2016 Toyota Tundra Recalls, Ratings & Complaints

Incident: November 5, 2025 · Filed: September 25, 2026

The contact owns a 2016 Toyota Tundra. The contact stated that upon starting the vehicle, the vehicle hesitated and shuddered. While driving approximately 65-70 MPH and depressing the accelerator pedal, the vehicle stalled. There was an unknown warning light was displayed after the failure. There was an abnormal fuel odor before and after the failure. The vehicle stalled and failed to restart and was towed. A service repair had been scheduled. Upon research the contact associated the failure with TSB: 0166-19. The failure mileage was approximately 77,000.

Incident: July 2, 2026 · Filed: July 23, 2026

2016 flex fuel toyota tundra with 118,00 miles was towed to toyota dealer in Las cruces with a no fuel issue. After the analysis it was determined the fuel pump over heated burning out conector and wiring ,but the pump was still working. According to toyota TSB 0166-19 this is a problem the can arise if the alcohol fuel density ID is not updated. I told the dealer to due repairs on vehicle even though a fuel pump was installed and reflashed at 114,000 miles. Viva toyota of las cruses advicate stated that a reflash is all the vehiles needs and does not desire to change the alchol fuel density to updated ID as per TSB-0166-19, so I am worried I will be operating a vehicle with a fuel pump that will over heat and burn out connectors again. I called Toyota complaints and they told me they cannot make a dealer do any repairs.

Incident: June 5, 2026 · Filed: June 14, 2026

Bed is rusting out from the bottom in a fashion that looks very similar to a previous Tundra bed rusting issue that had a TSB and remedy from Toyota. On the driver's side bed bolt closest to the cab, the sheet metal tack welded to the bed has separated and is rusting out. Approximately 7 inches to the drivers side from that bolt. The seam sealer is also cracking. Additionally, the drivers side bed bolt closes to the tailgate has rust bubbling up from underneath approximately 1 inch to the passenger side from the bolt and also along where that sheet metal is tack welded onto the bed.

Incident: May 21, 2026 · Filed: May 22, 2026

The fuel pump component or system failed or malfunctioned the engine tried cranking but would not start. The problem has been reproduced to an independent service center, where I was notified of a safety recall on Toyota Tundra. No other inspections have been performed. There are no warning lamps messages visible on the vehicle in question. The vehicle will not start until repeated starts are performed. Vehicle idles roughly before regaining normal idle. One other past similar incident of this type has occurred. No other

Incident: April 8, 2026 · Filed: April 21, 2026

The contact owns a 2016 Toyota Tundra. The contact stated that while driving at slower speeds, the vehicle stalled while depressing the accelerator pedal. The check engine warning light was illuminated. The vehicle was towed to a local dealer to be diagnosed. The contact was informed that the fuel pump and other fuel pump-related parts needed to be replaced. The vehicle was not repaired because the parts were on back order. The manufacturer was made aware of the failure. The failure mileage was approximately 67,000.

Incident: January 24, 2026 · Filed: February 19, 2026

The steering rack internal seal inside the steering rack failed/ "blew" per mechanic and is leaking. I could lose my ability to steer at any time while driving my vehicle and wreck. It is currently at the Toyota services center in Gladstone, OR and has been diagnosed. No other representatives have inspected the vehicle. There were no warnings or signs of failure. I had originally taken my truck in to have an oil change and have it checked for a "slow" start up.

Incident: December 4, 2025 · Filed: December 16, 2025

The power steering went out during routine around-town driving. One moment it was steering fine, the next moment it became extremely difficult and sluggish. There were no warning lights or warning of any sort until the steering wheel started jerking unevenly as I tried to turn. I was able to get control of the vehicle and pull it to the side of the road. There was no difference in the engine noise, and I couldn't see any noticeable fluid leak. I was able to drive the vehicle home, make an appointment with the Toyota dealer, and get the vehicle to the dealership for inspection. The dealership told me after inspection, that the rack and pinion steering was binding internally, and that there was seepage from the right boot. Initially, they told me that the pump should be fine. I authorized them to replace the rack and pinion steering. After which, they told me that the problem seemed to still persist some, and that the pump would have to be replaced also. My total bill came to $3,200, which seemed not unfair. But this whole issue seemed like something that should be noticed as part of a recall. I found the NHTSA recall number. 21V-920, and my truck seemed to match exactly the symptoms spelled out is this recall , but Toyota refused to acknowledge it. My VIN number did not fall within the specified VIN for this recall. I've driven several Toyotas, including another Tundra, a Tacoma, 2 Highlanders and a Sienna, and have been pleased with each vehicle. This Tundra is 10 years old with 95,000 miles, and I've only done expected maintenance and a couple of occasional minor repairs. Those being: - Having the brakes resurfaced - Changing out the alternator In the end, it wasn't a devastating amount of money, but it was an issue that I felt Toyota should have taken care of. I did reach out to them, but because I had already paid for the repairs on the vehicle I needed to drive for work, they refused to talk to me any further. I have the estimate and final bill.

Incident: May 24, 2025 · Filed: May 24, 2025

My right front headlamp is getting moisture inside the headlamp assembly. It can be inspected any time. Chance that headlamp will not work. Did not take to a dealer.

Incident: May 6, 2025 · Filed: May 7, 2025

Odometer Fraud. The contact purchased a 2016 Toyota Tundra. The contact stated while going through prior service paperwork found in the vehicle, he discovered that there was a mileage discrepancy. The vehicle was a private sale. The contact also stated that the vehicle was once sold at a private auction. At the time of purchase, the vehicle mileage was 158,000; however, upon discovery of the service paperwork, the contact discovered that the vehicle mileage was once 250,000.

Incident: March 18, 2025 · Filed: March 20, 2025

I have had multiple incidents where the front hood bulge has blown off going down the interstate and nearly hit other cars. It’s not been worth buying a new one with the risk of them flying off. It’s definitely a saftey concern and a hazard.