2010 Volkswagen Passat Recalls, Ratings & Complaints

Incident: March 11, 2026 · Filed: March 14, 2026

My 2010 Volkswagen CC became completely inoperable because of the active fuel pump control module recall (NHTSA 17V509). The vehicle stalled and nearly caused an accident. The check engine light came on just before I noticed a burning smell coming from the backseat of my car immediately after smelling that the car suddenly stalled out in the middle of a busy intersection and the engine would not start back up. I had to push it to a gas station parking lot across 3 lanes of traffic. I lifted up the backseat and found that the fuel control module was overheated and melting on top of the fuel pump so I carefully and properly disconnected it from the vehicle. The next day I had the vehicle towed to Lokey Volkswagen in Clearwater, FL. Today 3/14/2026 They did the recall repair and told me my vehicle is safe to drive. Today 3/14/2026 I drove the car 1 mile from the dealership when the exact same thing happened again the car stalled out, and I had to carefully maneuver to the shoulder of hwy us 19 s narrowly missing vehicles in the other lanes. The vehicle was then towed back to lokey Volkswagen. It is pretty clear that the issue was not resolved, and that this fuel control module failing may have affected other parts of the fuel system/wiring and or the fuel control module failed again. I have pictures of the fuel control module, and I gave the initial melted/failed fuel control module to the service department and they took it. The dealership service department is stating that this may be to do something other than the recall repair and that I may be liable for the diagnostic and towing charges. This is a very serious safety issue that almost cost me to get in accidents on the highway twice. I feel that they (Volkswagen) needs to be held responsible for rectification and to find out if there is a connection between this recall and the continuing failure of the vehicle to operate safely.

Incident: October 13, 2024 · Filed: October 23, 2024

I purchased a used vehicle but have found out the oxygen sensor is feeding false error codes to the main OBC causing leaks into driver compartment causing engine to stall while auto in motion and most importantly causing steering wheel to lock, have spoken with VWoA but they have no direct influence with VW or dealerships even if a warranty issue because all parties are independent contractors and all they are able to do is try and help. My name has not been transferred to registration because of smog requirements so you may call me [XXX] my telephone number is [XXX] my case# with VWoA is [XXX], I myself have learned to deal with defects but should this matter be more widespread which I cannot find out because the last case regarding the sensors was sealed in an agreement made by the California ARB, EPA and VW and Audi through a settlement signed in December 2021. Once again my hands are tied from taking much more action but I believe your department whether is able to enforce this matter or not should at least investigate and issue warnings to advise people of what can happen so if they can even at own cost seek appropriate repairs before more damages accrued. Also if this sensor is effecting more models and manufacturers an appropriate temporary fix should be seeker since no long term solutions are available at this time INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident: February 25, 2024 · Filed: March 25, 2024

The contact owns a 2010 Volkswagen Passat. The contact stated while driving at various speeds, there was a strong fuel odor inside and outside the vehicle. The contact stated that the failure persisted while the vehicle was parked and turned off. The check engine warning light was illuminated. The contact stated that the strong fuel odor had caused her to have headaches while driving. The vehicle was taken to an independent mechanic, where it was diagnosed that the fuel pump module had failed, causing the fuel pump to leak. Additionally, the contact stated that the vehicle had failed to start and was undrivable. The dealer was notified of the failure and advised the contact to bring the vehicle to their location for the repairs. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that they could not assist because NHTSA Campaign Number: 17V509000 (Fuel System, Gasoline) had already been completed on the vehicle. The failure mileage was approximately 148,000.

Incident: January 19, 2024 · Filed: January 24, 2024

The contact owns a 2010 Volkswagen Passat. The contact stated that while her son was driving at an undisclosed speed, the vehicle inadvertently lost motive power. The driver was able to coast to the shoulder of the roadway, where the vehicle was able to be restarted. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic, who diagnosed a failure with the thermostat. The vehicle was repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 17V509000 (Fuel System, Gasoline) but the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was 61,000.

Incident: July 13, 2022 · Filed: August 2, 2023

Replaced cracked fuel pump 3 times. Electrical problem to fuel pump ; also all were cracked from pressure. Thx !! Dr.

Incident: August 1, 2023 · Filed: August 1, 2023

As the trunk hatch opens and closes, the wiring to the hatch wears down, frays, and then shorts or breaks. This killed our rear view camera, which is a safety issue. This also can cut off light to the license plate. The rear hatch also cannot then be opened from the rear of the car, as the handle is electrical and gets disconnected, possible causing another safety issue.

Incident: March 17, 2022 · Filed: July 24, 2023

Drove the car to and from work that day with no problems. Also, went back to work a 2nd side job that evening with no issues. Got home, shut the car off and when my wife and I went out to go to work the next morning at 5 a.m., the car wouldn't start at all. Wouldn't even click. Did a lot of research because I had the starter replaced about 2 weeks before and knew it couldn't be the starter and also had bought a new battery when I had the starter replaced as well, so knew it wouldn't be the battery. After a lot, I mean a lot of research online, finally came to the decision it was the timing chain tensioner was faulty. When I went to replace the tensioner for the timing chain, I took my camera and put it in the cylinder heads and found out that there was 2 broken valves in the number 3 piston. One was broken and sideways in the piston and the other just broken. I'm not sure whether a rod has gone through the bottom of the head or not, couldn't get my camera to go that far down. So now I have no vehicle what-so-ever to drive back and forth to work. My wife had to resign from her job because she had no way to get there everyday and I have to pay someone gas money weekly to pick me up and bring me home from work so needless to say, we are currently struggling, can't pay our bills because my wife cannot get a job and now I have to figure out how to repair this damage that should have been made a recall for these volkswagens because by the looks of things, there are over 100 people that have had this same problem. An engine is going to be between $4,000 and $6,000 to repair and I have no way to fix this at that price. So now I am probably going to have to just junk the car.

Incident: January 18, 2023 · Filed: January 24, 2023

I was in my car driving , as soon as I go for a turn my car stalled on me infront of everyone , almost causing a wreck.

Incident: July 1, 2022 · Filed: September 28, 2022

There is a short in the wiring for the tail lights the short in the wires also effects the trunk wiring. The design of the wiring in the trunk bends the tail light wires and wears them out so now there is a short in the tail light, reverse light , fog light and the trunk release. It is very unsafe to have these lights not work and to have a faulty wiring.

Incident: November 15, 2021 · Filed: November 15, 2021

The car was hit broadside on the passenger side front door, spun around and hit head in to a power pole. With all this happening none of the airbags deployed.