NHTSA vehicle safety data

2008 Volvo VNM Recalls & Complaints

The 2008 Volvo VNM has 10 NHTSA recall campaigns and 1 owner complaint on file as of November 3, 2026. Recall repairs are usually free at an authorized Volvo dealer.

NHTSA recall and complaint data for the 2008 Volvo VNM. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2008 Volvo VNM owner complaints

Owners have filed 1 complaint with NHTSA about the 2008 Volvo VNM, describing incidents dated January 5, 2008.

Most-cited components

Air Bags 1 complaint

The complaint on file reports a crash, with 1 injury (owner-reported, not verified by NHTSA).

Newest complaints

ODI #10220749 · Filed March 11, 2008
THE FOLLOWING COMPLAINT IS REGARDING A 2008 VOLVO TRUCK (MODEL VNM 200, 2 AXLE DAYCAB). I WAS DRIVING THIS MODEL OF TRUCK PULLING TWO TRAILERS AT THE TIME OF MY CRASH. THIS VEHICLE SUSTAINED SIGNIFICANT FRONT-END DAMAGE. HOWEVER, THE AIRBAG FAILED TO DEPLOY. THIS ACCIDENT OCCURRED ON INTERSTATE 15…

Read the full complaint

NHTSA defect investigations

NHTSA's investigations file lists the 2008 Volvo VNM in 4 investigations. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Preliminary Evaluation PE13-002: Stop Lamp Switch Signal
Closed July 3, 2013
- Recall 13V-268
Recall Query RQ11-001: Volvo Sleeper glass de-bonding
Closed January 20, 2012
Preliminary Evaluation PE10-028: Front Air Brake Hose Interference
Closed December 23, 2010
Preliminary Evaluation PE07-046: SAF HOLLAND FIFTH WHEEL ASSEMBLY
Closed November 9, 2007

Open and recently closed NHTSA defect investigations

Redundant Clutch Disengagement Signal

NHTSA #13V268000 · Power Train — Clutch Assembly · NHTSA notice

Reported June 26, 2013 · Volvo Trucks North America

Potentially affected: 23,056 vehicles

Volvo campaign RVXX1303 · Owners notified August 26, 2013 · Vehicles built December 20, 2006 – May 22, 2013 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

Volvo Trucks North America (Volvo) is recalling certain model year 2007-2014 VAH, VHD, VNL, VNM, and VT models. The affected vehicles were built without a redundant clutch disengagement switch. Without a redundant switch, a loss of signal from the brake air pressure switch can prevent the clutch from automatically disengaging when the brake is applied.

Safety consequence

Without a signal to disengage the clutch when the brakes are applied, the distance required to stop the truck may lengthen, increasing the risk of a crash.

Manufacturer remedy

Volvo Trucks will notify owners and dealers will inspect and repair the vehicles if necessary. The recall began on August 26, 2013. Volvo's recall number is RVXX1303. Owners may contact Volvo at 1-336-393-2000.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

CERTIFICATION LABEL TIRE DESCRIPTION/PART 567

NHTSA #10V492000 · Equipment — Other — Labels · NHTSA notice

Reported October 12, 2010 · VOLVO TRUCKS NORTH AMERICA

Potentially affected: 1,926 vehicles

Volvo campaign RVXX1005 · Owners notified February 25, 2011 · Vehicles built August 13, 2007 – March 26, 2010 (per NHTSA)

Defect description

VOLVO IS RECALLING CERTAIN MODEL YEAR 2008-2011 VHD, VNL, VNM, AS WELL AS 2008-2010 VT VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF PART 567, "CERTIFICATION." THE TIRE DESCRIPTION MAY BE INCORRECT ON THE VEHICLE'S CERTIFICATION LABEL.

Safety consequence

THE MISINFORMATION ON THESE LABELS COULD LEAD TO A VEHICLE OVERLOADING THAT CAN INCREASE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL INSPECT AND REPLACE THE LABELS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 25, 2011. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.

Notes

VOLVO SAFETY RECALL NO. RVXX1005.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

WIPER MOTOR

NHTSA #09V173000 · Visibility — Windshield Wiper/Washer — Motor · NHTSA notice

Reported May 21, 2009 · VOLVO TRUCKS NORTH AMERICA

Potentially affected: 127,764 vehicles

Volvo campaign RVXX0902 · Owners notified September 30, 2009

Defect description

VOLVO TRUCKS IS RECALLING 127,764 MY 2001-2008 VHD, VNL, VNM, AND MY 2005-2008 VT TRUCKS. A SEAL MAY FAIL ALLOWING WATER AND CONTAMINANTS TO SEEP INTO THE WINDSHIELD WIPER MOTOR.

Safety consequence

IF THIS HAPPENS A SHORT CIRCUIT MAY OCCUR, WHICH OVER TIME COULD POSSIBLY LEAD TO A VEHICLE FIRE.

Manufacturer remedy

VOLVO WILL REPLACE THE WIPER MOTOR FREE OF CHARGE. SINCE THIS RECALL INVOLVES A LARGE NUMBER OF VEHICLES, VOLVO WILL RELEASE THE RECALL IN STAGES AS PARTS ARE RECEIVED. PRIORITY WILL BE GIVEN TO THE VEHICLES LOCATED IN THE REGIONS/STATES THAT HAVE A CORROSIVE ENVIRONMENT. THE RECALL BEGAN ON SEPTEMBER 30, 2009. OWNERS MAY CONTACT VOLVO TRUCKS AT 1-800-528-6586.

Notes

VOLVO TRUCKS RECALL NO. RVXX0902.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

LIGHTING SYSTEM/CIRCUIT BREAKERS

NHTSA #07V573000 · Electrical System — Wiring — Fuses and Circuit Breakers · NHTSA notice

Reported December 14, 2007 · VOLVO TRUCKS NORTH AMERICA

Potentially affected: 104,845 vehicles

Volvo campaign RVXX0707 · Owners notified February 25, 2008

Defect description

ON CERTAIN HEAVY DUTY TRUCKS, THE CIRCUIT PROTECTION (I.E. AUTOMATIC CIRCUIT BREAKERS) USED TO PROTECT THE VEHICLE LIGHTING SYSTEM MAY NOT PROVIDE ADEQUATE PROTECTION.

Safety consequence

IF A SHORT CIRCUIT OCCURS AND IS LEFT UNTREATED, COMPONENTS AND WIRING MAY BE SUBJECT TO OVERHEATING WHICH COULD POSSIBLY RESULT IN A VEHICLE FIRE.

Manufacturer remedy

DEALERS WILL REPLACE THE CIRCUIT BREAKERS WITH FUSES. THE RECALL BEGAN ON FEBRUARY 25, 2008. OWNERS MAY CONTACT VOLVO TRUCKS AT 1-800-528-6586.

Notes

VOLVO TRUCKS RECALL NO. RVXX0707.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

STEERING GEAR MOUNTING BOLTS

NHTSA #07V529000 · Steering — Gear Box (OTHER THAN RACK AND PINION) · NHTSA notice

Reported November 19, 2007 · VOLVO TRUCKS NORTH AMERICA

Potentially affected: 2,054 vehicles

Volvo campaign RVXX0706 · Owners notified December 3, 2007 · Vehicles built July 2, 2007 – September 21, 2007 (per NHTSA)

Defect description

ON CERTAIN TRUCKS, THE BOLTS THAT ATTACH THE STEERING GEAR TO THE FRAME MAY NOT HAVE BEEN TIGHTENED TO THE SPECIFIED TORQUE.

Safety consequence

LOSS OF STEERING CONTROL COULD OCCUR INCREASING THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL TIGHTEN THE BOLTS FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 3, 2007. OWNERS MAY CONTACT VOLVO TRUCKS AT 1-800-528-6586.

Notes

VOLVO TRUCKS RECALL NO. RVXX0706.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

SAF HOLLAND SIMPLEX FIFTH WHEEL/ARM PIVOT BOLT

NHTSA #07V496000 · Trailer Hitches — Fifth Wheel Assembly · NHTSA notice

Reported October 23, 2007 · VOLVO TRUCKS NORTH AMERICA

Potentially affected: 6,519 vehicles

Volvo campaign RVXX0705 · Owners notified January 28, 2008 · Vehicles built January 9, 2006 – June 29, 2007 (per NHTSA)

Defect description

ON CERTAIN TRUCKS EQUIPPED WITH A SAF HOLLAND SIMPLEX FIFTH WHEEL, THE LEVER ARM PIVOT BOLT MAY HAVE BEEN OVER TIGHTENED. AN OVER TIGHTENED PIVOT BOLT CAN DISTORT THE PIVOT BOLT SPACER SLEEVE, WHICH MAY PREVENT THE FIFTH WHEEL LATCH JAW FROM CLOSING AND LATCHING SECURELY AROUND THE TRAILER KING PIN.

Safety consequence

THERE IS A POSSIBILITY THAT THE PIVOT BOLT CAN BECOME LOOSE WITHOUT THE DRIVER'S KNOWLEDGE. WHEN THIS OCCURS, THE DRIVER COULD DRIVE AWAY AND THE TRAILER COULD BECOME DISENGAGED, INCREASING THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL REPLACE THE PIVOT BOLT AND SLEEVE WITH A HEX HEAD SHOULDER BOLT AND WASHER FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 28, 2008. OWNERS MAY CONTACT VOLVO TRUCKS AT 1-800-528-6586.

Notes

VOLVO TRUCKS RECALL NO. RVXX0705.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

HOOD RESTRAINT CYLINDER

NHTSA #07V410000 · Structure — Body — Hood — Hinge and Attachments · NHTSA notice

Reported September 10, 2007 · VOLVO TRUCKS NORTH AMERICA

Potentially affected: 956 vehicles

Volvo campaign RVXX0704 · Owners notified October 15, 2007 · Vehicles built March 12, 2007 – May 11, 2007 (per NHTSA)

Defect description

ON CERTAIN TRUCKS, THE HOOD RESTRAINT CYLINDER DOES NOT CONTAIN ENOUGH DAMPENING TO ADEQUATELY RESTRAIN THE HOOD.

Safety consequence

THE CYLINDERS COULD POSSIBLY SEPARATE, WHICH WOULD LEAVE THE HOOD UNRESTRAINED WHEN OPENING AND CLOSING THE HOOD.

Manufacturer remedy

DEALERS WILL REPLACE THE HOOD RESTRAINT CYLINDERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 15, 2007. OWNERS MAY CONTACT VOLVO TRUCKS AT 1-800-528-6586.

Notes

VOLVO RECALL NO.RVXX0704.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

FUEL-WATER SEPARATOR PREHEATER/DAVCO

NHTSA #07V345000 · Fuel System, Diesel · NHTSA notice

Reported August 7, 2007 · VOLVO TRUCKS NORTH AMERICA

Potentially affected: 677 vehicles

Volvo campaign RVXX0703 · Owners notified September 10, 2007 · Vehicles built December 5, 2006 – March 7, 2007 (per NHTSA)

Defect description

ON CERTAIN TRUCKS, AN UNPROTECTED LEAD IN THE THERMOSWITCH OF THE HEATER MAY MAKE CONTACT WITH ANOTHER POST POSSIBLY CREATING A SHORT CIRCUIT, WHICH CAN RESULT IN CONTINUOUS OPERATION OF THE HEATING ELEMENT.

Safety consequence

IF THE CONDITION EXISTS AND THE KEY IS LEFT ON WITHOUT FUEL IN THE FILTER, THE HEATING ELEMENT MAY HEAT TO A POINT WHERE A FLAME BECOMES PRESENT AT THE TIP OF THE ELEMENT WHICH COULD RESULT IN A VEHICLE FIRE.

Manufacturer remedy

DEALERS WILL INSPECT THE THERMOSWITCH AND WILL REPLACE IT IF NECESSARY. THE RECALL BEGAN ON SEPTEMBER 10, 2007. OWNERS MAY CONTACT VOLVO TRUCKS AT 1-800-528-6586.

Notes

VOLVO TRUCK RECALL NO. RVXX0703.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

STEERING SHAFT LOCKNUT

NHTSA #07V323000 · Steering · NHTSA notice

Reported July 24, 2007 · VOLVO TRUCKS NORTH AMERICA

Potentially affected: 9,102 vehicles

Volvo campaign RVXX0702 · Owners notified August 24, 2007 · Vehicles built November 14, 2006 – May 30, 2007 (per NHTSA)

Defect description

ON CERTAIN TRUCKS, THE NUT USED TO RETAIN THE STEERING SHAFT MAY OR MAY NOT BE A LOCK NUT THAT HAS THE LOCKING FEATURE. A LOCK NUT IS REQUIRED TO PROVIDE ADDITIONAL RESISTANCE TO ENSURE THAT THE NUT DOES NOT COME LOOSE.

Safety consequence

IF THE NUT WERE TO COME LOOSE, THE STEERING SHAFT COULD POTENTIALLY SEPARATE RESULTING IN LOSS OF STEERING CONTROL WHICH COULD CAUSE A CRASH.

Manufacturer remedy

DEALERS WILL REPLACE THE STEERING SHAFT PINCH BOLTS AND LOCKNUTS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 24, 2007. OWNERS MAY CONTACT VOLVO TRUCKS AT 1-800-528-6586.

Notes

VOLVO RECALL NO. RVXX0702.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

AXLE HOUSING/DANA

NHTSA #07V108000 · Power Train — Axle Assembly · NHTSA notice

Reported March 16, 2007 · VOLVO TRUCKS NORTH AMERICA

Potentially affected: 84 vehicles

Volvo campaign RVXX0701 · Owners notified April 9, 2007 · Vehicles built December 1, 2006 – February 28, 2007 (per NHTSA)

Defect description

ON CERTAIN TRUCKS, THE AXLE HOUSINGS MAY HAVE BEEN MANUFACTURED WITH STEEL THAT WAS OUT OF SPECIFICATION WHICH COULD RESULT IN A FATIGUE FAILURE OVER TIME.

Safety consequence

IF A FATIGUE FAILURE OCCURS AND IS LEFT UNATTENDED, THE AXLE MAY LOCK UP OR THE END OF THE AXLE COULD COME OFF, WHICH MAY RESULT IN A VEHICLE CRASH.

Manufacturer remedy

DEALERS WILL REPAIR AND INSPECT THE AXLES AND REPLACE THEM FREE OF CHARGE. THE RECALL BEGAN ON APRIL 9, 2007. OWNERS MAY CONTACT VOLVO TRUCKS AT 1-800-528-6586.

Notes

VOLVO TRUCKS RECALL NO. RVXX0701.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

try.vin has no NCAP crash-test rating on file for the 2008 Volvo VNM. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

1 owner complaint has been filed with NHTSA for the 2008 Volvo VNM.

Air Bags

ODI #10220749

Crash 1 injury

Incident: January 5, 2008 · Filed: March 11, 2008

THE FOLLOWING COMPLAINT IS REGARDING A 2008 VOLVO TRUCK (MODEL VNM 200, 2 AXLE DAYCAB). I WAS DRIVING THIS MODEL OF TRUCK PULLING TWO TRAILERS AT THE TIME OF MY CRASH. THIS VEHICLE SUSTAINED SIGNIFICANT FRONT-END DAMAGE. HOWEVER, THE AIRBAG FAILED TO DEPLOY. THIS ACCIDENT OCCURRED ON INTERSTATE 15 NEAR EXIT 36 IN UTAH. I WAS TRAVELING SOUTHBOUND AT APPROXIMATELY 55 MPH WHEN I COLLIDED WITH A BOULDER. THE IMPACT WITH THE BOULDER WAS NEAR THE FRONT RIGHT CORNER OF THE BUMPER, ALSO STRIKING THE RIGHT STEER TIRE AND HITTING VARIOUS OTHER PARTS OF THE RIG. AFTER COLLIDING WITH THE BOULDER I FOUGHT TO KEEP THE VEHICLE STRAIGHT FOR ABOUT 2 TO 4 SECONDS. AFTER THIS, THE TRACTOR BEGAN TO VEER OFF TO THE RIGHT ON ITS OWN, SUBSEQUENTLY CRASHING INTO A STEEP EMBANKMENT. THIS IMPACT WAS WITH THE LEFT FRONT PART OF THE TRUCK. ULTIMATELY THE TRUCK AND FRONT TRAILER ROLLED ONTO THEIR LEFT SIDES COMING TO REST FACING NORTH. THE IMPACT WITH THE EMBANKMENT WAS SO SEVERE THAT THE ENGINE WAS PUSHED BACK AND EVEN THE INTERIOR CENTER CONSOLE WAS PUSHED BACK AGAINST THE GEARSHIFT. THE LIGHT SWITCH POPPED OUT AS WELL AS VARIOUS OTHER INTERIOR PANELS. THE RIGHT EXTERIOR MIRROR SWUNG ALL THE WAY FORWARD FROM THE IMPACT. THE STEERING WHEEL WAS BENT UPWARDS. MY INJURIES ARE CONSISTENT WITH BEING THROWN FORWARD; BROKEN NECK, BROKEN BACK, BROKEN RIBS, LEFT SHOULDER SPRAIN, AND KNEE CONTUSIONS. I SUFFERED THESE INJURIES EVEN THOUGH I WAS WEARING MY SEAT BELT. I HOPE THAT THIS COMPLAINT WILL BE INVESTIGATED FURTHER. *TR

Other Volvo VNM model years

Check your 2008 Volvo VNM VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Volvo VNM at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Volvo VIN