NHTSA vehicle safety data

2006 Itasca Sunova Recalls & Complaints

The 2006 Itasca Sunova has 7 NHTSA recall campaigns and 2 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Itasca dealer.

NHTSA recall and complaint data for the 2006 Itasca Sunova. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2006 Itasca Sunova owner complaints

Owners have filed 2 complaints with NHTSA about the 2006 Itasca Sunova, describing incidents dated December 3, 2008 to November 15, 2014.

Most-cited components

Structure 1 complaint
Tires 1 complaint

Newest complaints

ODI #10659757 · Filed November 20, 2014
WHILE DRIVING NORTH ON I-15 BETWEEN HESPERIA AND BARSTOW, CALIFORNIA, THE FIBERGLASS SKIN ON THE ROOF OF OUR RV STARTED BLOWING OFF. BY THE TIME WE WERE ABLE TO SAFELY PULL TO THE SIDE OF THE FREEWAY, 80% OF THE ROOF SKIN HAD SEPARATED FROM THE FRAME AND LARGE PARTS WERE FLYING THROUGH THE AIR…
ODI #10290819 · Filed November 3, 2009
TL* THE CONTACT OWNS A 2006 ITASCA SUNOVA RV WITH GOODYEAR TIRES DOT# MJ93-MAHW, SIZE 245/70/ R19. WHILE DRIVING 50 MPH SHE HEARD A PECULIAR NOISE FROM THE REAR END OF THE VEHICLE. UPON VEHICLE INSPECTION SHE NOTICED THAT THE INSIDE OF DRIVER-SIDE REAR TIRE HAD EXPLODED. THE TIRE WAS TAKEN TO A…

Read all 2 complaints

NHTSA defect investigations

NHTSA's investigations file lists the 2006 Itasca Sunova in 1 investigation. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Preliminary Evaluation PE10-048: Hitch Receiver Fracture
Closed December 3, 2013

Open and recently closed NHTSA defect investigations

REFRIGERATORS/POSSIBLE FIRE/NORCOLD

NHTSA #10V525000 · Equipment · NHTSA notice

Reported October 26, 2010 · WINNEBAGO INDUSTRIES, INC.

Potentially affected: 18,461 vehicles

Owners notified December 15, 2010

Defect description

WINNEBAGO IS RECALLING CERTAIN RECREATIONAL VEHICLES EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWER ARE NOT SUFFICIENT.

Safety consequence

THE SENSING ALGORITHM OR THERMAL SWITCH INSTALLED TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED DUE TO A POSSIBLE HYDROGEN GAS LEAK MAY NOT SHUT OFF IN SUFFICIENT TIME TO PREVENT A FIRE.

Manufacturer remedy

WINNEBAGO IS WORKING WITH NORCOLD TO IDENTIFY AND NOTIFY ANY AFFECTED OWNERS. OWNERS WILL BE INSTRUCTED TO CONTACT NORCOLD DEALERS TO RECEIVE THE REMEDY FREE OF CHARGE. PLEASE SEE NORCOLD'S DEFECT REPORT 10E-049 FOR ADDITIONAL INFORMATION. THE RECALL BEGAN DURING DECEMBER 2010. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101 OR WINNEBAGO AT 1-641-585-3535.

Notes

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

DINETTE AREA SEAT BELTS/FMVSS 210

NHTSA #10V467000 · Seat Belts · NHTSA notice

Reported October 5, 2010 · WINNEBAGO INDUSTRIES, INC.

Potentially affected: 1,925 vehicles

Manufacturer campaign 119 · Owners notified December 10, 2010 · Vehicles built January 23, 2004 – July 10, 2009 (per NHTSA)

Defect description

WINNEBAGO IS RECALLING CERTAIN MODEL YEAR 2005 THROUGH 2009 WINNEBAGO SIGHTSEER AND ITASCA SUNOVA MOTOR HOMES BECAUSE THE DINETTE AREA SEAT BELT RESTRAINTS ON THOSE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES." IN A COLLISION, THE GENERATED CRASH FORCES CAN CAUSE THE RESTRAINT'S ATTACHMENT TO TEAR AND ALLOW THE ANCHOR TO SEPARATE FROM THE BODY OF THE VEHICLE.

Safety consequence

IF THE RESTRAINT SEPARATES FROM THE VEHICLE DURING A CRASH, THE BELT WILL NOT PROPERLY RESTRAIN THE SEAT OCCUPANT, INCREASING THE RISK OF INJURY OR DEATH TO THE OCCUPANT.

Manufacturer remedy

WINNEBAGO WILL NOTIFY OWNERS A DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 10, 2010. OWNERS MAY CONTACT WINNEBAGO AT 1-800-537-1885.

Notes

WINNEBAGO SAFETY RECALL NO. 119.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

STEERING ARM CASTLE NUT/WORKHORSE

NHTSA #08V571000 · Steering — Gear Box — Shaft Pitman · NHTSA notice

Reported October 29, 2008 · WINNEBAGO INDUSTRIES, INC.

Potentially affected: 717 vehicles

Owners notified September 9, 2008 · Vehicles built May 1, 2005 – October 16, 2007 (per NHTSA)

Defect description

WINNEBAGO IS RECALLING 717 MY 2006-2009 SIGHTSEER AND VISTA, ITASCA SUNOVA AND SUNSTAR MOTOR HOMES BUILT ON WORKHORSE CHASSIS. THE CASTLE NUT THAT RETAINS THE STEERING DRAG LINK TO THE PITMAN ARM MAY HAVE BEEN IMPROPERLY TORQUED DURING ASSEMBLY. THE IMPROPER TORQUE MAY HAVE DAMAGED THE CASTLE NUT AND COMPROMISED THE INTEGRITY OF THE CONNECTION.

Safety consequence

IF THE DRAG LINK WERE TO SEPARATE FROM THE PITMAN ARM, THE DRIVER WOULD NOT HAVE DIRECTIONAL CONTROL OF THE VEHICLE POSSIBLY CAUSING A CRASH.

Manufacturer remedy

WINNEBAGO IS WORKING WITH WORKHORSE TO REPLACE AND PROPERLY TIGHTEN THE CASTLE NUT THAT RETAINS THE STEERING DRAG LINK TO THE PITMAN ARM (PLEASE SEE 08V442). OWNERS MAY CONTACT WORKHORSE AT 1-877-946-7731 OR WINNEBAGO AT 1-641-585-3535.

Notes

CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

STEERING IMMEDIATE SHAFT/WORKHORSE

NHTSA #06V250000 · Steering · NHTSA notice

Reported July 5, 2006 · WINNEBAGO INDUSTRIES, INC.

Potentially affected: 1,021 vehicles

Vehicles built June 1, 2005 – June 30, 2006 (per NHTSA)

Defect description

CERTAIN MOTOR HOMES BUILT ON WORKHORSE CHASSIS MAY HAVE BEEN EQUIPPED WITH INCORRECT STEERING INTERMEDIATE SHAFTS. THE STEERING COULD BECOME LOOSE AT THE STEERING BOX DURING TIGHT STEERING MANEUVERS.

Safety consequence

THIS STEERING CONDITION COULD RESULT IN A LOSS OF STEERING CONTROL, INCREASING THE RISK OF A CRASH.

Manufacturer remedy

WORKHORSE IS CONDUCTING THIS RECALL (PLEASE SEE 06V148000) AND WILL INSPECT AND, IF NECESSARY, REPLACE THE STEERING INTERMEDIATE SHAFT. OWNERS MAY CONTACT WORKHORSE AT 1-877-294-6883 OR WINNEBAGO AT 1-641-585-3535.

Notes

CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

RANGE CABINET PARTITION

NHTSA #06V163000 · Equipment — Recreational Vehicle/Trailer · NHTSA notice

Reported May 16, 2006 · WINNEBAGO INDUSTRIES, INC.

Potentially affected: 68 vehicles

Manufacturer campaign 101 · Owners notified May 19, 2006 · Vehicles built September 7, 2005 – April 25, 2006 (per NHTSA)

Defect description

ON CERTAIN MOTOR HOMES, THE FLAME ON THE COOKING RANGE MAY BE FORCED DOWNWARD OVER THE BURNER OR FLAME OUTAGE MAY OCCUR WHEN THE COOKING RANGE AND FURNACE ARE OPERATED AT THE SAME TIME. THIS CONDITION IS DUE TO THE POSSIBILITY OF A MISSING CABINET PANEL THAT ISOLATES THE FURNACE RETURN AIR.

Safety consequence

IF THE FURNACE IS OPERATED AT THE SAME TIME AS THE STOVE AND THE CABINET PANEL IS MISSING, THE STOVE FLAME MAY GO OUT AND THE PROPANE GAS WILL CONTINUE TO FLOW, WHICH HAS THE POTENTIAL TO IGNITE RESULTING IN PERSONAL INJURY OR VEHICLE AND PROPERTY DAMAGE.

Manufacturer remedy

DEALERS WILL INSPECT THE CABINET ASSEMBLY FOR A CABINET PANEL AND INSTALL ONE IF NECESSARY FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON JUNE 2, 2006. OWNERS MAY CONTACT WINNEBAGO AT 641-585-6939.

Notes

WINNEBAGO RECALL NO. 101.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

ENTRANCE STEPS/KWIKEE

NHTSA #05V573000 · Structure — Body · NHTSA notice

Reported December 28, 2005 · WINNEBAGO INDUSTRIES, INC.

Potentially affected: 193 vehicles

Manufacturer campaign 100 · Owners notified December 23, 2005 · Vehicles built November 14, 2005 – December 8, 2005 (per NHTSA)

Defect description

ON CERTAIN MOTOR HOMES EQUIPPED WITH KWIKEE BRAND ELECTRIC STEPS, THE STEPS MAY HAVE BEEN MANUFACTURED WITH DEFECTIVE STEP CONTROL UNITS.

Safety consequence

THE DEFECTIVE CONTROL UNITS COULD DEVELOP AN ELECTRICAL SHORT ALLOWING FOR THE POTENTIAL OF THE PLASTIC CASE TO IGNITE, POSSIBLY RESULTING IN PERSONAL INJURY AND/OR VEHICLE AND PROPERTY DAMAGE.

Manufacturer remedy

DEALERS WILL INSPECT THE KWIKEE STEP AND REPLACE THE STEP CONTROL UNIT, IF NECESSARY, FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 23, 2005. OWNERS MAY CONTACT WINNEBAGO AT 1-800-537-1885.

Notes

WINNEBAGO RECALL NO. 100. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

GALLEY COUNTERTOP KNIFE SHIELD

NHTSA #05V532000 · Equipment — Recreational Vehicle/Trailer — LPG Systems — Lines and Fittings · NHTSA notice

Reported November 9, 2005 · WINNEBAGO INDUSTRIES, INC.

Potentially affected: 342 vehicles

Manufacturer campaign 99 · Owners notified November 11, 2005 · Vehicles built February 8, 2005 – September 15, 2005 (per NHTSA)

Defect description

ON CERTAIN MOTOR HOMES WITH THE OPTIONAL GALLEY UPGRADE PACKAGE, KNIVES STORED IN THE GALLEY KNIFE HOLDER MAY INTERFERE WITH THE PROPANE GAS LINE TO THE STOVE.

Safety consequence

THE KNIVES COULD DAMAGE THE PROPANE GAS LINE ALLOWING PROPANE GAS TO ESCAPE, WHICH HAS THE POTENTIAL TO IGNITE, RESULTING IN PERSONAL INJURY OR VEHICLE PROPERTY DAMAGE.

Manufacturer remedy

DEALERS WILL PROPERLY ROUTE THE PROPANE GAS LINE AND INSTALL A KNIFE SHIELD. THE RECALL BEGAN ON NOVEMBER 11, 2005. OWNERS MAY CONTACT WINNEBAGO AT 641-585-6939.

Notes

WINNEBAGO RECALL NO. 99.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

try.vin has no NCAP crash-test rating on file for the 2006 Itasca Sunova. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

2 owner complaints have been filed with NHTSA for the 2006 Itasca Sunova.

Structure

ODI #10659757

Incident: November 15, 2014 · Filed: November 20, 2014

WHILE DRIVING NORTH ON I-15 BETWEEN HESPERIA AND BARSTOW, CALIFORNIA, THE FIBERGLASS SKIN ON THE ROOF OF OUR RV STARTED BLOWING OFF. BY THE TIME WE WERE ABLE TO SAFELY PULL TO THE SIDE OF THE FREEWAY, 80% OF THE ROOF SKIN HAD SEPARATED FROM THE FRAME AND LARGE PARTS WERE FLYING THROUGH THE AIR. FORTUNATELY THE WIND WAS BLOWING TOWARDS THE SHOULDER AND MOST OF THE FLYING DEBRIS LANDED ON THE SIDE OF THE ROAD AS WE WERE IN THE LANE CLOSEST TO THE SHOULDER. THE DEBRIS INCLUDED THE LAVATORY EXHAUST FAN, FIBERGLASS STYREFOAM, WOOD PANELING AND POSSIBLY COULD HAVE BROUGHT THE AIR CONDITIONER AND SATELLITE DOWN. AFTER TALKING TO SEVERAL REPAIR SHOPS AND READING ONLINE, THIS HAS BEEN AN ONGOING PROBLEM WITH THESE VEHICLES AND NO ONE FROM WINNEBEGO/ITASCA NOTIFIED US OF THIS POTENFIAL FAILURE. I BELIEVE THAT SERIOUS INJURIES OR DEATHS COULD RESULT FROM THIS. *TR

Tires

ODI #10290819

Incident: December 3, 2008 · Filed: November 3, 2009

TL* THE CONTACT OWNS A 2006 ITASCA SUNOVA RV WITH GOODYEAR TIRES DOT# MJ93-MAHW, SIZE 245/70/ R19. WHILE DRIVING 50 MPH SHE HEARD A PECULIAR NOISE FROM THE REAR END OF THE VEHICLE. UPON VEHICLE INSPECTION SHE NOTICED THAT THE INSIDE OF DRIVER-SIDE REAR TIRE HAD EXPLODED. THE TIRE WAS TAKEN TO A DEALERSHIP WHERE THE CONTACT WAS INFORMED THAT THE INNER MESH LINING OF THE TIRE HAD CORRODED. THERE WERE NO PRIOR WARNINGS. THE CURRENT AND FAILURE MILEAGES WERE 19500. UPDATED 12/07/09. *LJ THE CONSUMER HAD EXPERIENCED 4 TIRE BLOWOUTS. GOODYEAR DID NOT OFFER ANY ASSISTANCE. UPDATED 12/08/09

Other Itasca Sunova model years

Check your 2006 Itasca Sunova VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Itasca Sunova at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check an Itasca VIN