the 10 gears properly.

Incident: December 20, 2022 · Filed: June 15, 2024

Transmission. Hesitates from a stop to highway speeds and hard downshift upon stopping…either controlled or emergency stop. Seems hard to find a gear. Indecisive acceleration. I took it back to Ford and they drove it and said they could not replicate my complaint. No one has inspected it except when I took it back to my dealership. No warning lamps or issues. There is a definite problem with the shifting and clunking of this transmission. It hesitates & makes a hard noise when stopping. I’m [XXX] and have always bought Fords. This one needs fixed! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident: March 1, 2024 · Filed: March 15, 2024

AIR BAG WARNING LIGHT HAS RECENTLY ILLUMINATED. INDEPENDENT MECHANIC SCAN TOOL READING ON 3/15/24 SHOWS THE FRONT PASSENGER AIRBAG TO HAVE COMPLETELY FAILED AND BECOME INOPERABLE. VEHICLE HAS NOT BEEN INVOLVED IN ANY IMPACTS OR COLLISIONS.

Incident: December 1, 2023 · Filed: January 30, 2024

The contact owns a 2023 Ford Ranger. The contact stated that while the Lane Keep Assist system activated, the system failed to work properly. While the alarm was on, the steering wheel vibrated, and the vehicle remained in the lane. While using the assist option, the vehicle veered into the other lane. While the Lane Keep Assist system was positioned with the alarm and assist, the system was inoperable. The contact called the local dealer and was informed that the vehicle was working as designed. The vehicle was not diagnosed or repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was 1,700.