NHTSA vehicle safety data

2005 Toyota Sienna Recalls, Ratings & Complaints

The 2005 Toyota Sienna has 12 NHTSA recall campaigns and 1,130 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Toyota dealer.

NHTSA recall and complaint data for the 2005 Toyota Sienna, plus NCAP crash-test ratings. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2005 Toyota Sienna owner complaints

Owners have filed 1,130 complaints with NHTSA about the 2005 Toyota Sienna, describing incidents dated October 16, 2004 to February 5, 2024.

Most-cited components

Structure 499 complaints
Latches/Locks/Linkages 135 complaints
Seat Belts 83 complaints
Steering 79 complaints
Service Brakes 68 complaints
Tires 68 complaints

Of the 1,130 complaints on file, 39 report a crash and 8 a fire; across all 1,130 complaints, owners report 71 injuries and 1 death (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11591696 · Filed May 31, 2024
The dashboard has so many cracks literally everywhere. All the way from the driver side to the passenger side. When the temperature changes hot to cold or cold to hot. There’s nothing but cracking sounds.
ODI #11571869 · Filed February 14, 2024
The contact owns a 2005 Toyota Sienna. The contact stated while driving 65 MPH, the oil warning light illuminated. The contact pulled over, opened the hood, and added additional oil. The vehicle was towed to an independent mechanic, who informed him that the engine needed to be replaced. The vehicle…
ODI #11556754 · Filed November 25, 2023
The rear hatch on our 2005 Toyota Sienna, after being opened, comes down almost immediately and can hit a person who is reaching into the back cargo area and cause injury. Other people have also reported this same dangerous malfunction online as far back as 2007.

Read all 1,130 complaints

Owner-reported

2005 Toyota Sienna mileage at failure

915 of the 1,130 complaints on file for the 2005 Toyota Sienna give the vehicle's mileage when the problem happened.

Mileage at failure by component, from owners' complaints to NHTSA
Component	Median	Middle half	Based on
Structure	Median 65,000 miles	Middle half 45,000–95,000 miles	Based on 428 complaints
Latches/Locks/Linkages	Median 60,000 miles	Middle half 45,000–85,000 miles	Based on 110 complaints
Seat Belts	Median 65,000 miles	Middle half 35,000–90,000 miles	Based on 67 complaints
Steering	Median 90,000 miles	Middle half 65,000–115,000 miles	Based on 66 complaints
Service Brakes	Median 90,000 miles	Middle half 35,000–125,000 miles	Based on 56 complaints
Tires	Median 18,000 miles	Middle half 10,000–40,000 miles	Based on 38 complaints

A component's median is its 50th percentile, and its middle half runs from its 25th to its 75th percentile.

Owners give the mileage themselves, often as a round number, and NHTSA doesn't check it. A complaint that names several components counts under each one, and mileages that can't be right, such as 999,999, or 50 miles on a five-year-old car, are left out.

These figures describe the complaints owners filed. They don't predict when a particular vehicle will have a problem, and vehicles that never had one aren't counted.

Mileage from NHTSA's complaints file of October 31, 2026. How these figures are worked out

NHTSA defect investigations

NHTSA's investigations file lists the 2005 Toyota Sienna in 6 investigations. Audit Queries and Equipment Queries are administrative investigations: they look at whether companies complied with federal vehicle safety requirements, such as reporting, recall and certification rules, not at a possible vehicle defect. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Equipment Query EQ12-010: Stabilus Rear Liftgate Struts Failing
Closed December 31, 2012
Engineering Analysis EA08-024: STEERING INTERMEDIATE SHAFT BINDING
Closed July 16, 2009
Engineering Analysis EA06-020: UNEXPECTED CLOSING OF POWER LIFTGATE
Closed June 25, 2008
- Recall 08V-244
Preliminary Evaluation PE06-029: UNEXPECTED LIFTGATE CLOSING
Closed December 1, 2006
Preliminary Evaluation PE06-010: TIRE PRESSURE WARNING SYSTEM FAILURE
Closed August 2, 2006

1 more NHTSA investigation

Engineering Analysis EA05-010: SEATBELT MALFUNCTION
Closed August 2, 2005
- Recall 05V-327

Open and recently closed NHTSA defect investigations

Shift Lever Assembly may Allow Rollaway

NHTSA #17V657000 · Power Train — Automatic Transmission · NHTSA notice

Reported October 18, 2017 · Toyota Motor Engineering & Manufacturing

Potentially affected: 310,475 vehicles

Repair completion: 36.87% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Toyota campaign H0V · Owners notified December 13, 2017 · Vehicles built August 8, 2005 – March 5, 2007 (per NHTSA)

Defect description

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2005-2007 and 2009-2010 Toyota Sienna vehicles. In the affected vehicles, due to a problem within the shift lock assembly, the shift lever may be moved out of the 'Park' position without depressing the brake pedal.

Safety consequence

If the shift lever can be moved from the "Park" position without depressing the brake pedal and the parking brake is not applied, the vehicle may roll, increasing the risk of a crash.

Manufacturer remedy

Toyota will notify owners, and dealers will replace the shift lock solenoid and reapply the grease, free of charge. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is H0V. Vehicles that were previously recalled under campaign 13V-429 are not affected by this recall.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Seat Heater Electrical Wiring

NHTSA #16V396000 · Seats — Front Assembly — Seat Heater/Cooler · NHTSA notice

Reported June 2, 2016 · Southeast Toyota Distributors, LLC

Potentially affected: 7,749 vehicles

Repair completion: 23.63% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign SET16B · Owners notified July 14, 2016 · Vehicles built December 5, 1987 – January 27, 2012 (per NHTSA)

Defect description

Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.

Safety consequence

If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.

Manufacturer remedy

SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Seat Heater Electrical Wiring

NHTSA #14V743000 · Seats — Front Assembly — Seat Heater/Cooler · NHTSA notice

Reported November 19, 2014 · Southeast Toyota Distributors, LLC

Potentially affected: 3,233 vehicles

Repair completion: 26.94% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Owners notified January 29, 2015 · Vehicles built June 1, 2004 – September 30, 2011 (per NHTSA)

Defect description

Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.

Safety consequence

Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.

Manufacturer remedy

SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Spare Tire Assembly may Corrode and Detach

NHTSA #14V273000 · Tires — Temporary/Emergency Spare Tire · NHTSA notice

Reported May 22, 2014 · Toyota Motor Engineering & Manufacturing

Potentially affected: 419,520 vehicles

Repair completion: 37.04% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Owners notified July 7, 2015

Defect description

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2004-2011 Sienna vehicles originally sold in, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin and the District of Columbia. The affected vehicles have a spare tire carrier assembly mounted under the vehicle whose attachment cable may corrode due to high concentrations of road salt splashing onto the spare tire carrier.

Safety consequence

If the carrier cable is corroded due to road salt, the spare tire may separate from the vehicle, increasing the risk of a crash.

Manufacturer remedy

Toyota sent owners in August 2014 an interim notification to advise owners of the recall and that dealers will perform an interim remedy to remove the spare tire and relocate it to the luggage compartment, free of charge. Owners are being mailed a second letter as parts become available and dealers will replace the spare tire carrier assembly with an improved one, free of charge. The remedy campaign is being performed in phases. The first phase of the recall began July 7, 2015. Owners may contact Toyota customer service at 1-800-331-4331. NOTE: 2004-2010 Siennas subject to this recall were subject to recall campaign 10V-160 initiated in 2010. Those owners are advised that they must have their vehicles remedied again under this campaign and that having the earlier recall completed did not remedy their vehicles. Additionally, model year 1998-2003 Siennas were recalled as part of safety recall 10V-160. Owners of those vehicles that have not had not the remedy performed on their vehicles, should contact their Toyota dealer to schedule a free repair.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Shift Lever Assembly may Allow Rollaway

NHTSA #13V429000 · Power Train — Automatic Transmission · NHTSA notice

Reported September 26, 2013 · Toyota Motor Engineering & Manufacturing

Potentially affected: 614,722 vehicles

Repair completion: 49.51% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Owners notified February 27, 2014 · Vehicles built January 10, 2003 – August 10, 2005 (per NHTSA)

Defect description

Toyota is recalling certain model year 2004-2005 Sienna vehicles manufactured January 10, 2003, through August 10, 2005; and model year 2007-2009 Sienna vehicles manufactured February 20, 2007, through December 12, 2008. In the affected vehicles, due to a problem within the shift lock solenoid, there is a possibility that the shift lever could be moved out of Park position without depressing the brake pedal.

Safety consequence

If the shift lever is moved out of the Park position without the brake applied, the transmission will either engage a drive gear or Neutral, increasing the risk of a backover or roll away crash.

Manufacturer remedy

Toyota will mail interim notifications to owners beginning in late October 2013. When parts are available, owners will be sent a second notice and dealers will replace the shift lock solenoid, free of charge. Owners may contact Toyota at 1-800-331-4331.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

CRANKSHAFT PULLEY

NHTSA #11V539000 · Engine and Engine Cooling · NHTSA notice

Reported November 9, 2011 · Toyota Motor Engineering & Manufacturing

Potentially affected: 420,326 vehicles

Owners notified December 31, 2011 · Vehicles built June 1, 2004 – January 31, 2005 (per NHTSA)

Defect description

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004 AVALON VEHICLES; 2004 AND 2005 CAMRY, CAMRY SOLARA, HIGHLANDER, AND SIENNA VEHICLES, 2006 HIGHLANDER HYBRID; 2004 AND 2005 LEXUS ES330 AND RX330; AND 2006 LEXUS RX400H VEHICLES MANUFACTURED FROM JUNE 1, 2004 THROUGH MARCH 31, 2005, EQUIPPED WITH THE 1MZ-FE OR 3MZ-FE ENGINE. THE AMOUNT OF ADHESIVE AGENT APPLIED BETWEEN THE OUTER RING AND THE TORSIONAL RUBBER DAMPER (INNER RING) IN THE CRANKSHAFT PULLEY MAY BE INADEQUATE. IF THE ADHESIVE IS INSUFFICIENT, THERE IS A POSSIBILITY THAT THE OUTER RING MAY BECOME MISALIGNED AND IT MAY NOT PROPERLY ROTATE WITH THE INNER RING, CAUSING NOISE AND/OR ILLUMINATION OF THE BATTERY DISCHARGE INDICATOR LIGHT.

Safety consequence

IN SOME CASES, THE BELT FOR THE POWER STEERING PUMP MAY BECOME DETACHED FROM THE PULLEY WHICH COULD RESULT IN A LOSS OF POWER STEERING AND A SUDDEN INCREASE IN STEERING EFFORT, INCREASING THE RISK OF A CRASH.

Manufacturer remedy

TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL CHECK THE CRANKSHAFT PULLEY TO IDENTIFY WHETHER IT WAS PRODUCED BY THE U.S. SUPPLIER. IF SO, THE DEALER WILL REPLACE THE PULLEY WITH A NEW ONE AT NO CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING EARLY JANUARY 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

Notes

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

SPARE TIRE CARRIER ASSEMBLY CABLE CORROSION

NHTSA #10V160000 · Structure · NHTSA notice

Reported April 20, 2010 · TOYOTA MOTOR NORTH AMERICA, INC.

Potentially affected: 600,000 vehicles

Toyota campaign AOE · Owners notified October 12, 2010 · Vehicles built January 16, 2003 – January 4, 2010 (per NHTSA)

Defect description

TOYOTA IS RECALLING CERTAIN MODEL YEAR 1998 THROUGH 2010 SIENNA PASSENGER VEHICLES MANUFACTURED BETWEEN AUGUST 7, 1997 AND JANUARY 4, 2010, CURRENTLY REGISTERED IN OR ORIGINALLY SOLD IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WASHINGTON DISTRICT OF COLUMBIA, VIRGINIA, WEST VIRGINIA, AND WISCONSIN. THE SUBJECT VEHICLES ARE EQUIPPED WITH THE SPARE TIRE STOWED UNDER THE VEHICLE. IF THE VEHICLE IS OPERATED IN THE COLD CLIMATE REGIONS OF THE UNITED STATES WHERE ROAD SALT IS FREQUENTLY USED, WATER SPLASHED BACKWARDS WITH HIGH CONCENTRATIONS OF ROAD SALT CAN REACH THE SPARE TIRE CARRIER AND CORRODE THE SPARE TIRE CARRIER ASSEMBLY CABLE.

Safety consequence

THE CABLE MAY BREAK DUE TO EXCESSIVE CORROSION AND THE SPARE TIRE MAY SEPARATE FROM THE VEHICLE, POSSIBLY RESULTING IN A VEHICLE CRASH.

Manufacturer remedy

TOYOTA WILL NOTIFY OWNERS WITH AN INTERIM LETTER INITIALLY INSTRUCTING THEM TO BRING THEIR VEHICLE TO AUTHORIZED DEALERS TO INSPECT FOR CORROSION. A SECOND NOTICE WILL BE SENT WHEN THE PERMANENT REMEDY IS AVAILABLE. FOR MORE INFORMATION, PLEASE SEE TOYOTA'S AMENDED RECALL REPORT OF JULY 19, 2010. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OCTOBER 12, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

Notes

TOYOTA RECALL NO. AOE.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

LOAD CARRYING CAPACITY MODIFICATION LABELS

NHTSA #10V036000 · Equipment — Other — Labels · NHTSA notice

Reported February 3, 2010 · SOUTHEAST TOYOTA DISTRIBUTORS, LLC

Potentially affected: 153,418 vehicles

Owners notified May 27, 2010

Defect description

SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Safety consequence

A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.

Notes

LOAD CARRYING CAPACITY MODIFICATION LABELS

NHTSA #10V035000 · Equipment — Other — Labels · NHTSA notice

Reported February 3, 2010 · GULF STATES TOYOTA, INC.

Potentially affected: 271,417 vehicles

Owners notified May 27, 2010

Defect description

GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Safety consequence

THIS DOES NOT MEET THE STANDARD REQUIREMENTS.

Manufacturer remedy

DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.

Notes

INCORRECT GVWR LABELS

NHTSA #09V234000 · Equipment — Other — Labels · NHTSA notice

Reported June 25, 2009 · TOYOTA MOTOR NORTH AMERICA, INC.

Potentially affected: 2,204 vehicles

Toyota campaign SSC 9LF · Owners notified December 10, 2009 · Vehicles built January 1, 2003 – May 4, 2009 (per NHTSA)

Defect description

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2009 SIENNA AND 2009 LEXUS GX PASSENGER VEHICLES. THE VEHICLE CAPACITY WEIGHT ON THE TIRE AND LOADING INFORMATION LABEL AND THE GVWR ON THE CERTIFICATION LABEL IS INSUFFICIENT FOR CERTAIN VEHICLES. SOME VEHICLES WERE ACCESSORIZED THROUGH VEHICLE PROCESSING CENTERS AND HAD ACCESSORIES INSTALLED THAT CAUSED THE VEHICLE TO EXCEED THE GVWR VALUE. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO 110, "TIRE SELECTION AND RIMS," AND 49 CFR PART 567.

Safety consequence

THE GVWR IS INSUFFICIENT FOR THE LOAD CARRYING CAPACITY OF THE VEHICLES.

Manufacturer remedy

TOYOTA WILL NOTIFY OWNERS INSTRUCTING THEM TO RETURN THEIR VEHICLE TO A TOYOTA OR LEXUS DEALER FOR AN EXCHANGE OF THE CERTIFICATION LABEL AND THE TIRE AND LOADING INFORMATION LABEL, AN INSTALLATION OF THE LOAD CARRYING CAPACITY MODIFICATION LABEL, IF NECESSARY, AND A CORRECTION TO THE OWNER'S MANUAL. THIS REMEDY WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 10, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.

Notes

RECALL NUMBER SSC 9LF.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

POWER REAR LIFTGATE

NHTSA #08V244000 · Structure — Body — Hatchback/Liftgate · NHTSA notice

Reported June 3, 2008 · TOYOTA MOTOR NORTH AMERICA, INC.

Potentially affected: 196,222 vehicles

Toyota campaign 80C · Owners notified August 4, 2008 · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

TOYOTA IS CONDUCTING A SAFETY IMPROVEMENT CAMPAIGN INVOLVING 196,222 MY 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER REAR LIFTGATE STRUTS. THE GAS STRUTS USED TO HELP LIFT AND SUPPORT THE REAR POWER LIFTGATE COULD WEAR OUT SOONER THAN EXPECTED. AS THE GAS STRUTS DETERIORATE, THE PERFORMANCE OF THE LIFTGATE WILL BEGIN TO DEGRADE AND THE POWER REAR LIFTGATE WILL OPERATE MORE SLOWLY THAN WHEN THE GAS STRUTS WERE NEW.

Safety consequence

IF NOT REPAIRED, THE GAS STRUTS MAY NOT BE ABLE TO SUPPORT THE WEIGHT OF THE LIFTGATE WHEN IT IS OPEN EVENTUALLY, THE GAS STRUTS COULD DETERIORATE TO THE POINT THAT THE LIFTGATE WILL FALL ABOUT TEN INCHES AFTER IT REACHES THE FULLY OPEN POSITION, AT WHICH POINT THE POWER MOTOR WILL ENGAGE AND POWER THE LIFTGATE TO THE FULLY CLOSED POSITION. THIS CONDITION MAY CAUSE INJURY TO A PERSON WHO IS STRUCK BY THE LIFTGATE WHEN IT FALLS OR WHEN IT IS CLOSING.

Manufacturer remedy

DEALERS WILL REPLACE THE GAS STRUTS WITH NEWLY DESIGNED GAS STRUTS THAT HAVE A LONGER SERVICE LIFE. THE CAMPAIGN BEGAN ON AUGUST 8, 2008, AND WILL BE MAILED IN THREE PHASES ENDING IN LATE DECEMBER 2008. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.

Notes

TOYOTA NO. 80C.THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. HOWEVER, TOYOTA HAS INFORMED NHTSA THAT IT WILL PROVIDE THE MODIFICATIONS DESCRIBED ABOVE FREE OF CHARGE.

PASSENGER SEAT BELT

NHTSA #05V327000 · Seat Belts · NHTSA notice

Reported July 20, 2005 · TOYOTA MOTOR NORTH AMERICA, INC.

Potentially affected: 345,443 vehicles

Toyota campaign 50L · Owners notified August 5, 2005 · Vehicles built January 10, 2003 – May 18, 2005 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

ON CERTAIN MINI VANS, IN THE MIDDLE ROW SEATING POSITION, THE SHOULDER PORTION OF THE SEAT BELT MAY BIND IN THE BEZEL TRIM PIECE. THE AFFECTED SEAT BELT BEZEL IS LOCATED ON THE SHOULDER PORTION OF THE SEAT IN THE RIGHT SIDE SEAT OF THE SEVEN PASSENGER MODELS AND THE CENTER SEATING POSITION IN THE EIGHT PASSENGER MODELS.

Safety consequence

IF THE SEAT BELT BINDS IN THE BEZEL, THAT EXTRA WEBBING MAY EXIST IN THE SEAT BELT WHICH COULD RESULT IN AN IMPROPERLY FITTED SEAT BELT ON A PASSENGER. IN THE EVENT OF A CRASH, A SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED INCREASING THE RISK OF PERSONAL INJURY.

Manufacturer remedy

DEALERS WILL REPLACE THE SEAT BELT BEZEL AND CLIP. THE RECALL BEGAN AUGUST 5, 2005. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

Notes

TOYOTA RECALL NO. 50L.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236; (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

2005 Toyota Sienna

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 4, Passenger: 5

Side Crash

Not Rated

Driver: 5, Passenger: 5

Side Pole

Not Rated

Rollover

Not Rated

Safety Technology

6 investigations

1,130 owner complaints have been filed with NHTSA for the 2005 Toyota Sienna.

Air Bags; Structure

ODI #11591696

Incident: January 8, 2024 · Filed: May 31, 2024

The dashboard has so many cracks literally everywhere. All the way from the driver side to the passenger side. When the temperature changes hot to cold or cold to hot. There’s nothing but cracking sounds.

Engine and Engine Cooling

ODI #11571869

Incident: February 5, 2024 · Filed: February 14, 2024

The contact owns a 2005 Toyota Sienna. The contact stated while driving 65 MPH, the oil warning light illuminated. The contact pulled over, opened the hood, and added additional oil. The vehicle was towed to an independent mechanic, who informed him that the engine needed to be replaced. The vehicle was towed to the residence. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified. The approximate failure mileage was 142,000.

Unknown or Other; Structure

ODI #11556754

Incident: April 15, 2023 · Filed: November 25, 2023

The rear hatch on our 2005 Toyota Sienna, after being opened, comes down almost immediately and can hit a person who is reaching into the back cargo area and cause injury. Other people have also reported this same dangerous malfunction online as far back as 2007.

Steering; Service Brakes

ODI #11547272

Incident: September 29, 2023 · Filed: September 29, 2023

When driving on the highway, the van will suddenly brake and the steering will lock up for about 10 seconds. It is truly frightening. It has happened many times, even with the anti-lock button off. I love this vehicle otherwise, but cannot drive it for safety reasons. And I feel bad selling it to anyone else because I don't want anyone to die! The scariest part when it's on a windy 2 lane road. It really becomes non responsive and also the brakes come on when you are going 60+ miles an hour! HELP! I DONT WANT TO DIE

Visibility/Wiper

ODI #11546395

Incident: September 25, 2023 · Filed: September 25, 2023

The stickiness of the dashboard causes unwanted glare and reflections on the windshield, especially when driving in bright sunlight. This glare and reflection make it extremely challenging to maintain a clear and unobstructed view of the road ahead, leading to hazy and blurry vision. As you can imagine, this compromised visibility poses a significant safety risk for both my family and other road users. The dashboard was recalled by Toyota however the part was not available at first for many months and by the time I inquired again, the recall had already expired, leaving us without a viable solution.

Air Bags

ODI #11544568

Incident: April 1, 2022 · Filed: September 14, 2023

Air bag warning light illuminated red on dashboard.

Air Bags; Seat Belts

ODI #11534963

Incident: July 26, 2023 · Filed: July 28, 2023

The airbag light is on. The seatbelt on the passenger side gets stuck.

Steering; Vehicle Speed Control; Service Brakes

ODI #11518385

Incident: April 22, 2023 · Filed: April 22, 2023

I was driving on a dry road, going 70mph when my car began flashing the abs indicator and it began breaking and controlling my steering taking me into another lane. The car slowed my vehicle suddenly down to 60 mph and then went off like it never happened. I then had control. There was no reason for the car to do this. There was nothing in the road and luckily no one was to close to me or there would have been an accident. I almost over corrected due to the pulling of the steering and the breaking of the vehicle.

Power Train

ODI #11511999

Incident: March 12, 2023 · Filed: March 15, 2023

The contact owns a 2005 Toyota Sienna. The contact stated when he walked outside, he noticed that the vehicle had rolled backwards into the middle of the street. The contact was able to drive the vehicle back into the driveway; however, the failure reoccurred. The dealer was not contacted. The manufacturer was contacted, and the manufacturer stated that the vehicle was previously repaired under NHTSA Campaign Number: 17V657000 (Power Train) and a case was filed. The failure mileage was 140,000.

Structure

ODI #11486049

Incident: December 25, 2019 · Filed: September 23, 2022

Broken spare tire carrier. Seems to be a common problem on XLE sienna. I have 2005 LE and my spare tire carrier is completely broken. Tried getting a replacement from 5 parts car sienna and they were all broken as well! Another common problems Sienna have are rack and pinions. They always leak. I owned a 1998 then a 2003 sienna and they both leaked from the power steering pack. Spare tire carrier is a dangerous issue. Spare tire can fall off on the road and can cause auto accidents or serious injuries and serious damage to other autos on the road. rack and pinion leaks leave oil on the floor. Steering locks up without power steering which can cause a serious accident.

Other Toyota Sienna model years

Check your 2005 Toyota Sienna VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Toyota Sienna at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Toyota VIN