NHTSA vehicle safety data

2006 Dodge Durango Recalls, Ratings & Complaints

The 2006 Dodge Durango has 10 NHTSA recall campaigns and 852 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Dodge dealer.

NHTSA recall and complaint data for the 2006 Dodge Durango, plus NCAP crash-test ratings. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2006 Dodge Durango owner complaints

Owners have filed 852 complaints with NHTSA about the 2006 Dodge Durango, describing incidents dated January 2, 2006 to September 18, 2026.

Most-cited components

Fuel/Propulsion System 552 complaints
Electrical System 84 complaints
Air Bags 76 complaints
Engine 68 complaints
Power Train 55 complaints
Service Brakes 27 complaints

Of the 852 complaints on file, 16 report a crash and 9 a fire; across all 852 complaints, owners report 19 injuries (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11766448 · Filed September 23, 2026
The contact owns a 2006 Dodge Durango. The contact stated that upon starting the vehicle, there was an abnormal gasoline odor coming from the vehicle with the check engine warning light illuminated. The contact inspected the vehicle and discovered fuel leaking on the top of the fuel tank. The…
ODI #11747356 · Filed June 30, 2026
Vehicle: 2006 Dodge Durango VIN: [XXX] Issue Type: Fuel System / Safety Hazard Description: During refueling, the vehicle repeatedly shuts the pump off and then sprays gasoline back out of the filler neck, creating a fire and injury hazard. This is a known defect covered under Dodge Customer…
ODI #11709685 · Filed January 8, 2026
Fuel spills out when you fill it up. I read there were safety recalls due to this issue for 2006 Dodge Durango's but a recall isn't appearing for my vehicle. When filling it fills fine until almost a full tank. Once it reaches full tank the gas pump clicks off then a gush of fuel spills out of my…

Read all 852 complaints

Owner-reported

2006 Dodge Durango mileage at failure

707 of the 852 complaints on file for the 2006 Dodge Durango give the vehicle's mileage when the problem happened.

Mileage at failure by component, from owners' complaints to NHTSA
Component	Median	Middle half	Based on
Fuel/Propulsion System	Median 60,000 miles	Middle half 45,000–80,000 miles	Based on 486 complaints
Electrical System	Median 80,000 miles	Middle half 45,000–120,000 miles	Based on 66 complaints
Engine	Median 85,000 miles	Middle half 50,000–120,000 miles	Based on 63 complaints
Power Train	Median 110,000 miles	Middle half 80,000–140,000 miles	Based on 47 complaints

A component's median is its 50th percentile, and its middle half runs from its 25th to its 75th percentile.

Owners give the mileage themselves, often as a round number, and NHTSA doesn't check it. A complaint that names several components counts under each one, and mileages that can't be right, such as 999,999, or 50 miles on a five-year-old car, are left out.

These figures describe the complaints owners filed. They don't predict when a particular vehicle will have a problem, and vehicles that never had one aren't counted.

Mileage from NHTSA's complaints file of October 31, 2026. How these figures are worked out

NHTSA defect investigations

NHTSA's investigations file lists the 2006 Dodge Durango in 7 investigations. Audit Queries and Equipment Queries are administrative investigations: they look at whether companies complied with federal vehicle safety requirements, such as reporting, recall and certification rules, not at a possible vehicle defect. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Engineering Analysis EA21-002: Desiccated Air Bag Inflator Rupture
Open since September 17, 2021
Engineering Analysis EA15-001: Air Bag Inflator Rupture
Open since February 24, 2015
- Recall 14V-668
- Recall 15V-284
- Recall 15V-285
- Recall 15V-286
- Recall 15V-287
- Recall 15V-312
- and 188 more on the investigation page
Audit Query AQ10-001: Fleet Vehicle Recall Completion Audit
Closed December 28, 2015
Preliminary Evaluation PE14-016: Air Bag Inflator Rupture
Closed March 2, 2015
- Recall 13V-172
- Recall 14V-428
- Recall 14V-700
- Recall 14V-763
- Recall 14V-770
- Recall 14V-787
- and 3 more on the investigation page
Engineering Analysis EA07-003: SIDE CURTAIN AIR BAG FAILURE
Closed February 8, 2008

2 more NHTSA investigations

Preliminary Evaluation PE06-045: SIDE CURTAIN AIR BAG FAILURE
Closed February 14, 2007
Engineering Analysis EA06-004: STEERING WHEEL AND STEERING SHAFT BOLTS
Opened March 9, 2006; no closing date on file

Open and recently closed NHTSA defect investigations

Do Not Drive - Passenger Frontal Air Bag Inflator May Rupture

NHTSA #16V352000 · Air Bags — Frontal — Passenger Side — Inflator Module · NHTSA notice

Reported May 24, 2016 · Chrysler (FCA US LLC)

Potentially affected: 4,648,270 vehicles

Repair completion: 43.53% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign S43 · Owners notified March 27, 2017 · Recall influenced by NHTSA's Office of Defects Investigation

Recall group: Takata airbag inflators

DO NOT DRIVE — this recall carries a "do not drive" advisory. Contact a Dodge dealer immediately.

Defect description

Chrysler (FCA US LLC) expanded the affected population to include 73,712 2005-2009 RAM 2500 trucks produced at the St. Louis North Assembly Plant. With this change, Chrysler is recalling certain model year 2004-2008 RAM 1500, 2005-2009 RAM 2500, 2006-2009 RAM 3500, 2007-2010 RAM 3500 Cab Chassis, 2008-2010 RAM 4500 and 5500 Cab Chassis, 2004-2009 Dodge Durango, 2007-2009 Chrysler Aspen, 2007-2012 Jeep Wrangler, 2008-2012 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2012 Chrysler 300, 2006-2012 Dodge Charger, 2005-2011 Dodge Dakota, and 2006-2009 Mitsubishi Raider vehicles originally sold, or ever registered, in AL, CA, FL, GA, HI, LA, MS, SC, TX, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Chrysler is also recalling 2004-2008 RAM 1500, 2005-2009 RAM 2500, 2006-2009 RAM 3500, 2007-2009 RAM 3500 Cab Chassis, 2008-2009 RAM 4500 and 5500 Cab Chassis, 2004-2009 Dodge Durango, 2007-2009 Chrysler Aspen, 2007-2009 Jeep Wrangler, 2008-2009 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2009 Chrysler 300, 2006-2009 Dodge Charger, 2005-2009 Dodge Dakota and 2006-2009 Mitsubishi Raider vehicles originally sold, or ever registered, in AZ, AR, DE, Washington D.C., IL, IN, KS, KY, MD, MO, NE, NV, NJ, NM, NC, OH, OK, PA, TN, VA, and WV, or "Zone B." Lastly, unless included in "Zone A" or "Zone B" above, Chrysler is recalling certain 2005-2008 RAM 2500, 2006-2008 RAM 3500, 2007-2008 RAM 3500 Cab Chassis, 2008 RAM 4500 and 5500 Cab Chassis, 2004-2008 Dodge Durango, 2007-2008 Chrysler Aspen, 2007-2008 Jeep Wrangler, 2008 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2008 Chrysler 300, 2006-2008 Dodge Charger, 2005-2008 Dodge Dakota, and 2006-2008 Mitsubishi Raider vehicles originally sold, or registered, in AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY.

Safety consequence

These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. These inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling. An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Manufacturer remedy

Owners are advised not to drive their vehicle until the recall repair is complete. Chrysler will notify the Chrysler, Dodge, Jeep and RAM owners. Mitsubishi owners will be notified by their company. Dealers will replace the passenger frontal air bag inflator, free of charge. The recall began on March 27, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S43. Note: This recall supersedes recall 14V-7700.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Do Not Drive - Driver Side Frontal Air Bag May Rupture

NHTSA #15V313000 · Air Bags — Frontal — Driver Side — Inflator Module · NHTSA notice

Reported May 26, 2015 · Chrysler (FCA US LLC)

Potentially affected: 4,077,169 vehicles

Repair completion: 47.11% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign R25 · Owners notified June 8, 2015 · Recall influenced by NHTSA's Office of Defects Investigation

Recall group: Takata airbag inflators

DO NOT DRIVE — this recall carries a "do not drive" advisory. Contact a Dodge dealer immediately.

Defect description

Chrysler (FCA US LLC) is recalling certain model year 2005-2009 Dodge Ram 2500, 2004-2008 Dodge Ram 1500 and Durango, 2006-2009 Dodge Ram 3500, 2008-2010 Dodge Ram 4500 and 5500, 2007-2008 Chrysler Aspen, 2005-2010 Chrysler 300, 300C, 300S, and SRT8, 2006-2010 Dodge Charger, 2005-2008 Magnum, 2005-2011 Dodge Dakota, and 2006-2009 Mitsubishi Raider vehicles. The affected vehicles are equipped with a dual-stage driver frontal air bag that may be susceptible to moisture intrusion which, over time, could cause the inflator to rupture.

Safety consequence

In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.

Manufacturer remedy

Owners are advised not to drive their vehicle until the recall repair is complete. Chrysler will notify the affected Chrysler and Dodge owners and Mitsubishi will notify the affected Raider owners. Dealers will replace the driver's frontal air bag inflator, free of charge. The recall began for Chrylser on June 8, 2015. The recall for Mitsubishi started on June 24, 2015. Chrysler and Dodge owners may contact Chrysler customer service at 1-800-853-1403. Mitsubishi owners may call 1-888-648-7820. Chrysler's number for this recall is R25. Note: This recall supersedes recall 14V817 in its entirety. Vehicles that have had their driver side frontal air bag replaced previously need to have their air bag replaced under this recall as well.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

FMVSS 108/AFTERMARKET COMBINATION LAMPS

NHTSA #09E012000 · Exterior Lighting · NHTSA notice

Reported April 7, 2009 · SABERSPORT

Potentially affected: 16,270 vehicles

Owners notified May 11, 2009

Defect description

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Safety consequence

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Manufacturer remedy

SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

INSTRUMENT CLUSTER CIRCUIT/INTERIOR LIGHTING

NHTSA #07V092000 · Electrical System — Instrument Cluster/Panel · NHTSA notice

Reported March 9, 2007 · DAIMLERCHRYSLER CORPORATION

Potentially affected: 328,424 vehicles

Manufacturer campaign G07 · Owners notified April 2, 2007 · Vehicles built April 3, 2003 – June 30, 2006 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

ON SOME SPORT UTILITY VEHICLES, UNDER CERTAIN OPERATING CONDITIONS, AN INTEGRATED CIRCUIT IN THE INSTRUMENT CLUSTER THAT CONTROLS INTERIOR LIGHTING MAY OVERHEAT.

Safety consequence

THIS COULD POTENTIALLY CAUSE AN INSTRUMENT PANEL FIRE.

Manufacturer remedy

DEALERS WILL INSPECT THE CLUSTER FOR DAMAGE AND REPLACE IT FREE OF CHARGE. THE RECALL BEGAN ON APRIL 2, 2007. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-140.

Notes

DAIMLERCHRYSLER RECALL NO. G07.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

REAR SUSPENSION LINK

NHTSA #06V240000 · Suspension — Rear · NHTSA notice

Reported July 7, 2006 · DAIMLERCHRYSLER CORPORATION

Potentially affected: 230 vehicles

Manufacturer campaign F30 · Owners notified July 19, 2006 · Vehicles built May 15, 2006 – May 16, 2006 (per NHTSA)

Defect description

ON CERTAIN SPORT UTILITY VEHICLES, THE LEFT REAR SUSPENSION WATTS LINK MAY HAVE BEEN DAMAGED DURING VEHICLE ASSEMBLY AND COULD FAIL.

Safety consequence

A FAILED WATTS LINK COULD ADVERSELY AFFECT VEHICLE HANDLING AND CAUSE A CRASH WITHOUT WARNING.

Manufacturer remedy

DEALERS WILL REPLACE THE LEFT REAR SUSPENSION WATTS LINK FREE OF CHARGE. THE RECALL BEGAN ON JULY 19, 2006. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Notes

DAIMLERCHRYSLER RECALL NO. F30.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

FRONT WINDSHIELD WIPER MOTOR

NHTSA #06V067000 · Visibility — Windshield Wiper/Washer — Motor · NHTSA notice

Reported March 8, 2006 · DAIMLERCHRYSLER CORPORATION

Potentially affected: 268,800 vehicles

Manufacturer campaign F10 · Owners notified June 19, 2006 · Vehicles built September 27, 2005 – November 24, 2005 (per NHTSA)

Defect description

ON CERTAIN VANS AND SPORT UTILITY VEHICLES, THE FRONT WINDSHIELD WIPER MOTOR ARMATURE SHAFT MAY BREAK.

Safety consequence

DURING CERTAIN OPERATING CONDITIONS, LOSS OF FRONT WINDSHIELD WIPING CAPABILITY COULD OCCUR, AND THE DRIVER'S VISION COULD BE OBSCURED WHICH COULD RESULT IN A CRASH.

Manufacturer remedy

DEALERS WILL INSPECT AND REPLACE THE WINDSHIELD WIPER MOTOR FREE OF CHARGE. THE RECALL BEGAN ON JUNE 19, 2006, TO DODGE DURANGO OWNERS. MINIVAN OWNERS WILL BE NOTIFIED DURING JULY 2006. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Notes

DAIMLERCHRYSLER RECALL NO. F10.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

FMVSS 208/OCCUPANT RESTRAINT CONTROLLER

NHTSA #06V044000 · Air Bags · NHTSA notice

Reported February 13, 2006 · DAIMLERCHRYSLER CORPORATION

Potentially affected: 335 vehicles

Manufacturer campaign F09 · Owners notified February 27, 2006 · Vehicles built January 13, 2006 – January 18, 2006 (per NHTSA)

Defect description

CERTAIN SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, 'OCCUPANT CRASH PROTECTION.' THE WRONG OCCUPANT RESTRAINT CONTROLLER (ORC) WAS INSTALLED ON THESE VEHICLES.

Safety consequence

THIS CAN CAUSE INCREASED RISK OF INJURY TO THE DRIVER UNDER CERTAIN CRASH CONDITIONS.

Manufacturer remedy

DEALERS WILL REPLACE THE OCCUPANT RESTRAINT CONTROL MODULE. THE RECALL BEGAN ON FEBRUARY 27, 2006. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Notes

DAIMLERCHRYSLER RECALL NO. F09. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

ELECTROSTATIC DISCHARGE EVENT

NHTSA #06V039000 · Visibility — Windshield Wiper/Washer — Switch/Wiring · NHTSA notice

Reported February 9, 2006 · DAIMLERCHRYSLER CORPORATION

Potentially affected: 79,701 vehicles

Manufacturer campaign F08 · Owners notified March 6, 2006 · Vehicles built July 1, 2005 – January 27, 2006 (per NHTSA)

Defect description

ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, A STATIC ELECTRICITY SPARK BETWEEN THE OPERATOR AND THE VEHICLE CAN CAUSE THE TURN SIGNAL, HEADLAMPS OR WINDSHIELD WIPERS TO MALFUNCTION WITHOUT WARNING.

Safety consequence

THIS CAN IMPAIR THE DRIVER'S VISION AND RESULT IN A CRASH.

Manufacturer remedy

DEALERS WILL RE-FLASH THE INSTRUMENT CLUSTER. THE RECALL BEGAN ON MARCH 6, 2006. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Notes

DAIMLERCHRYSLER RECALL NO. F08.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

REPROGRAM ABS CONTROL MODULE

NHTSA #05V554000 · Service Brakes, Hydraulic — Antilock/Traction Control/Electronic Limited Slip — Control Unit/Module · NHTSA notice

Reported December 8, 2005 · DAIMLERCHRYSLER CORPORATION

Potentially affected: 16,317 vehicles

Manufacturer campaign E20 · Owners notified December 12, 2005 · Vehicles built July 8, 2005 – September 30, 2005 (per NHTSA)

Defect description

ON CERTAIN SPORT UTILITY VEHICLES WITH ANTI-LOCK BRAKE SYSTEM (ABS), THE ABS CONTROL MODULE SOFTWARE PROGRAM MAY CAUSE THE REAR BRAKES TO LOCK UP DURING CERTAIN BRAKING CONDITIONS.

Safety consequence

THIS COULD RESULT IN A LOSS OF VEHICLE CONTROL AND A CRASH COULD OCCUR WITHOUT WARNING.

Manufacturer remedy

DEALERS WILL REPROGRAM THE ABS CONTROL MODULE. THE RECALL IS EXPECTED TO BEGIN ON DECEMBER 12, 2005. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Notes

DAIMLERCHRYSLER RECALL NO. E20.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

AUTOMATIC TRANSMISSION CUP PLUG

NHTSA #05V460000 · Power Train — Automatic Transmission · NHTSA notice

Reported October 6, 2005 · DAIMLERCHRYSLER CORPORATION

Potentially affected: 256,409 vehicles

Manufacturer campaign E14 · Owners notified November 28, 2005 · Vehicles built October 6, 2004 – May 23, 2005 (per NHTSA)

Defect description

ON CERTAIN PICKUP TRUCKS, SPORT UTILITY AND PASSENGER VEHICLES EQUIPPED WITH 42RLE AUTOMATIC TRANSMISSIONS, THE CUP PLUG THAT RETAINS THE PARK PAWL ANCHOR SHAFT MAY BE IMPROPERLY INSTALLED. IF THE SHAFT MOVES OUT OF POSITION, THE VEHICLE MAY NOT BE ABLE TO ACHIEVE 'PARK' POSITION.

Safety consequence

IF THIS OCCURS AND THE PARKING BRAKE IS NOT APPLIED, THE VEHICLE MAY ROLL AWAY AND CAUSE A CRASH WITHOUT WARNING.

Manufacturer remedy

DEALERS WILL INSPECT THE TRANSMISSIONS AND INSTALL A BRACKET TO ENSURE THE PARK PAWL ANCHOR SHAFT IS RETAINED IN THE PROPER POSITION. THE RECALL BEGAN ON NOVEMBER 28, 2005. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Notes

DAIMLERCHRYSLER RECALL NO. E14.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236; (TTY:1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

2006 Dodge Durango 4-DR.

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 5, Passenger: 5

Side Crash

Not Rated

Driver: Not Rated, Passenger: Not Rated

Side Pole

Not Rated

Rollover

19% rollover risk

Safety Technology

7 investigations

852 owner complaints have been filed with NHTSA for the 2006 Dodge Durango.

Fuel System, Gasoline

ODI #11766448

Incident: September 18, 2026 · Filed: September 23, 2026

The contact owns a 2006 Dodge Durango. The contact stated that upon starting the vehicle, there was an abnormal gasoline odor coming from the vehicle with the check engine warning light illuminated. The contact inspected the vehicle and discovered fuel leaking on the top of the fuel tank. The manufacturer was not notified of the failure. The failure mileage was 180,000.

Fuel/Propulsion System

ODI #11747356

Incident: June 29, 2026 · Filed: June 30, 2026

Vehicle: 2006 Dodge Durango VIN: [XXX] Issue Type: Fuel System / Safety Hazard Description: During refueling, the vehicle repeatedly shuts the pump off and then sprays gasoline back out of the filler neck, creating a fire and injury hazard. This is a known defect covered under Dodge Customer Satisfaction Notification X39, which extends warranty coverage for the inlet check valve / ORVR failure on 2006–2008 Durango models. The symptoms match the documented defect exactly: pump shutoff, fuel expulsion, and fuel spray. This occurs at multiple stations and with different pumps. Stellantis customer service and local dealers have been unresponsive and will not acknowledge X39 unless forced. The defect poses a clear safety risk to me and others nearby during refueling. I am requesting NHTSA involvement to ensure Stellantis honors the X39 warranty extension and addresses this fuel system hazard. Safety Risk: Gasoline sprays out under pressure, contacting the vehicle, ground, and the person refueling. This is a fire hazard and exposes the user to fuel on skin and clothing. The condition is unpredictable and dangerous. Requested Action: Require Stellantis to inspect and repair the vehicle under CSN X39 and ensure compliance with the documented unlimited‑time warranty extension for this defect. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Fuel/Propulsion System

ODI #11709685

Incident: April 2, 2025 · Filed: January 8, 2026

Fuel spills out when you fill it up. I read there were safety recalls due to this issue for 2006 Dodge Durango's but a recall isn't appearing for my vehicle. When filling it fills fine until almost a full tank. Once it reaches full tank the gas pump clicks off then a gush of fuel spills out of my car. I bought it last year and it does it every time we put a full tank in it if you don't catch it and manually shut pump off before full. Bought the car used

Air Bags

ODI #11582337

Crash

Incident: April 11, 2024 · Filed: April 11, 2024

The contact owns a 2006 Dodge Durango. The contact stated that while driving at an undisclosed speed, another vehicle abruptly merged into his lane in front of him, prompting him to rapidly decrease speeds. However, the vehicle ahead was too close; as a result, the contact collided with the rear of the other vehicle, forcing his vehicle to careen to the shoulder of the roadway before coming to a complete stop. The air bags did not deploy. The air bag warning light was illuminated. A police report was filed, and no injuries were reported. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 15V313000 (Air Bags); the VIN was included, and the vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was 231,000

Fuel/Propulsion System

ODI #11509165

Incident: February 1, 2023 · Filed: February 26, 2023

Every time filling full of gas, once full it SPRAYS gas into the air for 2 to 3 seconds. It's evident this is a manufacturing defect as multiple self reported incidents can be found online throught the years. This is vreating a significant fire risk as other vehicles can be pulling up near by. Date provided isn't accurate as this is constant if we let it fill

Power Train; Unknown or Other; Fuel/Propulsion System

ODI #11447772

Incident: October 21, 2021 · Filed: January 17, 2022

Several repairs for sensor Labor: Check and advise the check engine light is on and the vehicle wants to stall when accelerating. Vehicle loses engine power but has not stalled completely (low/reverse solenoid circuit. Test and replaced transmission solenoid assembly; cost: $819.65, prior to that $1200.00, $546.00. I'm unemployed and the truck costing more repairs. The plastic on radiator has cracked all the way cross and leaks coolant, stop radiator leak encourage by dealership and to seal leak or replace radiator (it's upsetting and its cost me thousands of dollars, my last two SUV was dodge Durango and I love them but this one has given the most problems and cost me financially. Plus, when I purchased the dealership replace windshield because of flaw in glass and it wasn't repaired correctly and Oakland County Sheriff said my truck was dangerous, but you said it was fine. Plus, the wrapped chrome grill has been replaced twice because it bubbles up. Information listed at your dealerships: Purchased at Milosch's Palace Chrysler Jeep Dodge (work performed) 3800 S. Lapeer Rd Lake Orion, MI 48359 Milosch Dodge Inc. 677 S. Lapeer Rd Lake Orion, MI 48326 Golling Chrysler Jeep Dodge Inc 2405 S. Telegraph Rd. Bloomfield Hills, MI 48302 2483343600 Firestone Complete Auto Care Pontiac/Waterford 2385 Elizabeth Lake Rd Waterford, MI 48328-3309 Tow company from sensor: Buckhorn Service 1258 S. Lapeer Road Po box 251 lake Orion MI 48360 (248)693-9375 Goodyear Auto Service Center 50300 Woodward Avenue Pontiac, MI 48342 (248)3356167 Monro Auto dba Speedy Auto 3484 Highland Rd. Waterford Mi 48328 (248)6816500 Other Tow companies had to tow under insurance policy for sensor. It's my truck[XXX] now current address [XXX] and the service work was completed under the following names in the system [XXX] Father),[XXX] (self) and son [XXX]. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

Fuel/Propulsion System

ODI #11440291

Incident: November 12, 2021 · Filed: November 12, 2021

Fuel erupts from fuel filler neck EVERY TIME the fuel tank is filled, even when filling very slowly. A half-gallon or more of fuel ends up violently spitting out of the filler neck onto people in the vicinity, onto the side of the car, and onto the ground—every time the vehicle is refueled. Many owners apparently have the exact same issue, judging by the large number of complaints on Durango and Dodge forums. Apparently, there was a recall covering model-year 2005 Durangos for this issue, but the issue is present on our 2006 Durango. This is a clear safety defect that could easily create an extremely dangerous situation.

Steering

ODI #11437762

Incident: October 16, 2021 · Filed: October 22, 2021

design issue on rack and pinion assembly. Basically metal transfer pipes on side of assembly rust out. This is my second Durango 2006 model to have this problem. Complete loss of steering assist occurs because of loss of power fluid out of fore mentioned pipes. The pipes cannot be repaired, entire rack and assembly must be replaced. Exposure to road salt is cause of rusting as assembly is totally exposed under vehicle. Stainless steel pipes are a better way except to bean counters.

Power Train

ODI #11429082

Incident: January 8, 2021 · Filed: August 14, 2021

In the winter of 2020 i had to use my 4wd lock in my durango. It never come out of 4wd lock. As a former ase technician and auto center manager I have to say dodge has a mess on their hands. 1st off its ridiculous to stop the flow of technical information to the owners of chrysler vehicles due to globalization!? I have been working on this vehicle for months as my patience allows. All testing and troubleshooting place the issue back into electrical issues within these durangos. This is a dangerous problem so many people own older dodge & chrysler products affected by this transfer case problem, recall it and get it done! Now it has to go to a chrysler dealer to have the codes cleared by a dodge scanner. Issue with that is the local dodge dealer in the village i live is not known for honesty. I took my durango there when i had issues with security system. I was told it would need a $1000. computer to start, then maybe another $1000. I took it home put a security module in it, been driving it since. Hold Chrysler accountable, do something for these thousands of people who own nice looking nice running dodge products they can't drive due to transfer case issues, and its not just one issue, there are several issues & components in that system that are troublesome!!

Electrical System; Fuel/Propulsion System

ODI #11420736

Incident: June 3, 2021 · Filed: June 13, 2021

TIPM / PCM (Computer modules) these items are affecting most Dodge vehicles that is listed already for recalls only in 2011-2013 and one earlier. This is happening in a lot of Dodges, mine is 1D4HB48N76F[XXX] (2006 Durango 4.7 SLT). They will stop running anywhere, it shuts the fuel pump off where the vehicles no longer gets gas and you have a full tank. It is only a computerized Dealer fix. Their recall for some vehicles will fix my 2006 also by the simply relay bypass that they are installing. PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

Other Dodge Durango model years

Check your 2006 Dodge Durango VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Dodge Durango at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Dodge VIN