NHTSA vehicle safety data
1995 Orion V Recalls & Complaints
The 1995 Orion V has 6 NHTSA recall campaigns on file as of October 21, 2026. try.vin has no NHTSA owner complaints on file for the 1995 Orion V. Recall repairs are usually free at an authorized Orion dealer.
NHTSA recall and complaint data for the 1995 Orion V. Recall data is refreshed daily from NHTSA.
REMOTE THROTTLE CONTROL
NHTSA #10V015000 · Power Train — Clutch Assembly — Pedal/Hand Lever(MOTORCYCLE) · NHTSA notice
Reported January 21, 2010 · DAIMLER BUSES NORTH AMERICA, INC.
Potentially affected: 426 vehicles
Owners notified April 1, 2010 · Vehicles built February 1, 1992 – May 31, 2009 (per NHTSA)
Defect description
DAIMLER BUSES IS RECALLING CERTAIN ORION TRANSIT BUSES EQUIPPED WITH THE MORSE REMOTE THROTTLE CONTROL. THE MORSE REMOTE THROTTLE CONTROL PANEL IS LOCATED IN THE ENGINE COMPARTMENT AND A SWITCH ON IT IS LABELED, "THROTTLE"; "OFF" OR "FRONT" AND "ON" OR "REAR" SELECTING THE ACTIVE ENGINE CONTROL STATION. IF A PERSON OPERATING THE ENGINE FROM THE "REAR" POSITION (AT THE ENGINE) FAILS TO PLACE THE SWITCH IN THE "OFF" OR "FRONT" POSITION AND THE ENGINE RPM WAS SET TO ABOVE IDLE DURING MAINTENANCE FOR EXAMPLE, WHEN THE BUS IS STARTED FROM THE DRIVER'S STATION THE ENGINE COULD CHANGE TO THE HIGHER RPM RESULTING IN UNWANTED ENGINE POWER.
Safety consequence
THE BUS COULD ACCELERATE AT A HIGHER RATE THAN ANTICIPATED INCREASING THE RISK OF A CRASH.
Manufacturer remedy
DAIMLER WILL PROVIDE INSTRUCTIONS TO MODIFY THE WIRING TO THE MORSE THROTTLE CONTROL SWITCH. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 1, 2010. OWNERS MAY CONTACT DAIMLER BUSES AT 1-800-716-7466.
Notes
OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .
WHEELCHAIR LIFTS/LIFT-U
NHTSA #07V024000 · Equipment Adaptive/Mobility · NHTSA notice
Reported February 1, 2007 · DAIMLERCHRYSLER COMMERCIAL BUSES NA
Potentially affected: 3,637 vehicles
Owners notified January 1, 2007 · Vehicles built November 1, 1987 – April 30, 1998 (per NHTSA)
Defect description
ON CERTAIN TRANSIT BUSES EQUIPPED WITH LIFT-U WHEELCHAIR LIFTS, IT IS POSSIBLE FOR A PERSON TO WEDGE THEIR FEET UNDER THE SOLID BAR BARRIER LINKAGE.
Safety consequence
WHILE SITTING IN A WHEELCHAIR, A PERSON WITH NO SHOES AND WHO DOES NOT HAVE CONTROL OF THEIR FEET COULD TWIST THEIR FEET AND GET THEM FORCED UNDER THE LINKAGE WHICH COULD RESULT IN AN INJURY.
Manufacturer remedy
DAIMLERCHRYSLER COMMERCIAL IS WORKING WITH LIFT-U TO REPAIR THESE BUSES (PLEASE SEE 06E-093). OWNERS WILL RECEIVE A FREE REPAIR KIT ALONG WITH INSTALLATION INSTRUCTIONS FREE OF CHARGE. OWNERS MAY CONTACT LIFT-U AT 209-838-2400 OR ORION BUS AT 905-403-7807.
Notes
CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
ORION/FMVSS 217/EMERGENCY WINDOW
NHTSA #04V545000 · Structure · NHTSA notice
Reported November 15, 2004 · ORION BUS INDUSTRIES LTD.
Potentially affected: 2,045 vehicles
Owners notified May 1, 2005 · Vehicles built September 1, 1995 – August 31, 2004 (per NHTSA)
Defect description
CERTAIN TRANSIT BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 217, "BUS EMERGENCY EXITS AND WINDOW RETENTION AND RELEASE." DURING SUBSEQUENT CLOSING OF AN EMERGENCY EXIT THE MOVING WINDOW FRAME INTERFERES WITH THE JAM FRAME STOP LOCATED IN MID SPAN ALONG THE LOWER EDGE OF THE WINDOW FRAME.
Safety consequence
DURING THE USE OF AN EMERGENCY EXIT WINDOW, A WINDOW MAY NOT OPEN AFTER APPLYING THE REQUIRED FORCES ALLOWING A PERSON TO ESCAPE IN THE EVENT OF AN EMERGENCY.
Manufacturer remedy
DEALERS WILL INSTALL TWO ALUMINUM BLOCKS EACH ATTACHED BY TWO SCREWS. THE MOVING WINDOW FRAME WILL NOT INTERFERE WITH THE JAM FRAME STOP. THE RECALL BEGAN MAY 1, 2005. OWNERS SHOULD CONTACT ORION AT 905-403-7832, EXT. 3335.
Notes
CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
ORION/FMVSS 217/WINDOW HANDLE
NHTSA #03V120000 · Visibility — Glass, Side/Rear · NHTSA notice
Reported March 27, 2003 · ORION BUS INDUSTRIES, INC.
Potentially affected: 4,191 vehicles
Owners notified June 2, 2003 · Vehicles built January 1, 1995 – December 31, 2002 (per NHTSA)
Defect description
CERTAIN TRANSIT BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 217, "BUS EMERGENCY EXITS AND WINDOW RETENTION AND RELEASE." THE HANDLE PULL FORCE EXCEEDS THE 89N FORCE TO RELEASE THE EMERGENCY WINDOW. ADDITIONAL FORCE IS REQUIRED TO RELEASE THE WINDOW.
Safety consequence
IN THE EVENT OF A CRASH, AN OCCUPANT MAY HAVE DIFFICULTY OPENING THE EMERGENCY EXIT WINDOW, INCREASING THE RISK OF PERSONAL INJURY OR DEATH.
Manufacturer remedy
DEALERS WILL REPAIR THESE WINDOWS. OWNER NOTIFICATION BEGAN JUNE 1, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT ORION AT 1-800-492-2116.
Notes
CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
ORION/POWER CABLE ROUTING
NHTSA #98V230000 · Electrical System — Wiring · NHTSA notice
Reported September 17, 1998 · ORION BUS INDUSTRIES, INC.
Potentially affected: 1,068 vehicles
Owners notified April 15, 1998 · Vehicles built June 26, 1995 – April 15, 1998 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation
Defect description
VEHICLE DESCRIPTION: TRANSIT BUSES EQUIPPED WITH ELECTRIC ENGINE STARTERS. THE POWER CABLES ARE ROUTED ACROSS THE BACK OF THE ENGINE AND FASTENED TO THE ENGINE BULKHEAD. THE CABLE MAY NOT BE ADEQUATELY FASTENED, CHAFFING THE CABLE, AND CAUSING AN ELECTRICAL SHORT.
Safety consequence
THIS CONDITION COULD POSSIBLY START A FIRE IN THE ENGINE COMPARTMENT.
Manufacturer remedy
DEALERS REROUTED THE WIRING IN THE ENGINE COMPARTMENT.
Notes
OWNER NOTIFICATION BEGAN APRIL 15, 1998.ALL OWNERS HAVE BEEN NOTIFIED.NO FURTHER ACTION IS REQUIRED ON THIS RECALL.
ORION/WHEELCHAIR RESTRAINTS
NHTSA #97V002000 · Unknown or Other · NHTSA notice
Reported January 2, 1997 · ORION BUS INDUSTRIES, INC.
Potentially affected: 578 vehicles
Owners notified January 10, 1997 · Vehicles built June 7, 1995 – December 30, 1996 (per NHTSA)
Defect description
THE SUBJECT VEHICLES HAVE THEIR WHEELCHAIR BARRIERS ATTACHED TO THE FLOOR STRUCTURE WITH A BOLT THREADED INTO THE FLOOR STRUCTURE. IN THE CASE OF A FRONTAL CRASH, AT MORE THAN 20 MILES PER HOUR, WITH THE WHEELCHAIR POSITION OCCUPIED, THERE IS A POSSIBLY THAT THE BOLT THREADS TAPPED INTO THE FLOOR STRUCTURE WOULD STRIP ALLOWING MOVEMENT OF THE WHEELCHAIR BARRIER.
Safety consequence
FAILURE OF THE HARDWARE ATTACHMENT WOULD ALLOW MOVEMENT OF THE WHEELCHAIR BARRIER WHICH COULD CAUSE INJURIES, OR DEATH OF THE DISABLED PERSON OR OTHER PASSENGERS.
Manufacturer remedy
THE EXISTING WHEELCHAIR BARRIER LEG MOUNTING BOLTS WILL BE REPLACED WITH NEW BOLTS, WASHERS AND NUTS.
Notes
OWNER NOTIFICATION:OWNER NOTIFICATION WILL BEGIN JANUARY 10, 1997. NOTES:IF YOU DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT ORION AT 1-905-625-9510.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
Other Orion V model years
Check your 1995 Orion V VIN
Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Orion V at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.
Check an Orion VIN