2013 Ford Flex Recalls, Ratings & Complaints

Incident: September 26, 2026 · Filed: September 28, 2026

My car randomly over heated ON XXX around 3:23 pm and when I pulled over to a parking lot there was antifreeze pouring out of the bottom front passenger side. I tried to allow it to cool down so that I could safely get it to the shop .5 mile away and the vehicle started to shake and stall and the check engine light came on. I had it towed and inspected at Featherstone Auto, 14523 Richmond Hwy, Woodbridge VA 22191 where I was informed by [XXX] that this is a common issue with Ford Flex where the water pump in inside the engine and fails yet there is no recall for this issue. This is an extremely pricely cost that Ford knows is an issue yet there is no resolution on their end??? That is highly unnacceptable. I have had this car for less than a year, granted it is 13 years old. The safety of my selves and others were put at risk because my vehicle almost stopped in the middle of ongoing traffic due to a well known issue with this vehicle. Prior to this there was no engine overheating message in the 11 months that I have had this vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident: June 15, 2026 · Filed: September 24, 2026

UNKNOWN So we bought the car used from the dealer exactly how they received it, and it was working normally but then a few weeks or a month or two we were going somewhere and one of the headlights would go out and we'd have to turn the switch off and back on to get it to turn back on, and it was one for a few weeks but then it started turning them both off, and then it eventually got to the point that we would turn the headlights on anf the passenger side headlight wouldn't turn on anymore at all, so I went and got a bulb incase that was the issue and so we went to put the new bulb in and as we disconnected the circuit in order to get to the bulb we found that 1, water would stay inside the plastic cover causing the main board of the headlight to be fully submerged. 2, The connector to the main board was melted and fried so it is unusable. 3, with that being said that could've turned into a way worse scenario such as driving down the road and suddenly the circuit catches fire. 4, another possible outcome is while we are driving the headlights turn themselves off and while turning them back on we can't see and end up hitting a pedestrian walking or a tree on the side of the road. 5, another outcome could be, that the wiring eventually fries itself to the point that you'd have to replace every wire. 6, another safety hazard is how it is wired, the safety concerns with that and the connectors if the wrong thing happens at the weong time it could cause a full engine meltdown or explode. Now how is this a safety hazard well I've mentioned possible outcomes but the main issue is you legally need headlights when it is dark outside and if you don't you can't see where you are going and others won't see you as quick which can result in an accident happening. Another one is if one of the connectors catched fire and we pull over to the side well that fire could spread to the engine causing it to blow up and if the timing is right take out someone with it. Thats all I can say.

Incident: May 1, 2026 · Filed: May 8, 2026

What component or system failed or malfunctioned, and is it available for inspection upon request? INTERNAL WATER PUMP/ TIMING CHAINS/ VVT SOLENOIDS/ CAM PHASERS/ CAM SENSORS/ RELATED SEALS How was your safety or the safety of others put at risk? ENGINE FAILURE - SUDDEN STOP OF VEHICLE Has the problem been reproduced or confirmed by a dealer or independent service center? YES, IS AWARE AND HAS ACKNOWLEDGED VIA SERVICE AND TECH BULLETINS THAT THIS IS A KNOWN AND REPEATED ISSUE. ISSUE IS KNOWN AND COMMON WITH ALL 3.7L AND 3.5L FORD ENGINES. MANUFACTURER HAS HAD PETTY AND CLASS ACTION SUITS RELATED TO THIS FAILURE AND IS NOT TAKING ANY ACTION TO REMEDY ASIDE FROM A "EXTENDED WARRANTY" FOR CERTIAN COUNTRIES BUT SAID WARRANTY DOES NOT HELP THOSE WHO PURCHASED VEHICLES USED AND HAVE NO VEHICLE HISTORY TO SEE IF THE "SERVICE INTERVALS" WERE MET LEAVING THOUSANDS OF OWNERS WITH REPAIR BILLS THAT COST AT MINIMUM OVER FOUR THOUSAND DOLLARS. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? YES. MULTIPLE TECHNICIANS ON MY VEHICLE AD WELL AS THOUSANDS OF COMPLAINTS ACROSS THE WORLD. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? NO LAMPS. ONLY POSSIBLE WAY YOU CAN EVEN TELL IS BY THE TIME ITS TOO LATE AND THE COOLANT AND OIL MIX RESULTING IN MILKY LIKE MIXTURE ON DIPSTICK OR IN OIL PAN OR ENGINE FAILURE.

Incident: May 1, 2026 · Filed: May 8, 2026

What component or system failed or malfunctioned, and is it available for inspection upon request? MULTIPLE DRIVER AID FUNCATIONS IN-OP. DRIVER DOOR LOCKS WILL NOT LOCK OR UNLOCK, DRIVER DOOR LOCK AND UNLOCK SWITCH WILL NOT OPERATE ANY LOCKS, PASSENGER DOOR MIRROR WILL NOT MOVE, SEAT MEMORY WILL NOT SAVE, REAR VIEW MIRROR WILL NOT AUTO DIM AND THERE IS NO MANUAL OPTION TO ADJUST THE MIRROR RESULTING IN IMPACTED NIGHT VISABLITY, REAR VIEW CAMERA DOES NOT DISPLAY ON SCREEN BUT WILL BEEP WHEN CLOSE TO AN OBJECT. NOT CODES OR DASH WARNINGS DISPLAYED TO STORED. How was your safety or the safety of others put at risk? IMPACTED VISIBLY WHILE DRIVING. UNABLE TO ADUST PASSENGER MIRROR TO SEE BLINK SPOT OR ALONG PASSENGER SIDE OF VEHICLE. UNABLE TO LOCK OR UNLOCK DRIVER DOOR, IF LOCKED ITS NOT ALLOWING ME TO ENTER THE VEHICLE AND HAVE TO ENTER VIA PASSENGER DOOR. AUTO DIM IMPACTS VISABLITY WITH DRIVING AT NIGHT. REAR BACK UP CAMERA IN-OP IS DAMGEROUS IN NUMEROUS ASPECTS. Has the problem been reproduced or confirmed by a dealer or independent service center? PROBLEM IS CONSTANT. NOT TAKING TO A DEALER DUE TO RIDICULOUS PRICES AND DIAG FEES. I'M A TECH AND TRIED TO DIAGNOSE ISSUES WITH NO ANSWERS. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? NOT YET. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? UNKNOWN. PURCHASED PRIVATE PARTY WITH ISSUES (05/01/2026). LOOKED AT 3 OTHER FORD FLEXS FROM THIS GENERATION THAT ALL HAD THE SAME ISSUES WHEN LOOKING TO PURCHASE A VEHICLE AND NO ONE HAD A SOLUTION FOR IT.

Incident: April 21, 2026 · Filed: April 21, 2026

The contact owns a 2013 Ford Flex. The contact stated that while driving at an undisclosed speed, the steering wheel seized, with the power steering fault warning light illuminated. The vehicle was restarted; however, the failure reoccurred, and the steering wheel became difficult to turn. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that the steering rack and steering angle and torque sensors had failed and needed to be replaced. The vehicle was not repaired. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure, and several cases were filed. The failure mileage was approximately 140,000.

Incident: March 3, 2026 · Filed: March 3, 2026

The contact owns a 2013 Ford Flex. The vehicle was taken to a dealer for a recall repair. The contact stated the dealer declined to perform the recall repair because the vehicle was unable to be started. The contact received notification of NHTSA Campaign Number: 20V072000 (SUSPENSION). The vehicle was currently at the dealer. The vehicle was not repaired. The manufacturer was not made aware of the issue. The failure mileage was 127,000.

Incident: February 22, 2026 · Filed: February 25, 2026

On Sunday, February 22, 2026, I was driving my 2013 Ford Flex with the driver’s seat heater activated. After a period of use, I began to notice an unusual electrical burning smell inside the vehicle. There were no dashboard warning lights or system alerts. I turned the seat heater off immediately once I detected the smell. I did not initially notice an injury at that time. The following day, I experienced significant pain and discovered burns on my buttocks in the area consistent with seat contact. I sought medical evaluation three days later and was diagnosed with second- to third-degree burns. Prescription treatment was provided. The vehicle has not yet been inspected for the cause of the overheating or odor. Based on the location and pattern of injury, and the timing of the electrical smell while the heated seat was activated, the burn appears to have resulted from a malfunction of the seat heating element.

Filed: February 5, 2026

Rear view camera has failed. The screen goes black and has a “contact dealer” message.

Incident: December 22, 2025 · Filed: December 22, 2025

While driving, the power steering warning light illuminated and steering assist was lost. The steering became extremely hard, especially at low speeds. The vehicle makes grinding/whining noises when turning, and the car vibrates while in Drive. This creates a serious safety concern, especially during turns and parking maneuvers. Issue appears to be electric power steering (EPAS) failure.

Incident: November 23, 2025 · Filed: December 2, 2025

Power steering. While I was driving in my neighborhood the power steering went out and I could not make a turn. It locked up while driving. I could have got into a head on collision/accident becasue the road turns. Yes, I reported it to Ford and they told me my flex did not have a recall despite the ford website stating that some 2013 ford flex are affected. The description of 15s18 sterring recall matches my same issue and it poses a serious safety hazard. Yes, i took it to a mechanic at an auto shop and her is telling me that he can't fix recalls. At the time of the accident, i got No pre warning just the message that states: "Steering Lock Malfunction Service Now: The steering lock system has detected a condition that requires service." This happened on or around 11/23/25. I am requesting that Ford pay for my power steering to be fixed.