2015 Toyota Sienna Recalls, Ratings & Complaints

Incident: October 5, 2026 · Filed: October 7, 2026

1) 2015 Toyota Sienna sliding door is faulty and can cause the door to open at anytime. They need to replace the junction block, rear sliding door wire harness and wire as part of existing recall G04. It was completed for driver side in 2024 and recall was marked complete however in 2026 the passenger side is encountering same issue. This puts any family member or friends life at risk with the potential of 2nd row sliding door to open at anytime without fix. It has been reproduced buy Toyota is saying the recall is marked complete for my vin when it wasn’t for both doors.

Incident: September 18, 2026 · Filed: September 20, 2026

This is the 2nd Occurrence where Sliding Door Cable Breaks and the doors are disabled where you can not open or close the sliding door and its jammed shut. Attempts to press the Power Sliding door buttons do not work. This is the 2nd Occurrence on this Vehicle. The First occurrence happened approximately 3 years ago with the Driver Sliding Door and was report to Holman Toyota , 1301 NJ 73, Mt. Laurel township, NJ 08054. Now the passenger sliding door cable is broken and the door is jammed shut also

Incident: September 3, 2026 · Filed: September 10, 2026

The cable that controls the sliding door lock disconnected leaving the door inoperable. According to the dealership, as well as, Toyota corporate, this is a common ongoing issue. This is a safety hazard and should be recalled immediately.

Incident: August 12, 2026 · Filed: August 26, 2026

Component Failed & Availability: The engine on my 2015 Toyota Sienna (99,000 miles) catastrophically failed and is completely seized. The vehicle and engine are in my possession and are fully available for physical inspection. Safety Risk: The vehicle shut down completely while in motion, causing an immediate loss of motive power, power steering, and power braking assistance. Had this un-warned seizure occurred at highway speeds rather than a parking lot, the sudden loss of vehicle control would have posed a severe crash hazard. Reproduced/Confirmed: Yes. A certified mechanic removed the serpentine belt, attempted to turn the engine with a lock bar, and confirmed the engine block is completely seized. The local dealership, Fred Haas ToyotaWorld, also confirmed the vehicle does not run. Inspections: The vehicle was inspected by my independent mechanic and the local dealership. However, Toyota Corporate formally refused my request to dispatch a field engineer to inspect the defective engine. Prior Warnings: There were absolutely no warning lamps, check engine lights, temperature spikes, or abnormal noises prior to the failure. The engine seized instantly and without warning.

Incident: May 22, 2026 · Filed: July 17, 2026

I am submitting this complaint to request that the National Highway Traffic Safety Administration (NHTSA) document and evaluate what may be a broader defect affecting certain Toyota Sienna vehicles and determine whether it presents a potential safety-related defect trend. My 2015 Toyota Sienna was diagnosed by an authorized Toyota dealership with an external rear-bank head gasket leak. A head gasket is a critical engine component, and failure can result in coolant loss, engine overheating, reduced engine performance, stalling, or complete vehicle disablement. These conditions may create a safety risk, particularly if they occur while driving in traffic or at highway speeds. An authorized Toyota dealership confirmed the diagnosis and submitted a goodwill assistance request to Toyota. The dealership noted my history as a repeat Toyota customer and recommended that assistance be provided. Toyota denied the goodwill request based on the vehicle's age and mileage. I subsequently appealed through Toyota's customer relations process, and the denial was upheld. I understand that NHTSA does not resolve individual warranty or customer-assistance disputes. My purpose in submitting this complaint is to request that NHTSA determine whether similar reports exist involving premature head gasket failures in this model year or related vehicles and, if warranted, evaluate whether a broader defect trend exists that could present a safety concern. Potential safety consequences include engine overheating, loss of power, stalling, and unexpected vehicle disablement. The vehicle has been maintained in accordance with manufacturer recommendations and has not experienced any overheating event that would reasonably explain a premature head gasket failure. Thank you for your consideration and for documenting this complaint as part of NHTSA's review of potential vehicle safety issues. Respectfully, Vehicle Owner

Incident: July 1, 2026 · Filed: July 16, 2026

I have requested urgent warranty evaluation regarding two Kumho Solus TA51a tires installed on my Toyota Sienna (Model: Kumho Solus TA51a, Size: 235/60R17 102H, DOT: 1824) Both front tires are exhibiting abnormal tread chunking and visible surface shredding. The tires are relatively new (purchased about 1-1.5 years ago) and have not been heavily used (only riding this car occassionally, about 5000-7000 miles per year). Our 2 rear tires are Kumho tires of different model, and although older, they are performing fine and do not experience these issues so it seems to be an issue on this particular Solus TA 51a model Kumho tires. Because this is our family vehicle and we transport our children in it regularly, we are very concerned about the safety of continuing to drive on these tires. I also returned to the tire shop that sold and installed the tires. After inspecting them, the owner advised me to contact Kumho for a warranty evaluation, informing me that he received similar complaints from other customers (especially Toyota Sienna owners) using this tire model. While I no longer have the original purchase receipt, the dealer can verify that the tires were purchased from and installed by his shop. I reached out to Kumho Tires USA by completing their online contact form 2 wks ago, which informed a response within 48 hours, but I have not received any response. I called and left a voice message in their warranty department, and in their general customer service line earlier this week, but still not response. I even completed another contact form and also reached out by email, but still no response. Then I remembered my mom recently sharing a concern about her tires, and just found out that she had same 'chunking' issues on her tires, which happened to be the same Kumho Solus TA51a tires from the same tire shop. Her car is Toyota Camry, not a Sienna, so this is happening on this specific tire model across all types of cars they are installed to. Please help!

Incident: June 15, 2026 · Filed: June 18, 2026

My 2015 Toyota Sienna has “Sticky” steering. When on a curve, like an highway curved ramp, the steering locks in place. I have to pull the steering wheel back to keep the car on track. When it sticks I can literally let go on a curve and it will hold it’s position. Even when driving straight this occurs. The steering wheel will stick in place requiring me to turn it to get the steering wheel to come back to the desired or correct position. I’m seeing that this is a regular problem for Toyota steering across multiple models. Having your steering get stuck in place has the potential to be a very serious safety issue. This may cause an accident and resulting death. The complete repair for this safety issue to the consumer is over $3000.00. This is ridiculous! This is my first Toyota. I think their reliability night be really over rated.

Incident: May 22, 2026 · Filed: May 22, 2026

Rain water leaking into the parked vehicle on the driver and passenger seat belts, potentially weakening the belts and creating odor.

Incident: April 21, 2026 · Filed: April 22, 2026

On April 15, 2026 Report filed with NHTSA from an accident-causing property damage due to a failure in the shifter mechanism while the vehicle was parked, ignition off, no keys in the vehicle and the brake pedal was NOT pressed. Manufacture initiated an investigation after we contacted their customer care line. Our vehicle was taken to a Toyota dealership on March 11, 2026. We received an email on April 13, 2026 stating Toyota's inspection did not identify any evidence that this incident was a result of a concern with the operation of our vehicles gear shift lever. We retrieved our vehicle from the dealership on April 20, 2026. On April 21, 2026 From our driveway the shift lever fell out of park into drive with the ignition off, no keys, and the brake pedal not pressed. Toyota claims no responsibility! How is this possible when they know there are active recalls for the same issue on earlier models? This is a massive public safety risk considering the vehicle can rollaway without the ignition even being on! I will continue to report this issue every time the Shift lever falls out of park until resolved.

Incident: April 21, 2026 · Filed: April 22, 2026

On April 15, 2026 Report filed with NHTSA from an accident-causing property damage due to a failure in the shifter mechanism while the vehicle was parked, ignition off, no keys in the vehicle and the brake pedal was NOT pressed. Manufacture initiated an investigation after we contacted their customer care line. Our vehicle was taken to a Toyota dealership on March 11, 2026. We received an email on April 13, 2026 stating Toyota's inspection did not identify any evidence that this incident was a result of a concern with the operation of our vehicles gear shift lever. We retrieved our vehicle from the dealership on April 20, 2026. On April 21, 2026 From our driveway the shift lever fell out of park into drive with the ignition off, no keys, and the brake pedal not pressed. Toyota claims no responsibility! How is this possible when they know there are active recalls for the same issue on earlier models? This is a massive public safety risk considering the vehicle can rollaway without the ignition even being on! I will continue to report this issue every time the Shift lever falls out of park until resolved.