NHTSA vehicle safety data

2001 Volkswagen Passat Recalls, Ratings & Complaints

The 2001 Volkswagen Passat has 4 NHTSA recall campaigns and 429 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Volkswagen dealer.

NHTSA recall and complaint data for the 2001 Volkswagen Passat, plus NCAP crash-test ratings. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2001 Volkswagen Passat owner complaints

Owners have filed 429 complaints with NHTSA about the 2001 Volkswagen Passat, describing incidents dated October 8, 2000 to June 18, 2026.

Most-cited components

Engine 96 complaints
Electrical System 71 complaints
Service Brakes 63 complaints
Fuel/Propulsion System 43 complaints
Power Train 33 complaints
Visibility/Wiper 29 complaints

Of the 429 complaints on file, 14 report a crash and 14 a fire; across all 429 complaints, owners report 11 injuries (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11745122 · Filed June 18, 2026
My fuses keep blowing, this is leading to replacing the Brake switch which I believe was recalled. If it was replaced,it's not working.
ODI #11422304 · Filed June 25, 2021
The driver's side airbag of my 2001 VW Passat spontaneously deployed while I drove on Hwy 494 in Woodbury MN. Sometime within 24 hours before the airbag deployed, the airbag fault light turned on in the car's dashboard display. Within 15 minutes before the incident, the car's automatic locking locks…
ODI #11389398 · Filed January 22, 2021
TOOK CAR TO VW DEALER TO HAVE TIMING BELT REPLACED AND WAS NOTIFIED THAT THERE WERE SEVERAL OPEN RECALLS AND THEY OFFERED TO TAKE CARE OF THEM FREE OF CHARGE. HOWEVER, THEY WERE UNABLE TO PERFORM RECALL #08V156. MANUFACTURER #26E5. THEY INSTALLED THE HEAT SHIELD BUT COULD NOT PERFORM SOFTWARE…

Read all 429 complaints

Owner-reported

2001 Volkswagen Passat mileage at failure

275 of the 429 complaints on file for the 2001 Volkswagen Passat give the vehicle's mileage when the problem happened.

Mileage at failure by component, from owners' complaints to NHTSA
Component	Median	Middle half	Based on
Engine	Median 65,000 miles	Middle half 45,000–100,000 miles	Based on 67 complaints
Electrical System	Median 40,000 miles	Middle half 20,000–80,000 miles	Based on 49 complaints
Service Brakes	Median 80,000 miles	Middle half 60,000–115,000 miles	Based on 40 complaints
Fuel/Propulsion System	Median 70,000 miles	Middle half 40,000–135,000 miles	Based on 30 complaints

A component's median is its 50th percentile, and its middle half runs from its 25th to its 75th percentile.

Owners give the mileage themselves, often as a round number, and NHTSA doesn't check it. A complaint that names several components counts under each one, and mileages that can't be right, such as 999,999, or 50 miles on a five-year-old car, are left out.

These figures describe the complaints owners filed. They don't predict when a particular vehicle will have a problem, and vehicles that never had one aren't counted.

Complaints received before December 15, 2002 rarely give a mileage, so they aren't counted here.

Mileage from NHTSA's complaints file of October 31, 2026. How these figures are worked out

NHTSA defect investigations

NHTSA's investigations file lists the 2001 Volkswagen Passat in 7 investigations. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Engineering Analysis EA11-002: Engine Compartment Fire
Closed February 17, 2012
Engineering Analysis EA07-014: PASSENGER ENGINE COMPARTMENT FIRES
Closed July 7, 2008
- Recall 08V-156
Preliminary Evaluation PE08-008: FUEL TANK LEAK
Closed May 30, 2008
- Recall 08V-156
- Recall 08V-157
Preliminary Evaluation PE07-024: PASSENGER/ENGINE COMPARTMENT FIRES
Closed September 28, 2007
Defect Petition DP05-004: ENGINE STALLING
Closed December 8, 2005

2 more NHTSA investigations

Engineering Analysis EA03-020: PASSENGER AIR BAG LID FAILURE
Closed April 23, 2004
Preliminary Evaluation PE03-021: PASSENGER SIR DOOR MOUNTING STUD FAILURE
Closed October 7, 2003

Open and recently closed NHTSA defect investigations

Water Pump may cause Failure of Timing Belt

NHTSA #14E007000 · Engine and Engine Cooling — Engine · NHTSA notice

Reported March 7, 2014 · The Gates Corporation

Potentially affected: 50 vehicles

Repair completion: 2% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Owners notified May 1, 2014

Defect description

The Gates Corporation (Gates) is recalling certain aftermarket Tru-Flow Water Pumps, part number TFW 41127, sold at certain NAPA Auto Parts and/or installed by automotive service technicians after November 1, 2013 (and manufactured August 2013 through October 2013) that have a black-colored pulley/sprocket or do not have 'US9377' stamped on the water pump housing. These service replacement parts were sold for use in model year 1999-2005 Audi A4, 2000-2006 Audi TT, 1998-2005 Volkswagen Beetle, 1999-2006 Golf, 1999-2008 and 2011-2013 Volkswagen Jetta, and 2000-2005 Volkswagen Passat. In the affected water pumps, the pulley or sprocket that turns the timing belt may develop microfractures causing the timing belt to fail.

Safety consequence

A failure of the timing belt may cause the engine to shut down, potentially increasing the risk of a vehicle crash.

Manufacturer remedy

Gates will notify owners, and dealers will replace the water pump, free of charge. The recall began during May 2014. Owners may contact The Gates Corporation at 1-303-744-1911.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

UNDERBODY HEAT SHIELDS/FUEL SYSTEM COMPONENTS

NHTSA #08V156000 · Fuel System, Gasoline — Delivery · NHTSA notice

Reported April 7, 2008 · VOLKSWAGEN OF AMERICA, INC

Potentially affected: 412,000 vehicles

Volkswagen campaign 26E5/R5 · Owners notified June 13, 2008 · Vehicles built June 1, 1999 – May 31, 2005 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

VOLKSWAGEN IS RECALLING 412,000 MY 1999-2005 PASSAT (5TH GENERATION) VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS AND PRODUCED AFTER JUNE 14, 1999. THESE VEHICLES MAY HAVE AN UNDERBODY HEAT SHIELD THAT CAN BECOME DAMAGED. IN ADDITION, AFFECTED VEHICLES WITH AUTOMATIC OR MANUAL TRANSMISSIONS MAY HAVE A FUEL LINE (1.8T ENGINES ONLY) OR FUEL TANK VENTILATION VALVE (4MOTION/ALL WHEEL DRIVE ONLY) THAT CAN LEAK DUE TO FRACTURE.

Safety consequence

A HEAT SHIELD THAT MAY CONTACT THE EXHAUST SYSTEM CAN RESULT IN A VEHICLE FIRE. IN ADDITION, A FUEL LEAK FROM A FUEL LINE OR FUEL TANK VENTILATION VALVE, IN THE PRESENCE OF AN IGNITION SOURCE, CAN LEAD TO A VEHICLE FIRE.

Manufacturer remedy

DEALERS WILL INSTALL ADDITIONAL UNDERBODY HEAT SHIELDS ON VEHICLES WITH AUTOMATIC TRANSMISSIONS TO COVER THE POSSIBLY DAMAGED AREAS AND FLASH ALL 1.8T ENGINES WITH A PRECAUTIONARY SOFTWARE UPDATE. DEALERS WILL ALSO INSPECT AND ADJUST THE FUEL LINE ROUTING ON 1.8T VEHICLES AND THE FUEL TANK VENTILATION VALVE ON 4MOTION/ALL WHEEL DRIVE VEHICLES, AND REPLACE COMPONENTS IF NECESSARY FREE OF CHARGE. THE RECALL BEGAN ON JUNE 13, 2008. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

Notes

VWOA RECALL NO. 26E5/R5.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

VW/FILLER NECK/TIRE ABRASION

NHTSA #02V026000 · Fuel System, Gasoline — Storage — Tank Assembly — Filler Pipe and Cap · NHTSA notice

Reported January 25, 2002 · VOLKSWAGEN OF AMERICA,INC

Potentially affected: 487,284 vehicles

Volkswagen campaign WK · Owners notified June 13, 2003 · Vehicles built April 1, 1997 – August 31, 2002 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

ON SOME PASSENGER VEHICLES, THE FUEL TANK FILLER NECK CAN SUFFER ABRASION DAMAGE IF THE REAR TIRE GOES FLAT AND THE VEHICLE IS DRIVEN UNTIL THE TIRE DISINTEGRATES.

Safety consequence

FUEL LEAKAGE CAN OCCUR INCREASING THE RISK OF A FIRE.

Manufacturer remedy

DEALERS WILL FIT PASSAT VEHICLES WITH A NEW WHEEL HOUSE LINER THAT WILL BETTER PROTECT THE CAR'S FILLER NECK. JETTA VEHICLES WILL BE FITTED WITH A DIFFERENT METAL SHIELD DESIGNED TO ENHANCE ABRASION PROTECTION IN THE EVENT OF TIRE DISINTEGRATION. OWNER NOTIFICATION BEGAN JUNE 13, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.

Notes

ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

VW/FUEL SENDING UNITS

NHTSA #01V157000 · Fuel System, Gasoline — Storage — Tank Assembly · NHTSA notice

Reported May 3, 2001 · VOLKSWAGEN OF AMERICA,INC

Potentially affected: 70,000 vehicles

Owners notified May 1, 2001 · Vehicles built September 1, 1999 – December 29, 2000 (per NHTSA)

Defect description

VEHICLE DESCRIPTION: PASSENGER VEHICLES. SULFUR IN FUEL INTERACTS WITH CERTAIN ADDITIVES FOUND IN WIDELY AVAILABLE GASOLINE CAUSING SULFUR TO BECOME DEPOSITED ON THE CONTACT POINTS OF THREE FUEL SENDING UNITS MOUNTED INSIDE THE FUEL TANK. THIS COULD CAUSE THE FUEL GAUGE TO READ FULL WHILE THE FUEL TANK MAY NOT IN FACT BE FULL OR COULD BE EMPTY.

Safety consequence

RUNNING OUT OF FUEL WITHOUT WARNING WHILE THE FUEL GAUGE INDICATES THAT THERE IS SUFFICIENT FUEL IN THE TANK LEAD TO SAFETY PROBLEMS.

Manufacturer remedy

DEALERS WILL REMOVE THE EXISTING FUEL LEVEL SENDING UNITS AND REPLACE THEM WITH FUEL LEVEL SENDING UNITS USING A NEW ALLOY COMPOSED OF GOLD, SILVER, AND A SMALL AMOUNT OF NICKEL, WHICH WILL NOT CHEMICALLY REACT WITH SULFUR. VW/AUDI WILL ALSO CALL BACK VEHICLES THAT WERE REPAIRED UNDER A PREVIOUS RECALL LAST JUNE IN ORDER TO INSTALL THE UPDATED FUEL SENDING UNITS NHTSA 00V137/AUDI LB). OWNER NOTIFICATION BEGAN MAY 1, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT AUDI AT 1-866-892-2834.

Notes

ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

2001 Volkswagen Passat 4-DR. w/SAB

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 5, Passenger: 5

Side Crash

Not Rated

Driver: Not Rated, Passenger: Not Rated

Side Pole

Not Rated

Rollover

Not Rated

Safety Technology

7 investigations

429 owner complaints have been filed with NHTSA for the 2001 Volkswagen Passat.

Service Brakes

ODI #11745122

Incident: June 18, 2026 · Filed: June 18, 2026

My fuses keep blowing, this is leading to replacing the Brake switch which I believe was recalled. If it was replaced,it's not working.

Air Bags

ODI #11422304

Incident: June 10, 2021 · Filed: June 25, 2021

The driver's side airbag of my 2001 VW Passat spontaneously deployed while I drove on Hwy 494 in Woodbury MN. Sometime within 24 hours before the airbag deployed, the airbag fault light turned on in the car's dashboard display. Within 15 minutes before the incident, the car's automatic locking locks unlocked twice while I was driving the car. After the second time, I tried to lock the car doors by pressing the lock button on the driver's door console but the doors would not locked. At that time I noticed that the two interior lights in the back seat area were turned on. All the doors of the car were properly shut. When the airbags deployed I was driving on the smooth 1 year old concrete section of Hwy 494. I did not hit anything on the highway. After the deployment, I parked on the shoulder, shut off the engine and opened the passenger door to air out the car. After about 5 minutes, I got back in the car and drove home. The automatic locks worked again. The interior lights automatically turned off. The drive home was uneventful.

Engine; Fuel/Propulsion System

ODI #11389398

Incident: December 28, 2020 · Filed: January 22, 2021

TOOK CAR TO VW DEALER TO HAVE TIMING BELT REPLACED AND WAS NOTIFIED THAT THERE WERE SEVERAL OPEN RECALLS AND THEY OFFERED TO TAKE CARE OF THEM FREE OF CHARGE. HOWEVER, THEY WERE UNABLE TO PERFORM RECALL #08V156. MANUFACTURER #26E5. THEY INSTALLED THE HEAT SHIELD BUT COULD NOT PERFORM SOFTWARE UPGRADE. I NEVER RECEIVED ANY RECALL NOTICES IN THE MAIL. NOW VW WANTS TO BUY THE CAR BACK BECAUSE THEY CAN'T FIX IT. IT'S A 2001 VW PASSAT WITH 25K MILES IN SHOWROOM SHAPE. WAS NEVER DRIVEN IN SNOW AND GARAGED IT'S ENTIRE LIFE. THEY OFFERED ME $1500 OUT OF WHICH I OWE $1300 FOR THE TIMING BELT. THEY SAID IT MAY NEED A ECU BUT THEY ARE NO LONGER AVAILABLE FROM VW BUT REFUSE TO INSTALL A USED ONE. THE CAR HAS BEEN AT THE VW DEALER SINCE 12/28/2020. I WAS UNDER THE IMPRESSION THAT RECALLS NEVER EXPIRE.

Vehicle Speed Control; Service Brakes

ODI #11120015

Incident: July 18, 2018 · Filed: August 15, 2018

ABS LIGHT ON AND BREAK LIGHT FLASHING

Fuel/Propulsion System

ODI #11054149

Incident: November 27, 2017 · Filed: December 12, 2017

STARTED SMELLING GAS AND MILEAGE STARTED DROPPI G BAD AROUND THE END OF NOVEMBER. WE SEE THAT THERE HAS BEEN RECALLS ON THE GAS TANK AND FUEL LINES FOR 01 VOLKSWAGEN PASSATS BUT UNFORTUNATELY NOT FOR THIS VIN # WHICH HAPPENS TO BE MY SONS CAR. NOW ITS AT THE SHOP BECAUSE ITS GAS MILEAGE WENT WAY DOWN AND AND SMELLS LIKE GAS AND HE WAS TOLD THAT HE WAS DRIVING A BOMB BASICALLY. IT COULD BE AROUND $1000 TO FIX IT. NONE OF US HAVE THAT KIND OF $ AND HES STILL HAS $800 LEFT OWEING ON IT. HELP

Engine

ODI #11046400

Incident: November 10, 2017 · Filed: November 15, 2017

FAULTY CAM CHAIN TENSIONER FAILED AND CAUSED SEVERE ENGINE DAMAGE TO VALVES, PISTONS, CAMSHAFT, CAM TIMING CHAIN. I WAS STATIONARY WAITING AT A RED LIGHT WHEN I HEARD A SUDDEN LOUD GRINDING NOISE FROM INSIDE THE ENGINE COMPARTMENT, THE ENGINE BEGAN TO SHAKE AND SPUTTER. THE CAR LOST MOST OF ITS POWER AND I WAS BARELY ABLE TO MAKE IT THROUGH THE INTERSECTION WHEN THE LIGHT TURNED GREEN. UPON INSPECTION IT WAS CLEAR TO SEE THAT THE CAM CHAIN TENSIONER HAD SELF DESTRUCTED AND CAUSED THE ENGINE TO FAIL.

Fuel/Propulsion System

ODI #11012185

Incident: August 1, 2017 · Filed: August 1, 2017

MY 2001 VOLKSWAGEN PASSAT HAS HAD AN R5 RECALL FOR FUEL LINES, FUEL TANK, AND A HEAT SHIELD. THE HARD (LOW PRESSURE FUEL RETURN?) LINE, THE MIDDLE ONE OF THE MOUNTING BRACKET ATOP THE FIREWALL, HAS FAILED CATASTROPHICALLY. IT NOW SPRAYS GASOLINE DIRECTLY DOWN ONTO THE CATALYTIC CONVERTER HEAT SHIELD. THIS IS THE SAME FAILURE IN THE SAME EXACT POINT THAT MANY OTHER OWNERS HAVE HAD. THIS PART IS DANGEROUS AND COULD HAVE KILLED ME AND DESTROYED MY CAR. VOLKSWAGEN REFUSED TO FIX IT. I'VE BEEN IN CONTACT WITH VW CUSTOMER CARE AND MY LOCAL DEALER, BOTH TOLD ME THAT ONCE THE RECALL IS CLOSED ON MY VEHICLE THAT THERE IS NOTHING THEY'LL DO. THEY WANTED ME TO TOW MY CAR TO THE DEALERSHIP AND PAY $135 FOR A DIAGNOSTIC UNTIL I SHOWED THEM A VIDEO OF THE FUEL LINE UNDER PRESSURE SPRAYING EVERYWHERE.

Air Bags

ODI #10955699

Incident: February 20, 2017 · Filed: February 20, 2017

MY CAR IS A 2001 MODEL, AND I'D LIKE TO KNOW IF IT HAS TAKATA AIRBAGS IN IT, EVEN IF IT ISN'T COVERED BY THE RECALL. DEALER DOESN'T KNOW IF THE AIRBAGS ARE TAKATA OR NOT. CAN YOU GIVE ME THIS INFORMATION?? I HOPE SO, OTHERWISE I DON'T KNOW HOW TO FIND OUT. THANKS [XXX] *DL INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).*JB

Service Brakes

ODI #10908805

Incident: September 22, 2016 · Filed: September 22, 2016

ABS CONTROL MODULE FAULT

Power Train

ODI #10865850

Incident: May 19, 2016 · Filed: May 19, 2016

AS MY SON GOT ON THE HIGHWAY THE TRANSMISSION FELT LIKE IT WAS SLIPPING AND JERKING TO THEN CATCH BACK UP TO THE ORIGINAL SPEED I WAS GOING. WHEN HE PUT HIS FOOT ON THE GAS PEDAL THE CAR WOULD STRUGGLE TO GO, 5 SECONDS LATER IT WOULD GET UP TO SPEED BUT THEN SLOW BACK DOWN. AT A STOPLIGHT THE CAR WOULD SHAKE ROUGHLY AND IDLE REALLY HIGH, THEN HE SAW THE FRONT OF THE HOOD START TO SMOKE AND I REALIZED THERE WAS A PROBLEM.

Other Volkswagen Passat model years

Check your 2001 Volkswagen Passat VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Volkswagen Passat at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Volkswagen VIN