2011 Ford Expedition Recalls, Ratings & Complaints

Incident: June 10, 2026 · Filed: June 11, 2026

Odometer Fraud. The contact purchased a 2011 Ford Expedition. It was discovered that there was a mileage discrepancy. The vehicle was a dealer sale. At the time of purchase, the vehicle mileage was 136,000, and at the time of registration, it was discovered that the mileage was 336,000. The contact called the seller, who advised that the sale was final and to end communications. An Attorney General and private attorney were contacted.

Incident: March 4, 2026 · Filed: March 5, 2026

Hard, delayed, jump from idle when accelerator is pressed. Hard shift from park to reverse.

Incident: July 10, 2023 · Filed: December 5, 2025

I bought this vehicle early 2023. From the moment I bought it I’ve had a loud ticking sound come from the dash or the motor when I start the car also when it’s really hot out. It also didn’t blow cold air. So I had to save up enough money to replace the AC components in my 2011 expedition. After I got it “repaired” It only lasted about six months and that’s being conservative. $2000 later and it’s blowing hot air and still making you loud ticking sound. I pretty much replaced all the components that deal with the AC and the blower. I don’t know what to do anymore, but it makes a loud ticking sound when I’m driving, when I start the car, anytime. And I also don’t have cold air anymore.

Incident: September 9, 2024 · Filed: October 2, 2024

The contact owns a 2011 Ford Expedition. The contact stated while driving at an undisclosed speed, the front blower system was seized. The vehicle was driven to the residence. The vehicle was towed to the dealer where it was diagnosed with a failed HVAC blower motor. The contact was informed that the HVAC blower motor needed to be replaced. The vehicle was not repaired. The contact was informed of Technical Service Bulletin: 10163573; however, the contact was informed that the vehicle repair was not covered under the bulletin. The manufacturer was made aware of the failure. The contact was referred to the NHTSA Hotline to report the failure. The failure mileage was approximately 153,000.

Incident: April 27, 2024 · Filed: May 8, 2024

So my 2011 expedition has a lead frame problem it is stuck in 4th gear and all the warning lights are on associating the lead frame. The shop I left told me it Is the lead frame. The problem is the ford f150 with the exact same transmission as mine has a recall for that exact part. But no recall on the expiration with the exact same transmission as mine. This is a safety problem as it is stuck in fourth gear and completely unsafe to drive. This is a ford factory problem and needs to be addressed before it gets someone gravely injured of killed I talked with ford and they sY since there is no recall there is nothing they can do I've beennout a vehicle for 2 weeks already and now they say they have no clue when they can find the part. So I'm just out a vehicle that I payed thousands of dollars for. This is Unacceptable as I need the vehicle to get to work I don't know if this will help but I have to try something. There should be a recall on the expeditions as well

Incident: December 5, 2022 · Filed: January 19, 2024

The contact owns a 2011 Ford Expedition. The contact stated that the locking assembly on the driver’s side door was frozen and failed to operate as designed. Due to the issue, the contact was unable to enter the vehicle without using a hair dryer to warm up the lock. However, once the door was opened, the door was unable to close until the lock was heated up again. No warning lights illuminated. The vehicle was not taken to the dealer and was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline. The approximate failure mileage was 115,000.

Incident: December 20, 2019 · Filed: April 20, 2023

The engine is blown at 125k miles when all servicing and maintenance was done at the dealership. Somewhere around 50k to 60k miles, I complained to the dealership about a ticking noise from the engine and was told multiple times it was "normal with this engine". Well this engine blew while I was on my way to take the kids to school. I was on the interstate/bypass and was by some miracle able to get the 7-11. I was driving and all of a sudden, it sounded like there was squirrel under the hood. I had to have it towed to the dealership because it was not driveable and they told me the engine was no longer good and was blown. They said it would cost me $10k and I would be better off buying a new vehicle. There was no engine light or anything that came on until it blew. The only "warning" I had was the slight ticking noise that came from the engine, but when mentioned to the dealership, I was told that it was normal with this engine.

Incident: April 4, 2022 · Filed: April 4, 2022

While getting tires replaced (Discount Tire), the representative pointed out that the aluminum-shelled lug nuts had swollen and become so deformed that the correctly sized socket could not be used. FUrthermore they could not be accurately torqued. The lug nuts had to be replaced, which cost $175.

Incident: March 16, 2022 · Filed: March 16, 2022

2 piece lug nuts swelled creating a dangerous situation where the lugs were extremely difficult to remove. If the vehicle experienced a flat tire, they would be difficult if not impossible to remove on the road.

Incident: February 20, 2022 · Filed: February 22, 2022

The contact owns a 2011 FORD Expedition. The contact stated that while driving, there was a burning odor coming from the vehicle. The contact stated at the time she did not see any smoke coming from her vehicle, so she assumed it was the outside. The contact stated that once she parked her vehicle, she sat inside the vehicle for approximately one hour before she exited the vehicle. The contact stated that when she came back to her vehicle, it was filled with smoke. The contact stated that the wires from the rear, middle row, passengers seat, on the driver's side of the vehicle had been burning. The contact stated that it did not cause a fire, however, it did melt the foam inside the seat. The contact stated the wires inside the seat were also melted. The dealer nor the manufacturer were notified of the failure. The failure mileage was 177,000