How many recalls does the 2005 Orion V have?

NHTSA lists 5 recall campaigns for the 2005 Orion V as of October 16, 2026. Each includes the defect description, safety consequence, and the remedy Orion will perform. New recalls can be issued at any time; this page is refreshed from NHTSA daily.

How do I tell if my 2005 Orion V is affected by a recall?

Enter your 17-character VIN — stamped at the base of the windshield on the driver side and on the door jamb sticker — at nhtsa.gov/recalls. NHTSA's VIN lookup shows whether your specific vehicle has an unrepaired recall; the list on this page covers every campaign for the 2005 Orion V.

Are recall repairs on a 2005 Orion V free?

Usually. Federal law requires Orion to remedy recalls on the 2005 V free of charge at an authorized Orion dealer, regardless of how many owners the vehicle has had or how many miles are on the odometer — unless it was first sold more than 15 years before the recall was issued (5 years for tires).

Does a recall on the 2005 Orion V affect resale value?

An open recall can reduce resale value; a recall that has been repaired (documented in the vehicle history report) generally does not. Before you buy or sell a used 2005 Orion V, check the VIN at nhtsa.gov/recalls to confirm every recall has been remedied.

How many owner complaints are on file for the 2005 Orion V?

No owner complaints have been filed with NHTSA on the 2005 Orion V.

NHTSA vehicle safety data

2005 Orion V Recalls, Ratings & Complaints

The 2005 Orion V has 5 NHTSA recall campaigns and 0 owner complaints on file as of October 16, 2026. Recall repairs are usually free at an authorized Orion dealer.

NHTSA recall and complaint data for the 2005 Orion V. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

ELECTRICAL SYSTEM

NHTSA #13V476000

Reported September 27, 2013 · Daimler Buses North America

Potentially affected: 3,009 vehicles

Defect description

Daimler Buses North America Ltd. (DBNA) is recalling certain model year 2003-2008 Orion V and model year 2002-2010 VII buses equipped with Sure Power equalizers and DC-DC Converters. The specific potting compound used in the equalizers and convertors for insulation was found to be capable of conducting electricity after being exposed to heat.

Safety consequence

Once electrically conductive, the material is capable of melting and burning, increasing the risk of a fire.

Manufacturer remedy

DBNA will notify owners and Sure Power representatives will change out the equalizer and/or convertor, free of charge. The recall is expected to begin during November 2014. Owners may contact DBNA at 1-905-403-1111.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

ENGINE AND ENGINE COOLING:ENGINE:OTHER FUEL TYPES:TURBO/SUPERCHARGER

NHTSA #12V447000

Reported September 13, 2012 · DAIMLER BUSES NORTH AMERICA, INC.

Potentially affected: 187 vehicles

Defect description

Daimler Buses North America (DBNA) is recalling certain model year 2004-2008 Orion V and model year 2005-2006 Orion VII transit buses equipped with John Deere Compressed Natural Gas (CNG) turbocharged engines. The turbine or compressor wheel may fail, resulting in subsequent damage to the engine and/or an oil leak.

Safety consequence

Failure of the turbine or compressor wheel may result in smoke, fire, and stalling, increasing the risk of a crash.

Manufacturer remedy

DBNA will notify owners. The remedy for this issue is still under development. The safety recall began on September 28, 2012. Owners may contact Daimler Buses North America at 1-800-882-8054.

Notes

Customers may contact the National Highway Traffic Safety Administration's Vehicle Safety Hotline at 1-888-327-4236 (TTY: 1-800-424-9153); or go to http://www.safercar.gov.

POWER TRAIN:CLUTCH ASSEMBLY:PEDAL/HAND LEVER(MOTORCYCLE)

NHTSA #10V015000

Reported January 21, 2010 · DAIMLER BUSES NORTH AMERICA, INC.

Potentially affected: 426 vehicles

Defect description

DAIMLER BUSES IS RECALLING CERTAIN ORION TRANSIT BUSES EQUIPPED WITH THE MORSE REMOTE THROTTLE CONTROL. THE MORSE REMOTE THROTTLE CONTROL PANEL IS LOCATED IN THE ENGINE COMPARTMENT AND A SWITCH ON IT IS LABELED, "THROTTLE"; "OFF" OR "FRONT" AND "ON" OR "REAR" SELECTING THE ACTIVE ENGINE CONTROL STATION. IF A PERSON OPERATING THE ENGINE FROM THE "REAR" POSITION (AT THE ENGINE) FAILS TO PLACE THE SWITCH IN THE "OFF" OR "FRONT" POSITION AND THE ENGINE RPM WAS SET TO ABOVE IDLE DURING MAINTENANCE FOR EXAMPLE, WHEN THE BUS IS STARTED FROM THE DRIVER'S STATION THE ENGINE COULD CHANGE TO THE HIGHER RPM RESULTING IN UNWANTED ENGINE POWER.

Safety consequence

THE BUS COULD ACCELERATE AT A HIGHER RATE THAN ANTICIPATED INCREASING THE RISK OF A CRASH.

Manufacturer remedy

DAIMLER WILL PROVIDE INSTRUCTIONS TO MODIFY THE WIRING TO THE MORSE THROTTLE CONTROL SWITCH. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 1, 2010. OWNERS MAY CONTACT DAIMLER BUSES AT 1-800-716-7466.

Notes

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

EQUIPMENT ADAPTIVE/MOBILITY

NHTSA #09V412000

Reported October 20, 2009 · DAIMLER BUSES NORTH AMERICA, INC.

Potentially affected: 983 vehicles

Defect description

DAIMLER BUSES IS RECALLING CERTAIN MODEL YEAR 2000 THROUGH 2008 ORION TRANSIT BUSES EQUIPPED WITH LIFT-U WHEELCHAIR LIFTS. THE LIFTS ARE EQUIPPED WITH A LOGIC BOARD ASSEMBLY FOR THE WHEELCHAIR LIFT CONTROL BOX, P/NOS. 373-0226 AND 373-0265. THE OUTBOARD RAMP BARRIER COULD FOLD IN TOWARD A LIFT PASSENGER AND PINCH, PRESS, OR CRUSH THE PASSENGER'S FEET.

Safety consequence

THE LIFT PASSENGER COULD BE SERIOUSLY INJURED.

Manufacturer remedy

ORION WILL NOTIFY OWNERS AND THE REPAIRS WILL BE MADE BY LIFT-U FREE OF CHARGE. PLEASE SEE LIFT-U'S DEFECT REPORT 09E-051. THE SAFETY RECALL BEGAN ON OCTOBER 29, 2009. OWNERS MAY CONTACT LIFT-U AT 1-209-838-2400 OR ORION AT 1-800-716-7466.

Notes

INTERIOR LIGHTING

NHTSA #09V413000

Reported October 20, 2009 · DAIMLER BUSES NORTH AMERICA, INC.

Potentially affected: 368 vehicles

Defect description

DAIMLER BUSES OF NORTH AMERICA IS RECALLING CERTAIN MODEL YEAR 2002 THROUGH 2009 ORION TRANSIT BUSES EQUIPPED WITH LUMINATOR HORIZON LED SIDE DESTINATION SIGNS. THE CONNECTOR BOARD CAN CORRODE DUE TO AN ACCUMULATION OF MOISTURE UNDER THE CONNECTOR.

Safety consequence

A SHORT COULD OCCUR, POSSIBLY CAUSING SMOKE AND A FIRE.

Manufacturer remedy

ORION WILL NOTIFY OWNERS AND THE BUSES WILL BE REPAIRED BY LUMINATOR FREE OF CHARGE. PLEASE SEE LUMINATOR'S DEFECT REPORT 09E-054. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2009. OWNERS MAY CONTACT LUMINATOR AT 1-972-516-3033 OR ORION AT 1-800-716-7466.

Notes

Other Orion V model years

Check your 2005 Orion V VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Orion V at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check an Orion VIN