NHTSA vehicle safety data

2003 Chevrolet Silverado 2500 Recalls & Complaints

The 2003 Chevrolet Silverado 2500 has 2 NHTSA recall campaigns and 110 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Chevrolet dealer.

NHTSA recall and complaint data for the 2003 Chevrolet Silverado 2500. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2003 Chevrolet Silverado 2500 owner complaints

Owners have filed 110 complaints with NHTSA about the 2003 Chevrolet Silverado 2500, describing incidents dated December 15, 2002 to April 14, 2026.

Most-cited components

Service Brakes 50 complaints
Electrical System 24 complaints
Power Train 12 complaints
Engine 9 complaints
Fuel/Propulsion System 7 complaints
Vehicle Speed Control 7 complaints

Of the 110 complaints on file, 3 report a crash and 3 a fire; across all 110 complaints, owners report 3 injuries (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11731112 · Filed April 14, 2026
While driving down a 50 mph roadway there was a line of cars slowing for a vehicle to make a turn. When gently pushing the brakes to slow down, brake went clear to the floor and could not slow down. Truck was driven into the ditch to avoid rear-ending vehicles. This happened immediately without…
ODI #11531325 · Filed July 10, 2023
The component that failed according to the Chevrolet dealer is the "transfer case pump clips", which came loose inside the transfer case and wore a hole through the case causing the oil to come out. If I would not have noticed the oil on the back of my truck, I could have continued to drive the…
ODI #11529895 · Filed July 1, 2023
When starting vehicle , after initial dash lights times out, I now get an AIRBAG 9malfunction light). Tried resetting, did not work. Now, every time I start the engine, the comes on and stays on.

Read all 110 complaints

Owner-reported

2003 Chevrolet Silverado 2500 mileage at failure

92 of the 110 complaints on file for the 2003 Chevrolet Silverado 2500 give the vehicle's mileage when the problem happened.

Mileage at failure by component, from owners' complaints to NHTSA
Component	Median	Middle half	Based on
Service Brakes	Median 95,000 miles	Middle half 50,000–130,000 miles	Based on 48 complaints

A component's median is its 50th percentile, and its middle half runs from its 25th to its 75th percentile.

Owners give the mileage themselves, often as a round number, and NHTSA doesn't check it. A complaint that names several components counts under each one, and mileages that can't be right, such as 999,999, or 50 miles on a five-year-old car, are left out.

These figures describe the complaints owners filed. They don't predict when a particular vehicle will have a problem, and vehicles that never had one aren't counted.

Mileage from NHTSA's complaints file of October 31, 2026. How these figures are worked out

NHTSA defect investigations

NHTSA's investigations file lists the 2003 Chevrolet Silverado 2500 in 1 investigation. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Engineering Analysis EA04-012: HYDRAULIC PUMP FAILRES
Closed February 28, 2005
- Recall 05V-005

Open and recently closed NHTSA defect investigations

AFTERMARKET FUEL FILTERS/FUEL LEAK

NHTSA #06E043000 · Fuel System, Gasoline · NHTSA notice

Reported May 19, 2006 · HONEYWELL INTERNATIONAL, INC.

Potentially affected: 88,303 vehicles

Owners notified October 18, 2006

Defect description

CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.

Safety consequence

THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.

Manufacturer remedy

HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

AFTERMARKET REPLACEMENT PITMAN ARM

NHTSA #06E010000 · Steering · NHTSA notice

Reported February 1, 2006 · FABTECH MOTORSPORTS

Potentially affected: 1,360 vehicles

Defect description

CERTAIN FABTECH AFTERMARKET REPLACEMENT PITMAN ARMS, P/NOS. FTS71000 AND FTS71001, INSTALLED FOR USE ON CERTAIN 2001-2006 GM C/K 2500 PICK UP TRUCKS AND SPORT UTILITY VEHICLES. THE PIN LOCATED INSIDE THE PITMAN ARM CAN SHEAR OFF DUE TO A REVERSE BENDING FATIGUE CONDITION, RESULTING IN A TOTAL LOSS OF STEERING CONTROL.

Safety consequence

LOSS OF STEERING CONTROL COULD LEAD TO A VEHICLE CRASH WITH POTENTIAL INJURY OR DEATH.

Manufacturer remedy

FABTECH WILL NOTIFY OWNERS AND REPLACE THE PITMAN AND IDLER ARMS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING FEBRUARY 2006. OWNERS MAY CONTACT FABTECH AT 909-597-7800.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET FABTECH REPLACEMENT PITMAN ARMS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON C/K 2500 PICK UPS, SUVS, AND HUMMER H2 VEHICLES MANUFACTURED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

try.vin has no NCAP crash-test rating on file for the 2003 Chevrolet Silverado 2500. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

110 owner complaints have been filed with NHTSA for the 2003 Chevrolet Silverado 2500.

Service Brakes

ODI #11731112

Incident: April 14, 2026 · Filed: April 14, 2026

While driving down a 50 mph roadway there was a line of cars slowing for a vehicle to make a turn. When gently pushing the brakes to slow down, brake went clear to the floor and could not slow down. Truck was driven into the ditch to avoid rear-ending vehicles. This happened immediately without warning, all braking prior to this incident was normal. When taken to our mechanic, they advised the brake lines underneath were notorious for rusting out and failing, new stainless steel lines were then installed to correct the problem.

Power Train

ODI #11531325

Incident: June 28, 2023 · Filed: July 10, 2023

The component that failed according to the Chevrolet dealer is the "transfer case pump clips", which came loose inside the transfer case and wore a hole through the case causing the oil to come out. If I would not have noticed the oil on the back of my truck, I could have continued to drive the truck, which could have caused the transfer case gears to lock up the front and rear axles while driving and could have caused me to wreck, causing injury to myself, my family or someone else. I marked the area of the leak with a sharpie as depicted in the photos.

Air Bags

ODI #11529895

Incident: June 15, 2023 · Filed: July 1, 2023

When starting vehicle , after initial dash lights times out, I now get an AIRBAG 9malfunction light). Tried resetting, did not work. Now, every time I start the engine, the comes on and stays on.

Service Brakes

ODI #11489582

Incident: June 3, 2021 · Filed: October 17, 2022

Hydroboost valve pump shows a recall.,and it's not working properly

Power Train

ODI #11489023

Incident: October 7, 2022 · Filed: October 12, 2022

I had to replace the replace the housing on my transfer case as it wore a hole in and was leaking. At a cost of 1200 dollars due to myself catching it early as later with a fully disabled case would have been 2600 dollars. My mechanic who deals in transmission repairs told me this a very common problem for Chevy trucks from 1999 to 2006. He claimed he had done 7 transfer cases in one week and was actually replacing a fully wrecked one for 2600 dollars as I brought mine in to be worked on . It had worn a hole through the transfer case and was leaking. As this seems to be a serious defect . I feel it should have been under a recall and reimbursement should be in order for those who paid out of pocket for repairs. My mechanic also stated that he has replaced them at 35, 000 miles and on up. No rhyme or reason to when they fail or leak.

Engine and Engine Cooling

ODI #11460336

Incident: April 1, 2022 · Filed: April 10, 2022

In the middle of the taxiway, while I was traveling my truck turned off while it was running and did not turn on again, putting my safety at risk by being in the middle of the taxiway, after several minutes the truck was able to be removed from the road, then I was able to investigate that I am not the only one that the same thing has happened to him, there is no Safety Recall in this regard, the GM fabric is aware of these cases but only wrote a TSB, it was diagnosed with the scanner and it gave code U1800, before the event there were no lights warning but after the event there is a check engine light on.

Fuel/Propulsion System

ODI #11271073

Incident: October 9, 2019 · Filed: October 25, 2019

TL* THE CONTACT OWNS A 2003 CHEVROLET SILVERADO 2500. WHILE THE CONTACT WAS CHANGING THE OIL IN THE VEHICLE, HE NOTICED OIL LEAKING WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO VISUALLY INSPECTED THE VEHICLE AND DETERMINED THAT THE FUEL LINE WAS FRACTURED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. HOLZ MOTORS (5961 S 108TH ST, HALES CORNERS, WI 53130, (414) 377-3584) WAS CONTACTED AND STATED THAT THE VIN WAS NOT INCLUDED IN A RECALL. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 139,000.

Service Brakes

ODI #11254984

Incident: August 21, 2019 · Filed: September 12, 2019

TL* THE CONTACT OWNS A 2003 CHEVROLET SILVERADO 2500. WHILE THE CONTACT'S SON WAS DRIVING 2 MPH IN A PARKING LOT, THE BRAKE PEDAL WAS APPLIED, BUT THE VEHICLE FAILED TO RESPOND WHEN IT WAS DEPRESSED TO THE FLOORBOARD. THERE WERE NO WARNING INDICATORS ILLUMINATED. ALSO, THE LOW BRAKE FLUID INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO LINDSAY BUICK GMC (250 W SHIRLEY AVE, WARRENTON, VA 20186, (540) 987-2082) WHERE IT WAS DIAGNOSED THAT THE BRAKE LINES WERE CORRODED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 190,703.

Service Brakes

ODI #11254729

Incident: September 1, 2019 · Filed: September 11, 2019

TL* THE CONTACT OWNS A 2003 CHEVROLET SILVERADO 2500. WHILE DEPRESSING THE BRAKE PEDAL, THE VEHICLE WOULD NOT IMMEDIATELY STOP AND THE BRAKE PEDAL TRAVELED TO THE FLOORBOARD. THE CONTACT NOTICED BRAKE FLUID LEAKING UNDER THE DRIVER'S SIDE OF THE VEHICLE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE BRAKE LINES WERE CORRODED AND FAILED, WHICH CAUSED BRAKE FLUID TO LEAK OUT. THE BRAKE LINES WERE REPLACED. THE MANUFACTURER AND LOCAL DEALER WERE NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 133,900.

Steering; Service Brakes

ODI #11232522

Incident: June 6, 2019 · Filed: July 16, 2019

I BOUGHT A 2003 CHEVY SILVERADO 2500HD 15 YEARS AGO AND GAVE IT TO MY 16 YEAR OLD SON. RECENTLY WE NOTICED THAT THE BRAKES AND STEERING WAS ACTING FUNNY AND MAKING A NOISE, SO WE REPLACED THE POWER STEERING PUMP AND HOSES. THE PROBLEM ONLY STARTED GETTING WORSE. I DID SOME RESEARCH AND FOUND AN OLD RECALL OR NOTICE RELATED TO THE HYDRO-BOOST RELIEF VALVE THAT WAS DEFECTED BECAUSE OF O-RING FAILURE. JUST SEARCHING THE VEHICLE WILL SHOW SEVERAL SITES REVEALING THE PROBLEM. THE NADA SITE GOES INTO MORE DETAIL ON THE PROBLEM. WE HAVE PARKED THE TRUCK UNTIL A DECISION IS MADE. I CONTACTED THE MANUFACTURE AND THEY STATED THAT THERE WAS NO PROBLEM, THE VEHICLE HAS TROUBLE WHEN STEERING AND LOOSES BRAKING.

Other Chevrolet Silverado 2500 model years

Check your 2003 Chevrolet Silverado 2500 VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Chevrolet Silverado 2500 at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Chevrolet VIN