NHTSA vehicle safety data

2000 Ford F-550 SD Recalls & Complaints

The 2000 Ford F-550 SD has 6 NHTSA recall campaigns and 72 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Ford dealer.

NHTSA recall and complaint data for the 2000 Ford F-550 SD. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2000 Ford F-550 SD owner complaints

Owners have filed 72 complaints with NHTSA about the 2000 Ford F-550 SD, describing incidents dated January 1, 2000 to July 9, 2021.

Most-cited components

Tires 31 complaints
Engine 7 complaints
Fuel/Propulsion System 7 complaints
Service Brakes 7 complaints
Power Train 5 complaints
Wheels 5 complaints

Of the 72 complaints on file, 5 report a crash and 2 a fire; across all 72 complaints, owners report 1 injury (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11427133 · Filed July 30, 2021
The contact owns a 2000 Ford F-550. The contact stated while driving 30 mph, the power steering and brake lines were leaking causing the brakes and steering to become inoperable. The contact pulled over and topped off the power steering fluid reservoir and drove to the residence. The contact stated…
ODI #10881404 · Filed June 29, 2016
SPARK PLUG SPIT OUT, A KNOWN FORD PROBLEM.
ODI #10760249 · Filed August 31, 2015
TL* THE CONTACT OWNS A 2000 FORD F-550 SD. THE CONTACT STATED THAT THE VEHICLE STALLED WITHOUT WARNING WHILE DRIVING AT VARIOUS SPEEDS. THE VEHICLE WAS TAKEN TO THE DEALER NUMEROUS TIMES, BUT THE FAILURE WAS UNABLE TO BE DETERMINED. THE DEALER REPLACED THE ENGINE ELECTRONIC CONTROL UNIT, THE FUEL…

Read all 72 complaints

NHTSA defect investigations

NHTSA's investigations file lists the 2000 Ford F-550 SD in 4 investigations. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Engineering Analysis EA06-012: ENGINE STALLING
Closed December 7, 2007
- Recall 07V-553
Engineering Analysis EA05-005: ENGINE COMPARTMENT FIRES
Closed August 2, 2006
- Recall 05V-388
- Recall 06V-286
- Recall 07V-078
- Recall 07V-336
- Recall 07V-347
- Recall 07V-488
- and 1 more on the investigation page
Engineering Analysis EA02-018: RAPID TIRE DEFLATION
Closed August 22, 2003
Engineering Analysis EA01-009: SECTOR SHAFT FRACTURES
Closed August 19, 2003

Open and recently closed NHTSA defect investigations

SPEED CONTROL DEACTIVATION SWITCH/OVERHEATS

NHTSA #09V399000 · Vehicle Speed Control · NHTSA notice

Reported October 13, 2009 · FORD MOTOR COMPANY

Potentially affected: 4,500,000 vehicles

Ford campaign 09S09 · Owners notified October 27, 2009 · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Safety consequence

A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.

Manufacturer remedy

FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.

Notes

FORD'S RECALL CAMPAIGN NUMBER IS 09S09.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

REPLACEMENT WHEEL HUB ASSEMBLIES

NHTSA #07E106000 · Wheels — Hub · NHTSA notice

Reported December 17, 2007 · FEDERAL-MOGUL CORPORATION

Potentially affected: 130,000 vehicles

Owners notified February 7, 2008

Defect description

CERTAIN FEDERAL-MOGUL REPLACEMENT WHEEL HUB ASSEMBLIES WITH THE BRAND NAMES: NATIONAL, CARQUEST P/NOS. 515020, 515021, 515025, 515053, 515054, 515059, AND 515060, SHIPPED BETWEEN JANUARY 23, 2006, AND DECEMBER 20, 2007, SOLD FOR LIGHT DUTY AND MEDIUM DUTY TRUCKS. THE INBOARD RETENTION NUT USED TO MAINTAIN HUB BEARING ASSEMBLY CAN LOOSEN RESULTING IN AN ABS LIGHT INDICATION, NOISE, AND/OR WHEEL SEPARATION.

Safety consequence

WHEEL SEPARATION CAN RESULT IN A VEHICLE CRASH.

Manufacturer remedy

FEDERAL-MOGUL WILL NOTIFY CUSTOMERS AND WILL REPLACE THE HUB ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 7, 2008. OWNERS CAN CONTACT FEDERAL-MOGUL TOLL-FREE AT 877-489-6659.

Notes

THIS RECALL ONLY PERTAINS TO REPLACEMENT NATIONAL, CARQUEST WHEEL HUB ASSEMBLIES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS OR FORD.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

CAMSHAFT POSITION SENSOR

NHTSA #07V553000 · Engine and Engine Cooling — Engine — Diesel · NHTSA notice

Reported December 5, 2007 · FORD MOTOR COMPANY

Potentially affected: 1,176,000 vehicles

Ford campaign 07S57 · Owners notified December 29, 2007 · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

ON CERTAIN HEAVY DUTY TRUCKS EQUIPPED WITH 7.3L DIESEL ENGINES, THE CAMSHAFT POSITION SENSOR LOCATED ON THE ENGINE OF THE VEHICLE MAY FUNCTION INTERMITTENTLY, POSSIBLY RESULTING IN AN ENGINE STALL.

Safety consequence

IN THE EVENT OF AN ENGINE STALL, A CRASH COULD RESULT WITHOUT WARNING.

Manufacturer remedy

DEALERS WILL INSPECT THE SENSOR AND REPLACE IT WITH AN IMPROVED CAMSHAFT POSITION SENSOR FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 29, 2007. OWNERS MAY CONTACT FORD AT 1-866-436-7332.

Notes

FORD RECALL NO. 07S57.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

SPEED CONTROL DEACTIVATION SWITCH/SUPPLEMENT

NHTSA #06V286000 · Vehicle Speed Control · NHTSA notice

Reported August 1, 2006 · FORD MOTOR COMPANY

Potentially affected: 1,200,000 vehicles

Ford campaign 05S28 · Owners notified August 7, 2006 · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.

Safety consequence

OVERHEATING COULD RESULT IN SMOKE OR BURN AND AN UNDERHOOD FIRE.

Manufacturer remedy

DEALERS WILL INSTALL A FUSED WIRING HARNESS INTO THE SPEED CONTROL SYSTEM FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 7, 2006. OWNERS MAY CONTACT FORD AT 1-866-436-7332. (NOTE: ALSO SEE RECALLS 05V017 AND 05V388)

Notes

FORD RECALL NO. 05S28.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

FORD/WINDSHIELD WIPER MOTOR COVER

NHTSA #01V258000 · Visibility — Windshield Wiper/Washer — Motor · NHTSA notice

Reported August 8, 2001 · FORD MOTOR COMPANY

Potentially affected: 1,083,000 vehicles

Ford campaign 01S24 · Owners notified August 20, 2001

Defect description

VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.

Safety consequence

LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.

Notes

ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

FORD/TRUCK TIRES

NHTSA #01V046000 · Tires — Valve · NHTSA notice

Reported February 14, 2001 · FORD MOTOR COMPANY

Potentially affected: 102,000 vehicles

Ford campaign 01S05 · Owners notified March 28, 2001 · Vehicles built September 8, 1997 – October 21, 2000 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

VEHICLE DESCRIPTION: TRUCKS EQUIPPED WITH COMMERCIAL TRUCK TIRES THAT HAVE STEEL CORDS IN THE TIRE SIDEWALL. THE VALVE STEMS MAY HAVE BEEN TORN OR DAMAGED DURING ASSEMBLY AND COULD LEAK CAUSING SIDEWALL DAMAGE.

Safety consequence

IF NOT MAINTAINED, COULD RESULT IN A SIDEWALL ZIPPER FAILURE. A ZIPPER FAILURE DURING INFLATION OF A DAMAGED TIRE COULD RESULT IN INJURY TO SOMEONE NEAR THE TIRE.

Manufacturer remedy

DEALERS WILL INSPECT THE VALVE STEMS FOR LEAKAGE, AND WILL REPLACE BOTH THE VALVE STEM AND THE TIRE IF LEAKAGE IS PRESENT. OWNER NOTIFICATION BEGAN MARCH 28, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.

Notes

ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

try.vin has no NCAP crash-test rating on file for the 2000 Ford F-550 SD. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

72 owner complaints have been filed with NHTSA for the 2000 Ford F-550 SD.

Steering; Service Brakes, Hydraulic

ODI #11427133

Incident: July 9, 2021 · Filed: July 30, 2021

The contact owns a 2000 Ford F-550. The contact stated while driving 30 mph, the power steering and brake lines were leaking causing the brakes and steering to become inoperable. The contact pulled over and topped off the power steering fluid reservoir and drove to the residence. The contact stated that there was no warning light illuminated. The vehicle was diagnosed but was not yet repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 53,000.

Engine

ODI #10881404

Incident: March 16, 2015 · Filed: June 29, 2016

SPARK PLUG SPIT OUT, A KNOWN FORD PROBLEM.

Engine

ODI #10760249

Incident: December 1, 2014 · Filed: August 31, 2015

TL* THE CONTACT OWNS A 2000 FORD F-550 SD. THE CONTACT STATED THAT THE VEHICLE STALLED WITHOUT WARNING WHILE DRIVING AT VARIOUS SPEEDS. THE VEHICLE WAS TAKEN TO THE DEALER NUMEROUS TIMES, BUT THE FAILURE WAS UNABLE TO BE DETERMINED. THE DEALER REPLACED THE ENGINE ELECTRONIC CONTROL UNIT, THE FUEL TANK WAS ALIGNED, THE FILTERS AND THE FUEL INJECTORS WERE REPLACED, BUT THE FAILURE PERSISTED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 294,731.

Service Brakes

ODI #10608614

Crash

Incident: February 1, 2013 · Filed: July 7, 2014

THE PURPOSE OF THIS IS TO SHED LIGHT ON A DEFECTIVE PARKING BRAKE SYSTEM DESIGNED BY FORD. THE SYSTEM WILL AFFECT SEVERAL MODEL YEARS OF FORD LIGHT AND MEDIUM DUTY TRUCKS. THE PARKING BRAKE PEDAL ASSEMBLY DOES NOT WITHSTAND REGULAR USE IT TENDS TO FALL APART. THE LAST ASSEMBLY INSTALLED IN MY F-500 IS A FORD NEW ASSEMBLY AND HELD UP FOR 18000 MILES, FORD NOW REFUSES TO PROVIDE A REPLACEMENT UNDER WARRANTY. THE FAILURE OF THE SYSTEM HAS CAUSE THIS TRUCK TO ROLL AND HIT PARKED CARS. *JS THE ENTIRE DESIGN IS A FAILURE AS IT CAN NOT SAFELY HOLD THE WEIGHT OF AN EMPTY VEHICLE. MY TRUCK WEIGHS 14000 EMPTY AND IS RATED AT 19000 GVW. THE ASSEMBLY EVEN WHEN ADJUSTED PROPERLY CAN NOT HOLD THE VEHICLE ON AN INCLINE. THE INSIDE THE ROTOR HAT DESIGN FOR PARKING BRAKES IS A COPY FROM THE LIGHT SUV'S FORD PRODUCES. THIS IS NOT AN ADEQUATE DESIGN FOR HEAVIER VEHICLES. THE SURFACE AREA CONTACT OF SHOES TO THE INSIDE OF THE ROTOR HAT IS NOT GREAT ENOUGH TO PRODUCE THE FRICTION NEEDED TO HOLD THE VEHICLE. I KNOW OF SEVERAL OTHER PEOPLE THAT HAVE THE SAME PROBLEM WITH THEIR FORDS IN THE SAME MODEL YEARS. AT 360749 MILES THE ENTIRE PARKING BRAKE SYSTEM HAS BEEN REBUILT ON THIS SPECIFIC TRUCK. THE SHOES ARE ADJUSTED UP MANUALLY (IT HAS NO SELF ADJUST FEATURE) TIGHT WITH THE ROTOR HAT AND THE SYSTEM WILL NOT HOLD THE VEHICLE ON AN INCLINE. THE SYSTEM WITH NORMAL WEAR BECOMES A GREATER HAZARD AS THE PARK BRAKE SYSTEM WEAKENS QUICKLY. *JS

Engine and Engine Cooling; Fuel/Propulsion System

ODI #10563547

Incident: January 4, 2013 · Filed: February 9, 2014

FORD TRUCK BEGAN LOOSING POWER. BECAME UNABLE TO CLIMB HILL AND CONTINUE UP ROAD. DRIVER WAS IN VERY REMOTE ALASKA IN SUBZERO TEMPERATURES IN WORK TRUCK (AS MOST F550S ARE) MILES FROM HELP. PLOWING A FIREWOOD ROAD FOR THE STATE OF ALASKA. WE MAINTAIN OUR TRUCKS TO THE BEST OF OUR ABILITY TO PREVENT SUCH A LIFE THREATENING CIRCUMSTANCE. DRIVER CALLED ME FOR HELP. I WAS ABLE TO GO ONLINE AND FIND ENOUGH INFORMATION (KNOWING IT WAS NOT A FILTER OR PUMP OR MAINTENANCE ISSUE I DUG DEEPER) TO DEDUCE THE FUEL TANK HAD DELAMINATED AS LATELY HAS BECOME "COMMON" WITH THESE TRUCKS. UNDER MY ADVICE DRIVER (BEING A MECHANIC) WAS ABLE TO BLOW COMPRESSED AIR FROM A COMPRESSOR HE HAD ON BOARD BACK INTO THE TANK AND TEMPORARILY GET THE TRUCK RUNNING CORRECTLY AND GET BACK CIVILIZATION. TRUCK CLOGGED AGAIN AND HAS BEEN RUN STARVING FOR FUEL FOR HOURS BEFORE IT GOT TO THE HILL. WE ARE COMPLETELY UPSET AT THE PRICE FORD WANTS TO REMEDY AN EXTREMELY DANGEROUS DESIGN FLAW. THESE TRUCKS ARE USED ALL OVER THIS NATION AS EMERGENCY SERVICE VEHICLES. I KNOW BECAUSE I HAVE 3 FOR THAT PURPOSE. I BELIEVE MY 2008 WILDLAND FIRE ENGINE MAY HAVE THE SAME ISSUE (2008 F550) AS THE 2000 F550 PLOW TRUCK I WROTE ABOUT ABOVE. THESE TRUCKS ARE RELIED ON WITH LIVES TO NOT BE BURNED OVER DURING FIRE BURNOUTS AND OPERATIONS. OTHERS OF THIS TYPE OF VEHICLE ARE AMBULANCES, WRECKERS, ETC. I TALKED TO A FORD TECH AND ALL DEALERS THAT WORK ON THESE HEAVY DUTY TRUCKS KNOW ABOUT THIS PROBLEM. WHY DIDN'T I. MY DRIVERS ARE IN DANGER AND GOOGLE TOLD ME ENOUGH TO GET FORD TECH'S TO TELL ME, AND IT'S MY FINANCIAL LOSS???? PLEASE LOOK INTO THE DELAMINATING TANK ISSUE FOR F550 TRUCKS. $3,000 AND RISK OF STRANDED IN FRONT OF THE FLAMES IN SUMMER AND REMOTE ALASKA FREEZING TEMPS IN WINTER. SAFETY ISSUE LIKE THAT SHOULD BE STAMPED INTO THE DASH IF ITS KNOWN ON THESE EMERGENCY SERVICE TRUCKS. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Engine and Engine Cooling; Vehicle Speed Control

ODI #10547694

Fire

Incident: October 11, 2013 · Filed: October 11, 2013

FORD F-550 WAS SITTING IN DRIVEWAY WITH THE ENGINE OFF AND CAUGHT ON FIRE, THE CAB OF THE TRUCK WAS COMPLETELY ENGULFED IN FLAMES SECONDS LATER VEHICLES CRUISE CONTROL SWITCH HAD BEEN REPLACED UNDER FORDS RECALL OF THE PART ACCORDING TO CONCERNS OF VEHICLE FIRES BUT WAS OBVIOUSLY STILL FAULTY. *TR

Fuel System, Diesel

ODI #10410774

Incident: June 1, 2007 · Filed: July 6, 2011

TL* THE CONTACT OWNS A 2000 FORD F550. THE CONTACT STATED THAT THE GAS TANK WAS FAULTY SINCE HE HAD IT REPLACED IN 2007 AND NEEDS TO BE REPLACED AGAIN DUE TO CORROSION. THE DEALER DID NOT OFFER ANY ASSISTANCE DUE TO THE AGE OF THE VEHICLE. THE MANUFACTURER WAS AWARE OF THE FAILURE. NO REPAIRS WERE PERFORMED. THE CURRENT MILEAGE WAS 90,000. THE APPROXIMATE FAILURE MILEAGE WAS 60,000.

Power Train

ODI #10355525

Incident: September 6, 2010 · Filed: September 14, 2010

THE FORD F-550 WITH THE 7.3L POWERSTROKE ENGINE AND AUTOMATIC TRANSMISSION HAS A FLAW IN ITS DESIGN. THE FLEXPLATE (FLYWHEEL) ON OURS CRACKED ALL THE WAY AROUND THE BOLTS HOLES IN AUGUST OF 2009. THE EXACT SAME THING HAPPENED IN SEPTEMBER OF THIS YEAR (2010). WE COULD FIGURE OUT WHAT IT WAS AT FIRST. IT SIMPLY GOT LOUDER AND LOUDER. HAD WE GONE MUCH LONGER WITHOUT FIGURING IT OUT, THE VEHICLE COULD HAVE LOST THE ABILITY TO PROPEL ITSELF WHILE DRIVING DOWN THE ROAD. THE FLYWHEEL HAS TO BE REPLACED, WHICH COSTS $599.00 WITH PARTS AND LABOR. *TR

Fuel System, Diesel

ODI #10314143

Incident: November 9, 2009 · Filed: February 25, 2010

TL*THE CONTACT OWNS A 2000 FORD F550. THE CONTACT STATED THAT THE MATERIAL IN THE FUEL TANK HAS DETACHED FROM THE INNER STRUCTURE OF THE TANK. THE MATERIAL WAS IN THE FUEL INJECTOR AND CAUSED THE VEHICLE TO STALL AND SHUTS OFF INTERMITTENTLY WHILE DRIVING 65 MPH. THE CONTACT HAS TAKEN THE VEHICLE TO THE DEALER TO REPLACE THE FUEL TANK, FUEL PUMP, FUEL SENDER, FUEL FILTERS, AND THE FUEL INJECTORS. THE REPAIRS HAVE REMEDIED THE FAILURE. THE CONTACT STATED THAT THE VEHICLE COULD HAVE CAUSED A CRASH WHILE STALLING. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 98,450.

Fuel System, Diesel

ODI #10274253

Incident: April 15, 2009 · Filed: June 18, 2009

2000 FORD F-550 FUEL TANK LINER FAILURES. TANK LINER COMING APART CAUSING THE FUEL TANK NEEDING TO BE RELINED, AND REPLACING THE FUEL PUMP AND FUEL FILTER. *TR

Other Ford F-550 SD model years

Check your 2000 Ford F-550 SD VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Ford F-550 SD at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Ford VIN