NHTSA vehicle safety data

2007 Toyota Tundra Recalls, Ratings & Complaints

The 2007 Toyota Tundra has 14 NHTSA recall campaigns and 390 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Toyota dealer.

NHTSA recall and complaint data for the 2007 Toyota Tundra, plus NCAP crash-test ratings. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2007 Toyota Tundra owner complaints

Owners have filed 390 complaints with NHTSA about the 2007 Toyota Tundra, describing incidents dated January 1, 2007 to September 8, 2026.

Most-cited components

Power Train 73 complaints
Vehicle Speed Control 65 complaints
Structure 61 complaints
Engine 58 complaints
Suspension 57 complaints
Fuel/Propulsion System 32 complaints

Of the 390 complaints on file, 26 report a crash and 5 a fire; across all 390 complaints, owners report 22 injuries and 3 deaths (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11764907 · Filed September 17, 2026
As a result of a class action lawsuit Toyota settled on frame replacement or spraying a rust inhibitor depending on the severity of frame rust. The sprayed on rust inhibitor, used in my case, was sprayed over mud and pack rust at the dealership - Williams Toyota, Big Flats NY. I took the truck to a…
ODI #11709874 · Filed January 9, 2026
All Driveshaft Support Bearings failed and needed replaced.
ODI #11709873 · Filed January 9, 2026
Intermittent Transmission issue. Truck will not shift into 5th or 6th gear. Temporary fix is turning the car off and on again. Problem will eventually return. Is this a Software or Hardware issue? Is there a campaign or recall on this issue?

Read all 390 complaints

Owner-reported

2007 Toyota Tundra mileage at failure

312 of the 390 complaints on file for the 2007 Toyota Tundra give the vehicle's mileage when the problem happened.

Mileage at failure by component, from owners' complaints to NHTSA
Component	Median	Middle half	Based on
Power Train	Median 60,000 miles	Middle half 20,000–90,000 miles	Based on 58 complaints
Vehicle Speed Control	Median 35,000 miles	Middle half 13,000–65,000 miles	Based on 55 complaints
Structure	Median 105,000 miles	Middle half 50,000–135,000 miles	Based on 39 complaints
Engine	Median 70,000 miles	Middle half 50,000–90,000 miles	Based on 54 complaints
Suspension	Median 2,000 miles	Middle half 100–40,000 miles	Based on 46 complaints

A component's median is its 50th percentile, and its middle half runs from its 25th to its 75th percentile.

Owners give the mileage themselves, often as a round number, and NHTSA doesn't check it. A complaint that names several components counts under each one, and mileages that can't be right, such as 999,999, or 50 miles on a five-year-old car, are left out.

These figures describe the complaints owners filed. They don't predict when a particular vehicle will have a problem, and vehicles that never had one aren't counted.

Most complaints NHTSA received since May 17, 2021 give no mileage. So that they aren't undercounted, each one received since then that gives a mileage also stands in for those that gave none, which can put a component's median above most of the mileages it is based on.

Mileage from NHTSA's complaints file of October 31, 2026. How these figures are worked out

Power Steering Gear Assembly May Leak Oil

NHTSA #21E103000 · Steering — Hydraulic Power Assist System · NHTSA notice

Reported December 23, 2021 · Toyota Motor Engineering & Manufacturing

Potentially affected: 151 vehicles

Repair completion: 86.09% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Toyota campaign 21TH01 · Owners notified February 17, 2022

Defect description

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain JTEKT power steering gear assembly service parts for 2007-2021 Tundra and 2008-2022 Sequoia, part numbers 44250-0C160, 44250-0C131, 44250-0C170, and 11250-0C121. The power steering gear assembly may have been manufactured incorrectly, which can result in an oil leak.

Safety consequence

An oil leak may cause a sudden loss of power steering assist, increasing the risk of a crash.

Manufacturer remedy

Dealers will inspect and replace the power steering gear assembly, free of charge. Owner notification letters were mailed on February 17, 2022. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is 21TH01.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

Oil Leak May Cause a Loss of Power Steering Assist

NHTSA #21V920000 · Steering — Hydraulic Power Assist System · NHTSA notice

Reported November 23, 2021 · Toyota Motor Engineering & Manufacturing

Potentially affected: 22,462 vehicles

Repair completion: 95.1% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Toyota campaign 21TB10 / 21TA10 · Owners notified January 21, 2022

Defect description

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2008-2022 Sequoia and 2007-2021 Tundra vehicles. The power steering gear assembly may have been manufactured incorrectly, which can result in an oil leak.

Safety consequence

An oil leak may cause a sudden loss of power steering assist, increasing the risk of a crash.

Manufacturer remedy

Dealers will inspect and replace the power steering gear assembly as necessary, free of charge. Owner notification letters were mailed on January 21, 2022. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are 21TB10 and 21TA10.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

Seat Heater Electrical Wiring

NHTSA #16V396000 · Seats — Front Assembly — Seat Heater/Cooler · NHTSA notice

Reported June 2, 2016 · Southeast Toyota Distributors, LLC

Potentially affected: 7,749 vehicles

Repair completion: 23.63% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign SET16B · Owners notified July 14, 2016 · Vehicles built December 5, 1987 – January 27, 2012 (per NHTSA)

Defect description

Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.

Safety consequence

If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.

Manufacturer remedy

SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Seat Heater Electrical Wiring

NHTSA #14V743000 · Seats — Front Assembly — Seat Heater/Cooler · NHTSA notice

Reported November 19, 2014 · Southeast Toyota Distributors, LLC

Potentially affected: 3,233 vehicles

Repair completion: 26.94% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Owners notified January 29, 2015 · Vehicles built June 1, 2005 – September 30, 2011 (per NHTSA)

Defect description

Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.

Safety consequence

Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.

Manufacturer remedy

SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Power Window Master Switch may Melt

NHTSA #12V491000 · Visibility — Power Window Devices and Controls · NHTSA notice

Reported October 10, 2012 · Toyota Motor Engineering & Manufacturing

Potentially affected: 2,519,424 vehicles

Repair completion: 66.99% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Owners notified November 5, 2012 · Vehicles built October 26, 2006 – December 22, 2008 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

Toyota is recalling certain model year 2007-2009 Camry, Camry Hybrid, RAV4, Corolla, Corolla Matrix, Tundra, Sequoia, Highlander, Highlander Hybrid, Yaris, Scion xB, Scion xD and Pontiac Vibe vehicles. The power window master switch assemblies in some of these vehicles were built using a less precise process for lubricating the internal components of the switch assemblies. Irregularities in this lubrication process may cause the power window master switch assemblies to malfunction and overheat.

Safety consequence

If the switch overheats, it may melt, possibly resulting in a fire.

Manufacturer remedy

Toyota will notify its owners, and dealers will inspect the switch and apply a special grease that inhibits heat build up or replace any switch damaged by the defect, free of charge. Toyota owners that experience a problem with a switch should not attempt to make repairs, but should contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331. General Motors will contact the Pontiac Vibe owners affected by this recall and GM dealers will inspect and repair switches as necessary. Those owners may contact Pontiac Customer Care at 1-800-762-2737.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

TIRE PRESSURE MONITORING SYSTEMS/FMVSS 138

NHTSA #11V278000 · Tires — Pressure Monitoring and Regulating Systems · NHTSA notice

Reported May 12, 2011 · SOUTHEAST TOYOTA DISTRIBUTORS, LLC

Potentially affected: 1,629 vehicles

Owners notified July 11, 2011

Defect description

SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2007-2011 TUNDRA VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 138, "TIRE PRESSURE MONITORING SYSTEMS." THE TPMS ON SOME VEHICLES MAY NOT HAVE BEEN PROPERLY CALIBRATED AND AS A RESULT THE LOW TIRE PRESSURE WARNING LAMP MAY NOT ILLUMINATE SHOULD THE INFLATION PRESSURE IN ONE OR MORE OF THE VEHICLE'S TIRES FALL BELOW THE THRESHOLD FOR WHEN THE LOW TIRE PRESSURE WARNING LAMP SHOULD ILLUMINATE.

Safety consequence

DRIVERS WILL NOT RECEIVE A WARNING FROM THE TIRE PRESSURE MONITOR THAT ONE OR MORE TIRES ARE UNDERINFLATED, INCREASING THE RISK THAT THE VEHICLE WILL BE DRIVEN WITH ONE OR MORE UNDERINFLATED TIRES, INCREASING THE RISK OF A TIRE FAILURE THAT MAY LEAD TO A CRASH.

Manufacturer remedy

DEALERS WILL RECALIBRATE THE TIRE PRESSURE MONITORING SYSTEM IN ACCORDANCE WITH THE REGULATION FREE OF CHARGE. THE SAFETY RECALL BEGAN DURING JULY 2011. OWNERS MAY CONTACT SOUTHEAST TOYOTA CUSTOMER ASSISTANCE CENTER TOLL FREE AT 1-800-301-6859, MONDAY THROUGH FRIDAY, 8:30 AM TO 5:00 PM, EASTERN STANDARD TIME.

Notes

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

LOAD CARRYING CAPACITY MODIFICATION LABELS

NHTSA #10V035000 · Equipment — Other — Labels · NHTSA notice

Reported February 3, 2010 · GULF STATES TOYOTA, INC.

Potentially affected: 271,417 vehicles

Owners notified May 27, 2010

Defect description

GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Safety consequence

THIS DOES NOT MEET THE STANDARD REQUIREMENTS.

Manufacturer remedy

DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.

Notes

LOAD CARRYING CAPACITY MODIFICATION LABELS

NHTSA #10V036000 · Equipment — Other — Labels · NHTSA notice

Reported February 3, 2010 · SOUTHEAST TOYOTA DISTRIBUTORS, LLC

Potentially affected: 153,418 vehicles

Owners notified May 27, 2010

Defect description

SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Safety consequence

A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.

Notes

STICKING ACCELERATOR PEDAL

NHTSA #10V017000 · Vehicle Speed Control — Accelerator Pedal · NHTSA notice

Reported January 21, 2010 · TOYOTA MOTOR NORTH AMERICA, INC.

Potentially affected: 2,230,661 vehicles

Toyota campaign AOA · Owners notified February 5, 2010 · Vehicles built January 4, 2007 – January 21, 2010 (per NHTSA)

Defect description

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 AVALON, MODEL YEAR 2007-2010 CAMRY, MODEL YEAR 2009-2010 COROLLA, COROLLA MATRIX, RAV4, MODEL YEAR 2010 HIGHLANDER, MODEL YEAR 2008-2010 SEQUOIA, AND MODEL YEAR 2007-2010 TUNDRA VEHICLES. DUE TO THE MANNER IN WHICH THE FRICTION LEVER INTERACTS WITH THE SLIDING SURFACE OF THE ACCELERATOR PEDAL INSIDE THE PEDAL SENSOR ASSEMBLY, THE SLIDING SURFACE OF THE LEVER MAY BECOME SMOOTH DURING VEHICLE OPERATION. IN THIS CONDITION, IF CONDENSATION OCCURS ON THE SURFACE, AS MAY OCCUR FROM HEATER OPERATION (WITHOUT A/C) WHEN THE PEDAL ASSEMBLY IS COLD, THE FRICTION WHEN THE ACCELERATOR PEDAL IS OPERATED MAY INCREASE, WHICH MAY RESULT IN THE ACCELERATOR PEDAL BECOMING HARDER TO DEPRESS, SLOWER TO RETURN, OR, IN THE WORST CASE, MECHANICALLY STUCK IN A PARTIALLY DEPRESSED POSITION.

Safety consequence

THE ACCELERATOR PEDAL MAY BECOME HARD TO DEPRESS, SLOW TO RETURN TO IDLE, OR, IN THE WORST CASE, MECHANICALLY STUCK IN A PARTIALLY DEPRESSED POSITION, INCREASING THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL INSTALL A REINFORCEMENT BAR IN THE ACCELERATOR PEDAL WHICH WILL ALLOW THE PEDAL TO OPERATE SMOOTHLY. GM WILL NOTIFY OWNERS FOR THE PONTIAC VIBE PLEASE SEE 10V-018. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON FEBRUARY 5, 2010 AND WILL BE COMPLETED ON MARCH 15, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

Notes

TOYOTA SAFETY RECALL NO. AOA. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

PEDAL ENTRAPMENT

NHTSA #09V388000 · Vehicle Speed Control — Accelerator Pedal · NHTSA notice

Reported October 5, 2009 · TOYOTA MOTOR NORTH AMERICA, INC.

Potentially affected: 4,445,056 vehicles

Toyota campaign 90L(TOYOTA)/90LG(LEX · Owners notified December 31, 2009

Defect description

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.

Safety consequence

A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.

Manufacturer remedy

TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.

Notes

TOYOTA RECALL NO. 90L/90LG.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

INCORRECT GVWR LABELS

NHTSA #09V223000 · Equipment — Other — Labels · NHTSA notice

Reported June 15, 2009 · TOYOTA MOTOR NORTH AMERICA, INC.

Potentially affected: 27,080 vehicles

Owners notified September 18, 2009 · Vehicles built September 1, 2005 – May 4, 2009 (per NHTSA)

Defect description

TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."

Safety consequence

INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.

Manufacturer remedy

TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.

Notes

AFTERMARKET ALLOY WHEEL LUG NUTS

NHTSA #08E029000 · Wheels — Lugs/Nuts/Bolts/Studs · NHTSA notice

Reported March 31, 2008 · SOUTHEAST TOYOTA DISTRIBUTORS

Potentially affected: 216 vehicles

Owners notified April 21, 2008

Defect description

SOUTHEAST TOYOTA IS RECALLING ALLOY WHEEL LUG NUTS USED FOR THE 18" DIAMOND FINISH 5-SPOKE ALLOY WHEELS AND 20" PAINTED ALLOY WHEELS WITH 6-DUAL SPOKES SOLD AS AN UPGRADE PACKAGE FOR 2007 TOYOTA TUNDRA MODEL VEHICLES. THE WHEEL NUTS CAN CRACK AND BREAK IF THE WHEELS ARE NOT INSTALLED CAREFULLY OR NOT CAREFULLY TIGHTENED. THIS WHEEL NUT CONDITION COULD OCCUR AT THE TIME OF WHEEL INSTALLATION, TIRE ROTATION, OR SERVICE.

Safety consequence

CRACKED OR BROKEN WHEEL NUTS COULD RESULT IN A VEHICLE CRASH.

Manufacturer remedy

SOUTHEAST TOYOTA WILL NOTIFY OWNERS AND REPLACE THE WHEEL NUTS WITH A MORE ROBUST WHEEL NUT FREE OF CHARGE. THE RECALL BEGAN ON APRIL 21, 2008. OWNERS MAY CONTACT SOUTHEAST TOYOTA CUSTOMER LOYALTY DEPARTMENT TOLL-FREE AT 800-301-6859.

Notes

CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

WHEEL NUTS

NHTSA #08V080000 · Wheels — Lugs/Nuts/Bolts/Studs · NHTSA notice

Reported February 25, 2008 · SOUTHEAST TOYOTA DISTRIBUTORS

Potentially affected: 1,716 vehicles

Owners notified April 18, 2008

Defect description

SOUTHEAST TOYOTA IS RECALLING 1,555 MY 2007 TUNDRA VEHICLES DUE TO A WHEEL NUT ISSUE. THE RECALLED VEHICLES ARE MY 2007 TUNDRAS EQUIPPED WITH 18" INSTALLED DIAMOND FINISH 5-SPOKE ALLOY WHEELS (OPTION CODE WN1 OR WN4) OR 20" INSTALLED PAINTED ALLOY WHEELS WITH 6 DUAL SPOKES (OPTION CODE WV1 OR WV4). AFFECTED VEHICLES WERE ORIGINALLY SOLD IN FLORIDA, GEORGIA, ALABAMA, NORTH CAROLINA OR SOUTH CAROLINA. WHEN THE VEHICLE WAS PROCESSED AT THE PORT, THE UPGRADED ALLOY WHEELS WERE FASTENED WITH NEW WHEEL NUTS. THE WHEEL NUTS CAN CRACK AND BREAK IF THEY ARE NOT INSTALLED CAREFULLY OR NOT CAREFULLY TIGHTENED. THIS WHEEL NUT CONDITION COULD OCCUR AT THE TIME OF WHEEL INSTALLATION, TIRE ROTATION, OR SERVICE.

Safety consequence

IF A VEHICLE'S WHEEL HAS A CRACKED OR BROKEN WHEEL NUT CONDITION AND THE WHEEL BECOMES LOOSE AND FALLS OFF THE VEHICLE WITHOUT WARNING, A CRASH COULD OCCUR.

Manufacturer remedy

DEALERS WILL REPLACE THE ATTACHING WHEEL NUTS. THE RECALL BEGAN ON APRIL 18, 2008. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.

Notes

CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

PROPELLER SHAFT

NHTSA #07V579000 · Power Train — Driveline — Driveshaft · NHTSA notice

Reported December 18, 2007 · TOYOTA MOTOR NORTH AMERICA, INC.

Potentially affected: 15,616 vehicles

Toyota campaign 70G · Owners notified January 7, 2008 · Vehicles built November 9, 2006 – August 3, 2007 (per NHTSA)

Defect description

ON CERTAIN 4-WHEEL DRIVE PICKUP TRUCKS, DUE TO THE IMPROPER HEAT TREATMENT OF THE SLIP YOKES THAT HAD BEEN REWORKED DURING THE MANUFACTURING PROCESS, THE HARDNESS OF THE SLIP YOKE MAY BE INSUFFICIENT.

Safety consequence

IN THIS CONDITION, THERE IS A POSSIBILITY THAT THE YOKE MAY BREAK CAUSING THE PROPELLER SHAFT TO SEPARATE AT THE JOINT AND COME INTO CONTACT WITH THE ROAD SURFACE OR THE FUEL TANK WHICH COULD RESULT IN A LOSS OF VEHICLE CONTROL OR A FUEL LEAK.

Manufacturer remedy

DEALERS WILL INSPECT THE SLIP YOKE AND REPLACE THE PROPELLER SHAFT IF NECESSARY FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 7, 2008. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

Notes

TOYOTA RECALL NO. 70G.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

2007 Toyota Tundra Regular Cab w/SAB

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 4, Passenger: 4

Side Crash

Not Rated

Driver: Not Rated, Passenger: Not Rated

Side Pole

Not Rated

Rollover

20% rollover risk

Safety Technology

Electronic Stability Control

2007 Toyota Tundra 4-DR. w/SAB

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 4, Passenger: 4

Side Crash

Not Rated

Driver: Not Rated, Passenger: Not Rated

Side Pole

Not Rated

Rollover

20% rollover risk

Safety Technology

Electronic Stability Control

2007 Toyota Tundra Extended Cab w/SAB

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 4, Passenger: 4

Side Crash

Not Rated

Driver: Not Rated, Passenger: Not Rated

Side Pole

Not Rated

Rollover

20% rollover risk

Safety Technology

Electronic Stability Control

390 owner complaints have been filed with NHTSA for the 2007 Toyota Tundra.

Unknown or Other

ODI #11764907

Incident: September 8, 2026 · Filed: September 17, 2026

As a result of a class action lawsuit Toyota settled on frame replacement or spraying a rust inhibitor depending on the severity of frame rust. The sprayed on rust inhibitor, used in my case, was sprayed over mud and pack rust at the dealership - Williams Toyota, Big Flats NY. I took the truck to a local shop to have the brakes replaced and nys inspection completed. The repair shop called and said that the truck was not road worthy due to frame rust.

Power Train

ODI #11709874

Incident: January 1, 2026 · Filed: January 9, 2026

All Driveshaft Support Bearings failed and needed replaced.

Power Train

ODI #11709873

Incident: December 1, 2025 · Filed: January 9, 2026

Intermittent Transmission issue. Truck will not shift into 5th or 6th gear. Temporary fix is turning the car off and on again. Problem will eventually return. Is this a Software or Hardware issue? Is there a campaign or recall on this issue?

Electrical System

ODI #11691837

Incident: October 6, 2025 · Filed: October 7, 2025

Odometer Fraud. The contact purchased a 2007 Toyota Tundra. The contact discovered a mileage discrepancy after the purchase. The vehicle was a private sale. At the time of purchase, the mileage was approximately 145,000. The contact attempted to resell the vehicle; and it was discovered through a Carfax Report that the mileage on the Title was approximately 330,000 in 2018.

Wheels

ODI #11688148

Incident: August 21, 2025 · Filed: September 18, 2025

Gulf States Toyota issued a recall (GST002) for the Enkei 18” wheels installed on my 2007 tundra. Toyota Vandergriff in Arlington has attempted to contact Gulf States Toyota multiple times since 8/21/25 but no reply has been provided. Currently, the wheels need to be replaced under the recall but Gulf States Toyota has made no effort to rectify the situation.

Structure

ODI #11665893

Incident: June 9, 2025 · Filed: June 9, 2025

The contact owns a 2007 Toyota Tundra. The contact stated while parking the vehicle, there was a loud sound coming from the vehicle. The contact inspected the vehicle and determined that the fuel tank scrap and bolt had fractured and detached. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. In addition, the contact stated that when the vehicle was purchased in May 2024, the contact later noticed flaking material on the ground underneath the vehicle. The vehicle was then taken to the dealer, but no assistance was provided. The manufacturer was made aware of the failure and a case was filed. In addition, the contact confirmed that in March 2019, the vehicle was serviced under an unknown corrosion prevention recall repair. The contact confirmed that at the time, the dealer performed the recall repair by spraying anti-corrosion prevention on the suspension. The unknown recall repair was warranted for 60 months. The failure mileage was approximately 279,000.

Fuel System, Gasoline

ODI #11651323

Incident: December 15, 2024 · Filed: March 28, 2025

The contact owns a 2007 Toyota Tundra. The contact stated while driving at 45 MPH, the accelerator pedal was depressed, and the vehicle failed to respond. The check engine warning light was illuminated. On a separate occasion, the contact stated that while driving uphill or driving forward, the vehicle lost motive power while depressing the accelerator pedal. The vehicle was taken to an independent mechanic; however, the vehicle was not diagnosed. The vehicle was then taken to a dealer, where it was diagnosed with air injection pumps and air injection switching valves failure. The vehicle was not repaired. The manufacturer was made aware of the failure and offered the contact an Extended Warranty. The contact was informed that the dealer would reach out to her; however, when the dealer contacted the contact, the contact was informed that the vehicle was not covered under an Extended Warranty. The failure mileage was approximately 74,268.

Structure

ODI #11649498

Incident: September 12, 2024 · Filed: March 20, 2025

The contact owns a 2007 Toyota Tundra. The contact stated that occasionally while driving at various speeds on bumpy road surfaces, the fuel tank was scraping against the pavement. The contact stated that upon inspection from the outside, the contact became aware that the fuel tank was hanging abnormally low and the bracket holding up the brake lines and fuel lines were completely rusted. There were no warning lights illuminated. The vehicle was taken to an independent mechanic to be diagnosed, and the contact was informed that due to the abnormal amount of rust on the sub frame, the vehicle was not safe to be driven. The contact was informed that the entire sub frame needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 142,255.

Power Train; Vehicle Speed Control; Engine

ODI #11626668

Incident: August 14, 2024 · Filed: November 21, 2024

Check engine light came on suddenly and acceleration slowed… truck will no longer go over 30 mph. Replaced radiator, driver air injection module, and regularly changed oil. no check engine light now the injection module was replaced but truck still will not go over 30 mph or 1800-2000 rpm’s.

Structure

ODI #11619528

Incident: January 1, 2007 · Filed: October 13, 2024

Undercoating of vehicle was not properly installed causing the frame to rust out creating a serious safety concern as the fuel tank can fall from the vehicle due to extensive rust. Toyota is aware of this situation however refuses to repair the problem.

Other Toyota Tundra model years

Check your 2007 Toyota Tundra VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Toyota Tundra at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Toyota VIN