NHTSA vehicle safety data

2001 Nissan Xterra Recalls, Ratings & Complaints

The 2001 Nissan Xterra has 5 NHTSA recall campaigns and 150 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Nissan dealer.

NHTSA recall and complaint data for the 2001 Nissan Xterra, plus NCAP crash-test ratings. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2001 Nissan Xterra owner complaints

Owners have filed 150 complaints with NHTSA about the 2001 Nissan Xterra, describing incidents dated November 15, 2000 to May 4, 2022.

Most-cited components

Visibility/Wiper 43 complaints
Fuel/Propulsion System 32 complaints
Electrical System 17 complaints
Engine 17 complaints
Wheels 11 complaints
Service Brakes 9 complaints

Of the 150 complaints on file, 15 report a crash and 5 a fire; across all 150 complaints, owners report 11 injuries (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11468769 · Filed June 11, 2022
The vehicle disabled and the steering wheel locked on the highway once the speed hit 70mph. The wheel bearings are always rattling and if I go through a pothole the steering and tire feel really loose. The brake system doesn't feel right and has made a loud metal grind sound. The exhaust and or…
ODI #11405499 · Filed March 30, 2021
THE XTERRA STARTED MISSING AND HESITATING (ENGINE) EVENTUALLY DYING AND NOT RESTARTING. THE MISSING AND HESITATION OCCURRED WHILE UNDERWAY ON A BUSY 4 LANE DIVIDED HIGHWAY, BUT THANKFULLY MADE IT HOME BEFORE DYING AND NOT RESTARTING. MISSING AND HESITATION OCCURRED WHILE TRAVELING STRAIGHT ON AND…
ODI #11217267 · Filed June 1, 2019
CAR FAILED TO START AFTER BEING PARKED OVERNIGHT. WOULD CRANK BUT NOT START. HAD IT DIAGNOSED AND THE FUEL SENDING UNIT REPLACED. THE DEAD UNIT HAD A HOLE THROUGH IT'S PLASTIC WHICH SHOWED A CORRODED ELECTRICAL TAB. IT DOESN'T LOOK LIKE CORROSION FROM A CRACK IN THE PLASTIC AS STATED IN CAMPAIGN#…

Read all 150 complaints

NHTSA defect investigations

NHTSA's investigations file lists the 2001 Nissan Xterra in 2 investigations. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Defect Petition DP03-005: BRAKE ROTOR WARPAGE
Closed July 29, 2003
Preliminary Evaluation PE02-052: FUEL SPILL DURING REFUELING
Closed December 3, 2002
- Recall 02V-300

Open and recently closed NHTSA defect investigations

FMVSS 108/AFTERMARKET COMBINATION LAMPS

NHTSA #09E012000 · Exterior Lighting · NHTSA notice

Reported April 7, 2009 · SABERSPORT

Potentially affected: 16,270 vehicles

Owners notified May 11, 2009

Defect description

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Safety consequence

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Manufacturer remedy

SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

FMVSS 108/AMBER SIDE REFLEX REFLECTORS

NHTSA #06E026000 · Exterior Lighting · NHTSA notice

Reported March 23, 2006 · PRO-A MOTORS, INC.

Potentially affected: 61,944 vehicles

Owners notified April 3, 2006

Defect description

CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Safety consequence

WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Manufacturer remedy

PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.

Notes

THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

NISSAN/FUEL SENDING UNIT

NHTSA #04V230000 · Fuel System, Gasoline — Delivery — Fuel Pump · NHTSA notice

Reported May 24, 2004 · NISSAN NORTH AMERICA, INC.

Potentially affected: 586,196 vehicles

Owners notified June 28, 2004 · Vehicles built March 4, 1999 – March 15, 2003 (per NHTSA)

Defect description

ON CERTAIN PICKUP TRUCKS EQUIPPED WITH SIX CYLINDER ENGINES AND SPORT UTILITY VEHICLES EQUIPPED WITH FOUR OR SIX CYLINDER ENGINES, THE FUEL PUMP TERMINAL ON THE FUEL-SENDING UNIT CAN DEVELOP A CRACK IN THE PLASTIC MOLDING. THIS CAN CAUSE THE TERMINAL STRIP TO CORRODE UNDER SOME ENVIRONMENTAL CONDITIONS.

Safety consequence

IF CORROSION OCCURS, THE TERMINAL STRIP COULD EVENTUALLY BREAK CAUSING THE FUEL PUMP TO STOP OPERATION. THIS WILL RESULT IN NOT BEING ABLE TO START THE ENGINE OR CAUSE THE ENGINE TO STOP RUNNING WITHOUT WARNING, WHICH CAN RESULT IN A CRASH.

Manufacturer remedy

IN THE FOLLOWING STATES, DEALERS WILL REPLACE THE FUEL-SENDING UNIT. THESE STATES ARE CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, TENNESSEE, VERMONT, VIRGINIA, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. IN THE OTHER STATES, THE DEALER WILL INSPECT THE FUEL PUMP TERMINAL ON THE SENDING UNIT FOR CORROSION. IF CORROSION IS PRESENT, THE DEALER WILL REPLACE THE UNIT. IF THERE IS NOT CORROSION, THE DEALER WILL APPLY SEALANT TO THE TERMINAL HOUSING TO HELP PREVENT CORROSION IN THE FUTURE. OWNER NOTIFICATION BEGAN ON JUNE 28, 2004. OWNERS SHOULD CONTACT NISSAN AT 1-800-647-7261.

Notes

CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

NISSAN/FUEL FILLER INLET

NHTSA #02V300000 · Fuel System, Gasoline — Storage — Tank Assembly — Filler Pipe and Cap · NHTSA notice

Reported November 12, 2002 · NISSAN NORTH AMERICA, INC.

Potentially affected: 44,000 vehicles

Nissan campaign R2020 · Owners notified December 10, 2002 · Vehicles built October 29, 2000 – January 13, 2001 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE FUEL TANK INLET SHUTTER VALVE DOES NOT MEET THE SEALING PERFORMANCE SPECIFICATION.

Safety consequence

UNDER CERTAIN CONDITIONS SUCH AS HIGH AMBIENT TEMPERATURE AND WHEN WINTER GRADE GASOLINE IS BEING SOLD, FUEL COULD SPILL FROM THE FILLER INLET AS THE TANK IS BEING FILLED. IN THE PRESENCE OF AN IGNITION SOURCE, FUEL LEAKAGE COULD RESULT IN A FIRE.

Manufacturer remedy

DEALERS WILL REPLACE THE FUEL TANK INLET SHUTTER VALVE. OWNER NOTIFICATION IS EXPECTED TO BEGIN DECEMBER 10, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NISSAN AT 1-800-647-7261.

Notes

ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

NISSAN/AXLE CORROSION

NHTSA #02V299000 · Suspension — Rear · NHTSA notice

Reported November 12, 2002 · NISSAN NORTH AMERICA, INC.

Potentially affected: 143,000 vehicles

Nissan campaign R2019 · Owners notified December 10, 2003 · Vehicles built July 15, 2000 – September 22, 2002 (per NHTSA)

Defect description

ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, WATER MAY ENTER THE REAR AXLE HOUSING DUE TO INADEQUATE SEALING OF THE ANTI-LOCK BRAKING SYSTEM (ABS) SENSOR.

Safety consequence

THIS CAN RESULT IN CORROSION AND EVENTUAL FAILURE OF THE WHEEL BEARING. IF THIS OCCURS, THE WHEEL ASSEMBLY COULD SEPARATE FROM THE VEHICLE INCREASING THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL INSPECT THE REAR AXLE FOR WATER INTRUSION AND ANY AFFECTED COMPONENTS WILL BE REPLACED. THE ABS SENSOR WILL BE RESEALED TO PREVENT WATER INTRUSION. OWNER NOTIFICATION BEGAN DECEMBER 10, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NISSAN AT 1-800-647-7261.

Notes

ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

2001 Nissan Xterra 4-DR.

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 4, Passenger: 4

Side Crash

Not Rated

Driver: 4, Passenger: 5

Side Pole

Not Rated

Rollover

Safety Technology

2 investigations

150 owner complaints have been filed with NHTSA for the 2001 Nissan Xterra.

Suspension; Service Brakes; Fuel/Propulsion System

ODI #11468769

Incident: May 4, 2022 · Filed: June 11, 2022

The vehicle disabled and the steering wheel locked on the highway once the speed hit 70mph. The wheel bearings are always rattling and if I go through a pothole the steering and tire feel really loose. The brake system doesn't feel right and has made a loud metal grind sound. The exhaust and or gasoline smell is way potent and not normal either it is strong smelling all the time. Potential recalls with fuel system, gasoline delivery, fuel pump and suspension, REAR , gasoline storage , tank assembly, filler pipe and cap. All are potential recalls also the exterior lighting

Power Train; Engine; Fuel/Propulsion System

ODI #11405499

Incident: March 19, 2021 · Filed: March 30, 2021

THE XTERRA STARTED MISSING AND HESITATING (ENGINE) EVENTUALLY DYING AND NOT RESTARTING. THE MISSING AND HESITATION OCCURRED WHILE UNDERWAY ON A BUSY 4 LANE DIVIDED HIGHWAY, BUT THANKFULLY MADE IT HOME BEFORE DYING AND NOT RESTARTING. MISSING AND HESITATION OCCURRED WHILE TRAVELING STRAIGHT ON AND WHILE STOPPED AT RED LIGHTS.

Electrical System; Fuel/Propulsion System

ODI #11217267

Incident: May 20, 2019 · Filed: June 1, 2019

CAR FAILED TO START AFTER BEING PARKED OVERNIGHT. WOULD CRANK BUT NOT START. HAD IT DIAGNOSED AND THE FUEL SENDING UNIT REPLACED. THE DEAD UNIT HAD A HOLE THROUGH IT'S PLASTIC WHICH SHOWED A CORRODED ELECTRICAL TAB. IT DOESN'T LOOK LIKE CORROSION FROM A CRACK IN THE PLASTIC AS STATED IN CAMPAIGN# 04V230000, BUT MORE LIKE THE ELECTRICAL CONNECTION MELTED THROUGH THE PLASTIC, WHICH THEN ALLOWED CORROSION. NISSAN HOTLINE TOLD ME THAT THE PREVIOUS OWNER HAD THE RECALL TAKEN CARE OF ALREADY, BUT COULDN'T SAY IF THE UNIT WAS REPAIRED OR REPLACED.

Power Train; Engine

ODI #11144792

Incident: October 19, 2018 · Filed: November 1, 2018

WHILE DRIVING, ENGINE GOES TO IDLE MODE AND CAN'T ACCELERATE. I HAVE TO SHIFT TO NEUTRAL AND BACK TO DRIVE TO AGAIN DRIVE NORMALLY, THEN PROBLEM HAPPENS AGAIN AND HAVE TO DO THE SAME CONTINUOUSLY EVERY FEW MILES WHILE DRIVING.

Air Bags

ODI #10954048

Crash 1 injury

Incident: February 9, 2017 · Filed: February 11, 2017

MAJOR INTRUSION ON FRONT END AFTER A MOTOR VEHICLE ACCIDENT WITHOUT AIR BAG DEPLOYMENT. THIS OCCURRED ON THE HIGHWAY AFTER SLIDING ON ICE AND BEING HIT HEAD ON BY A FORD F150.

Fuel/Propulsion System

ODI #10896852

Incident: August 12, 2016 · Filed: August 18, 2016

THE TERMINAL STRIP ARE CORRODE AND CAN'T BE REPLACED BECAUSE THE PUMP GOT DAMAGE BY THE CORROSION OF THE TERMINAL, NOW NISSAN DO NOT WANT TO REPLACE THE PUMP. IS NOT MY FAULT THAT THEY USING PARTS THAT CAUSING THOSE TYPE OF PROBLEM. I CAN'T AFFORT TO PAY FOR THE PUMP PLUS LABOR.

Suspension; Fuel/Propulsion System

ODI #10743271

Incident: November 12, 2002 · Filed: July 24, 2015

TL* THE CONTACT OWNS A 2001 NISSAN XTERRA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 04V230000 (FUEL SYSTEM, GASOLINE) AND 02V299000 (SUSPENSION). THE MANUFACTURER STATED THAT THE PART TO DO THE REPAIR WAS AVAILABLE; HOWEVER, WHEN THE CONTACT TOOK THE VEHICLE TO THE DEALER FOR THE RECALL REPAIR, THE DEALER STATED THAT THE PART TO DO THE RECALL REPAIR WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME TO PROVIDE THE PART TO DO THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED. THE VEHICLE EXPERIENCED THE FAILURE LISTED IN THE RECALL. THE APPROXIMATE FAILURE MILEAGE WAS 108,000.

Electrical System; Fuel/Propulsion System

ODI #10715043

Incident: May 4, 2015 · Filed: May 6, 2015

I JUST PURCHASED THIS CAR ABOUT 3 MONTHS AGO AND PAID 4000 DOLLARS FOR IT. THE VEHICLE STOPPED WORKING AND THE FUEL PUMP WASN'T COMING ON. AFTER SEARCHING FOR THE POWER ISSUE I DISCOVERED THE FUEL TANK SENDING UNIT WHICH IS THE TOP TO THE GAS TANK ITSELF. MEANING THE SERVICE HOLE OF THE TANK ACCESS IS THE TOP PART OF THE SENDING UNIT. THE SENDING UNIT HAS 4 FUEL LINE CONNECTIONS AND 4 ELECTRICAL CONNECTIONS. TWO FUEL CONECTIONS AND 2 ELECTRICAL CONNECTIONS PLUG INTO THE TOP SIDE OF THE SENDING UNIT AND THEY ROUTE THROUGH THE PLASTIC MOLDED SENDING UNIT AND CONNECTIONS ARE MADE IN THE BOTTOM SIDE. BASICALLY FUEL AND ELECTRICITY ROUTE THROUGH THIS UNIT INTO THE TANK. THE POWER WIRE TO THE FUEL PUMP BURNED AND MELTED THE CONECTION INSIDE THE MOLD AND BURNED THE PLASTIC ALL AROUND THE CONNECTION PLUG WHERE THE POWER GOES TO THE GAS TANK. FROM WHAT I UNDERSTAND THE 00' AND 02' SENDING UNITS WERE RECALLED BUT NOT MY 01'. THIS IS THE EQUIVALENT TO RIDING DOWN THE ROAD WITH A TICKING TIME BOMB UNDER MY CHILDREN'S SEATS. I HAVE CONTACTED NISSAN BUT I HAVE GOTTEN NOWHERE WITH THEM SO I AM REACHING OUT TO THE TRANSPORTATION SAFTEY AUTHORITIES. *TR

Wheels; Engine; Fuel/Propulsion System

ODI #10644150

Incident: May 2, 2014 · Filed: October 12, 2014

AFTER THE CAR WARMS UP IT WILL STALL WHILE DRIVING AND WHEN COMING TO A STOP TO IDLE.SOMETIMES IT WILL NOT START IMMEDIATELY AFTER STALLING. THIS IS A SAFETY HAZARD AND COULD CAUSE AN ACCIDENT. WE HAVE ALSO HAD MULTIPLE PROBLEMS WITH THE ALIGNMENT DUE TO THE WHEEL BEARINGS. *TR

Wheels

ODI #10641367

Crash

Incident: September 28, 2014 · Filed: October 4, 2014

WHILE DRIVING ON THE MASS TURNPIKE, THE FRONT WHEEL CAME OFF THE CAR. THIS IS THE SECOND TIME. FIRST TIME, IN 2013, IN SCHOOL PARKING LOT, DIFFERENT SIDE BUT ALSO A FRONT WHEEL. WE BOUGHT THE CAR USED FROM A NISSAN DEALERSHIP IN AUGUST 2012 FOR MY 19 YEAR OLD SON. THE CAR IS HARDLY DRIVEN AS HE IS AWAY IN COLLEGE. THIS CAR HAS BEEN SERVICED SEVERAL TIMES FOR VARIOUS OTHER THINGS AND TWO DIFFERENT FRONT WHEELS JUST COMING OFF CAN NOT BE A MATTER OF LOOSE LUG NUTS AND INCOMPETENCE ON THE PART OF THE REPAIR SHOP. I FEEL THAT SOMETHING MUST BE FUNDAMENTALLY WRONG OR FAULTY. I SEE THAT THERE WERE RECALLS YEARS AGO HAVING TO DO WITH BALL JOINTS IN THIS MODEL, I CAN NOT TELL FROM CARFAX REPORTS WHETHER THIS VIN WAS EVER SERVICED FOR THAT, AND THAT NISSAN NEVER SHOULD HAVE RESOLD THIS CAR WITHOUT CHECKING TO SEE - DESPITE THE FACT THAT THIS IS AN OLDER CAR. A WHEEL COMING OFF IS DANGEROUS, ESPECIALLY WHILE DRIVING AT HIGHWAY SPEEDS. MY SON COULD HAVE BEEN KILLED (LUCKILY NO ONE WAS HURT). I AM TRYING TO FIND OUT WHETHER THIS CAR WAS EVER CHECKED FOR THE RECALL ON BALL JOINTS IN 2003 OR EVER. DOESN'T THE DEALERSHIP HAVE ANY OBLIGATION TO CHECK SAFETY RECALLS BEFORE RESELLING CARS THAT COULD BE DANGEROUS TO DRIVE? I FEEL THAT WE WERE SOLD A USED CAR THAT WAS FUNDAMENTALLY NOT SAFE. TWO DIFFERENT WHEELS FALL OFF WITHIN 2 YEARS OF PURCHASE - SOMETHING DOESN'T SEEM LEGITIMATE HERE. *TR

Other Nissan Xterra model years

Check your 2001 Nissan Xterra VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Nissan Xterra at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Nissan VIN