2024 Ram 2500 Recalls & Complaints

Incident: September 6, 2026 · Filed: September 22, 2026

While driving a phantom auto trailer light will come on and I am not tow anything. While towing phantom check brake wiring and trailer brake disconnected warning lights appear.

Incident: September 4, 2026 · Filed: September 11, 2026

While driving, the vehicle suffered a sudden, complete, and catastrophic loss of braking power due to a total failure of the brake fluid line. The vehicle had to be immediately pulled off the road to avoid a serious collision.The vehicle was transported to a certified Ram dealership service center (Southern Motors CDJR in Savannah, GA). Upon inspection, the certified factory technician discovered and documented a severe manufacturing assembly defect: the primary brake fluid line was routed incorrectly at the factory. Due to this improper routing, the line was resting in direct, constant physical contact with the hot exhaust pipe. Over time, the extreme heat from the exhaust melted completely through the brake line and the protective heat sleeve, causing an immediate drop in hydraulic pressure and total brake system failure.This is a critical manufacturing assembly error that poses an imminent life-safety risk and fire hazard to myself and other drivers of this model year. If this incorrect routing is widespread on the assembly line, it will lead to sudden brake failures at highway speeds. I am requesting a formal safety investigation into the factory routing of the brake lines relative to the exhaust system on the 2024 Ram 2500.

Incident: August 24, 2026 · Filed: September 4, 2026

LT275/70R18 Firestone E Transforce HT2 Upon seeing warning lamp for low air second time, tire was taken to independent shop for inspection and repair. Tech stated tire (23000 miles) could not be repaired because of a safety issue due to sidewall seperation defect with no sign of impact or run flat damage. The rubber was soft and thin. Could have been catastrophic had it blown out on highway. I purchased a replacement. When I took the tire to a Firestone retail store, the manager said "It's hard to tell what happened to it" obviously denying a defect and refered Me to "corporate" to try and get credit. I told him I was concerned about the other three tires because they have the same batch number. DOT VN15 TH7 5123. He stated They would do a visual inspection nothing else. I have the tire if needed for inspection. I do not feel safe driving on the other tires. This lot should be recalled.

Incident: October 6, 2025 · Filed: September 2, 2026

I had a sent the vehicle in for warranty repairs for what i was told faulty lifters. the paper work shows lifters and cam was replaced and some rocker and some rods but not all. no photos provided. after my first oil change after the repair the noise is back and they state its normal and it has been noted.

Incident: November 24, 2025 · Filed: August 24, 2026

The contact owns a 2024 Ram 2500. The contact stated that while depressing the brake pedal, the brake pedal went to the floorboard. The contact had to pump the brake pedal several times to stop the vehicle. The vehicle was taken to the dealer for an oil change, and the contact informed the dealer of the failure; however, the vehicle was not diagnosed or repaired. The manufacturer was not informed of the issue. The failure mileage was approximately 15,000.

Incident: March 31, 2026 · Filed: June 29, 2026

The contact owns a 2024 Ram 2500. The contact stated that while driving at an undisclosed speed, the trailer braking system failed to operate, slow the vehicle, or stop the trailer while the brake pedal was depressed. The contact stated that the trailer brake disconnected warning light was illuminated. The contact researched and was made aware of NHTSA Campaign Number: 26V059000 (Exterior Lighting, Electrical System); however, the VIN was not included. The vehicle was taken to a dealer, where it was diagnosed, and it was determined that the trailer brake controller needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 12,000.

Incident: June 20, 2026 · Filed: June 22, 2026

This is a brand new truck with 22,000 miles, a rod came loose in the engine when i was driving it, and blew a hole in the engine at 65 MPH, the rod then shot through my oil pan, I lost all drivability, no steering, no gas and I could not see due to black smoke. I almost died! I was able to pull over all the way to the left by the grace of God, not being able to see and having cars driving by at top speeds this is a catastrophic failure and the service Tech Ethan where the truck is says this happens 1 in every 1,000 trucks! The truck is at castle rock co dodge jeep ram

Incident: November 1, 2025 · Filed: June 9, 2026

Brakes always collapse to the Floor. You cannot stick your toe in between the brake and the floorboard. But if you pump up the brakes like you used in the 1970''s the brake will rise and you can put a full foot underneath between the brake and the floorboard. Those making the brakes stop the truck 80%better. But if you put it in 4x4 mode there is almost no stopping power at all. You only have 10% of your brakes. Both issues can cause death and or injuries! If 4x4 is used on the road for rain or snow it will cause death and if your lucky just a major injury!!!!!!

Incident: May 6, 2026 · Filed: May 6, 2026

The vehicle experienced repeated electrical and no-start issues believed to be related to the RF/electrical communication system. The truck has been returned to the dealership repeatedly for this issue and recently spent approximately two months at the dealership for diagnosis and repair. After finally being returned, the vehicle was completely dead the very next morning and would not start. The vehicle has also experienced dangerous electrical failures while being driven. During one incident at night, the headlights and interior electrical system became extremely dim and began flickering while an employee was operating the truck. Visibility was significantly reduced to the point the driver could barely see the roadway. During the same event, the brake pedal became abnormally hard to press intermittently, creating a serious safety concern while driving. The failure also occurred on our business lot where the truck was blocking multiple trailers needed for scheduled customer deliveries, creating operational disruption and safety concerns related to moving equipment and trailers around an inoperable heavy-duty truck. The dealership reportedly replaced or repaired an RF-related component/module during the repair process. However, the problem appears unresolved because the truck failed again immediately after being returned from service. Symptoms have included: * Complete battery drain/no-start condition * Flickering and dimming headlights/electrical systems * Intermittent hard brake pedal condition * Repeated electrical-related issues * Extended dealer downtime * Ongoing unresolved repair attempts The vehicle is available for inspection upon request. This truck is used daily for commercial/business operations. Reliability concerns are significant because unexpected electrical failure or no-start conditions can leave the vehicle stranded or create hazardous driving conditions. The issue has been reproduced after dealer repair attempts. Based on the symptoms and

Incident: April 19, 2026 · Filed: May 2, 2026

I was in my yard backing my truck up and the camera froze in the location that I was in and the sensors did not beep. The distance that I was backing up was not very far. It wasn't until I backed into a post in the front of my house, that I realized the camera and sensors had temporarily failed.