NHTSA vehicle safety data

2004 Keystone Outback Recalls & Complaints

The 2004 Keystone Outback has 2 NHTSA recall campaigns and 3 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Keystone dealer.

NHTSA recall and complaint data for the 2004 Keystone Outback. Recall data is refreshed daily from NHTSA.

2004 Keystone Outback owner complaints

Owners have filed 3 complaints with NHTSA about the 2004 Keystone Outback, describing incidents dated May 19, 2006 to July 6, 2008.

Most-cited components

Suspension 2 complaints
Tires 1 complaint
Wheels 1 complaint

Of the 3 complaints on file, 1 reports a crash (owner-reported, not verified by NHTSA).

Newest complaints

ODI #10235798 · Filed July 25, 2008
WE WERE PULLING OUR 29 FT. TRAVEL TRAILER NORTH ON HWY 75 NEAR JASPER, FL., WHEN SUDDENLY IT STARTED TO FISHTAIL. WE TRIED TO CONTROL THE SWAYING, BUT IT INCREASED UNTIL THE CAMPER WAS MOVING OUR CAR AND CARRIED US OFF THE ROAD. THE CAMPER COMPLETELY COLLAPSED EVEN THOUGH WE DID NOT ROLL. WE WERE…
ODI #10204869 · Filed September 24, 2007
TL*THE CONTACT OWNS A 2004 KEYSTONE OUTBACK RV. THE TIRE BRAND IS DURO, HWA-FONG RUBBER INDUSTRIAL COMPANY LTD IS THE MANUFACTURER. THE TIRE SIZE WAS T115/70D15. 25RSS IS THE MODEL NUMBER. THE RV DOESN'T HAVE A MOTOR. THE CONTACT OBSERVED THAT THE TREAD IS SEPARATING ON ALL 4 OF HIS TIRES, THE FRONT…
ODI #10158231 · Filed May 24, 2006
I PURCHASED AN OUTBACK TRAILER FROM KEYSTONE RV IN 2004 AND IT CURRENTLY HAS 3000 MILES ON IT. I RECENTLY NOTICED THAT THE TIRES ON THE DRIVER SIDE HAVE STARTED TO CRACK, AND DURING THE TIRE REPLACEMENT THE MECHANIC NOTICED THAT THE HUBS ARE LOOSE ON BOTH AXLES ON THE DRIVER SIDE. I THEN TOOK THE…

Read all 3 complaints

NHTSA defect investigations

NHTSA's investigations file lists the 2004 Keystone Outback in 1 investigation. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Engineering Analysis EA04-032: WHEEL SEPARATIONS
Closed December 30, 2005
- Recall 05V-309

Open and recently closed NHTSA defect investigations

Fire Extinguisher May Be Clogged or Inoperable

NHTSA #17V755000 · Equipment · NHTSA notice

Reported November 22, 2017 · Keystone RV Company

Potentially affected: 1,205,997 vehicles

Repair completion: 2.15% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Keystone campaign 17-307 · Owners notified January 15, 2018

Defect description

Keystone RV Company (Keystone) is recalling various 2003-2018 Crossroads, Dutchmen, and Keystone recreational trailers equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. A list of the affected trailer models is available at: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17V755-5127.pdf. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

Safety consequence

In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.

Manufacturer remedy

Keystone will notify owners and instruct them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began on January 15, 2018. Owners may contact Keystone customer service at 1-574-535-2100, or Kidde customer service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information. Keystone's number for this recall is 17-307.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

REFRIGERATOR/DOMETIC

NHTSA #08V325000 · Equipment — Recreational Vehicle/Trailer · NHTSA notice

Reported July 17, 2008 · KEYSTONE RV COMPANY

Potentially affected: 161,250 vehicles

Keystone campaign 08-111 · Owners notified September 30, 2008 · Vehicles built June 1, 2003 – April 30, 2007 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

KEYSTONE IS RECALLING 161,250 MY 2004-2007 FIFTH WHEEL AND TRAVEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATOR MANUFACTURED BY THE DOMETIC CORPORATION. THE REFRIGERATOR MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

Safety consequence

IF THIS SOLUTION IS EXPOSED TO AN IGNITION SOURCE UNDER CERTAIN SPECIFIC CIRCUMSTANCES, IT CAN RESULT IN A VEHICLE FIRE.

Manufacturer remedy

KEYSTONE IS WORKING WITH DOMETIC TO REPAIR THESE REFRIGERATORS (PLEASE SEE 08E032). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST THE OWNER IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR KEYSTONE AT 1-866-425-4369.

Notes

KEYSTONE RECALL NO. 08-111.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

try.vin has no NCAP crash-test rating on file for the 2004 Keystone Outback. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

3 owner complaints have been filed with NHTSA for the 2004 Keystone Outback.

Suspension

ODI #10235798

Crash

Incident: July 6, 2008 · Filed: July 25, 2008

WE WERE PULLING OUR 29 FT. TRAVEL TRAILER NORTH ON HWY 75 NEAR JASPER, FL., WHEN SUDDENLY IT STARTED TO FISHTAIL. WE TRIED TO CONTROL THE SWAYING, BUT IT INCREASED UNTIL THE CAMPER WAS MOVING OUR CAR AND CARRIED US OFF THE ROAD. THE CAMPER COMPLETELY COLLAPSED EVEN THOUGH WE DID NOT ROLL. WE WERE TRAVELING ON A STRAIGHT ROAD AND DID NOT MAKE ANY LANE CHANGES OR SUDDEN MOVES TO START THE SWAYING. IT JUST STARTED AND INCREASED. WE BELIEVE THE AXLE BROKE OR SWAY BAR. THE DESIGN OF THIS CAMPER ADDED TO THE INCREASED SWAY AND PROBABLY LED TO THE COLLAPSING. *TR

Tires

ODI #10204869

Incident: September 4, 2007 · Filed: September 24, 2007

TL*THE CONTACT OWNS A 2004 KEYSTONE OUTBACK RV. THE TIRE BRAND IS DURO, HWA-FONG RUBBER INDUSTRIAL COMPANY LTD IS THE MANUFACTURER. THE TIRE SIZE WAS T115/70D15. 25RSS IS THE MODEL NUMBER. THE RV DOESN'T HAVE A MOTOR. THE CONTACT OBSERVED THAT THE TREAD IS SEPARATING ON ALL 4 OF HIS TIRES, THE FRONT PASSENGER AND DRIVER AND THE REAR DRIVER AND PASSENGER TIRES. THE ESTIMATED COST TO REPLACE THEM IS $300 PER TIRE. THESE ARE THE ORIGINAL TIRES WHEN THE RV WAS PURCHASED. THE DEALER ADVISED THE OWNER TO SPEAK WITH THE TIRE MANUFACTURER. THE MANUFACTURER ADVISED HIM TO EMAIL PHOTOS OF THE TIRES AND THEY WOULD COMPENSATE HIM FOR HALF OF THE COST. THE CONTACT WANTS THE MANUFACTURER TO REIMBURSE HIM FOR 4 NEW TIRES, INCLUDING THE SPARE. THE CURRENT APPROXIMATE TIRE MILEAGE WAS 850 AND THE FAILURE MILEAGE WAS 450. UPDATED 10.09.07. *JB

Suspension; Wheels

ODI #10158231

Incident: May 19, 2006 · Filed: May 24, 2006

I PURCHASED AN OUTBACK TRAILER FROM KEYSTONE RV IN 2004 AND IT CURRENTLY HAS 3000 MILES ON IT. I RECENTLY NOTICED THAT THE TIRES ON THE DRIVER SIDE HAVE STARTED TO CRACK, AND DURING THE TIRE REPLACEMENT THE MECHANIC NOTICED THAT THE HUBS ARE LOOSE ON BOTH AXLES ON THE DRIVER SIDE. I THEN TOOK THE TRAILER TO GENERAL RV IN MOUNT CLEMENS, MICHIGAN FOR REPAIR AND THEY CONFIRMED THAT THE HUBS ARE BOTH LOOSE DUE TO A LACK OF COTTER PINS THAT HOLD THE CASTLE NUT ON TO THE TRAILER ON BOTH HUBS. THE HUBS HAVE NEVER BEEN SERVICED BY REMOVAL ONLY BY ADDING GREASE THROUGH THE ZERK FITTINGS. THE DEALERS MECHANIC COULD NOT FIND ANY INDICATION OF THE COTTER PINS INSIDE THE HUBS. SO, ONE CAN ONLY ASSUME THAT THEY DID NOT EVER ADD THE COTTER PINS TO THE ASSEMBLY. THE CASTLE NUT HAD VIBRATED NEARLY OFF THE SPINDLE ON BOTH WHEELS ON THE DRIVER SIDE. THE TRAILER HAS DUAL AXLES FROM AL-KO KOBER CORPORATION. I TEND TO BELIEVE THAT THIS COULD LEAD TO SERIOUS COMPLICATIONS ON THE ROAD, AND SHOULD BE INVESTIGATED FURTHER. THANK YOU FOR YOUR TIME JEFFERY K PLAMP. *JB

Other Keystone Outback model years

Check your 2004 Keystone Outback VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Keystone Outback at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Keystone VIN