NHTSA vehicle safety data

2005 Itasca Sunova Recalls & Complaints

The 2005 Itasca Sunova has 4 NHTSA recall campaigns and 2 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Itasca dealer.

NHTSA recall and complaint data for the 2005 Itasca Sunova. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2005 Itasca Sunova owner complaints

Owners have filed 2 complaints with NHTSA about the 2005 Itasca Sunova, describing incidents dated December 1, 2004 to September 24, 2005.

Most-cited components

Equipment 1 complaint
Service Brakes 1 complaint
Structure 1 complaint

Newest complaints

ODI #10154133 · Filed March 27, 2006
2005 WINNEBAGO ITASCO SUNOVA HAS PROBLEMS WITH THE CHASSIS, IT IS UNSAFE TO DRIVE PAST 55M PH RV IS REACTIVE TO SLIGHT WIND GUST FROM SMALL TO LARGE VEHICLES. *TS THE CONSUMER HAD OTHER PROBLEMS WITH THE RV SUCH AS AN INOPERATIVE STOVE TOP O RING, SLIDE OUT FASCIA RIGHT SIDE, DRIVER SIDE AND…
ODI #10131470 · Filed August 3, 2005
DT: THE CONTACT OWNED A 2005 ITASCA SUNOVA 29R. THERE WAS 3700 MILES ON THE MOTOR HOME. REAR BRAKES WERE SMOKING. THE BRAKES HAD BEEN SQUEALING EVERY SINCE HE PURCHASED VEHICLE. ITASCA CORPORATE HEADQUARTERS REPRESENTATIVE SAID CONSUME R MUST HAVE BEEN DRIVING IT HARD. THIS WAS ON FLAT LAND AND…

Read all 2 complaints

REFRIGERATORS/POSSIBLE FIRE/NORCOLD

NHTSA #10V525000 · Equipment · NHTSA notice

Reported October 26, 2010 · WINNEBAGO INDUSTRIES, INC.

Potentially affected: 18,461 vehicles

Owners notified December 15, 2010

Defect description

WINNEBAGO IS RECALLING CERTAIN RECREATIONAL VEHICLES EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWER ARE NOT SUFFICIENT.

Safety consequence

THE SENSING ALGORITHM OR THERMAL SWITCH INSTALLED TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED DUE TO A POSSIBLE HYDROGEN GAS LEAK MAY NOT SHUT OFF IN SUFFICIENT TIME TO PREVENT A FIRE.

Manufacturer remedy

WINNEBAGO IS WORKING WITH NORCOLD TO IDENTIFY AND NOTIFY ANY AFFECTED OWNERS. OWNERS WILL BE INSTRUCTED TO CONTACT NORCOLD DEALERS TO RECEIVE THE REMEDY FREE OF CHARGE. PLEASE SEE NORCOLD'S DEFECT REPORT 10E-049 FOR ADDITIONAL INFORMATION. THE RECALL BEGAN DURING DECEMBER 2010. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101 OR WINNEBAGO AT 1-641-585-3535.

Notes

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

DINETTE AREA SEAT BELTS/FMVSS 210

NHTSA #10V467000 · Seat Belts · NHTSA notice

Reported October 5, 2010 · WINNEBAGO INDUSTRIES, INC.

Potentially affected: 1,925 vehicles

Manufacturer campaign 119 · Owners notified December 10, 2010 · Vehicles built January 23, 2004 – July 10, 2009 (per NHTSA)

Defect description

WINNEBAGO IS RECALLING CERTAIN MODEL YEAR 2005 THROUGH 2009 WINNEBAGO SIGHTSEER AND ITASCA SUNOVA MOTOR HOMES BECAUSE THE DINETTE AREA SEAT BELT RESTRAINTS ON THOSE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES." IN A COLLISION, THE GENERATED CRASH FORCES CAN CAUSE THE RESTRAINT'S ATTACHMENT TO TEAR AND ALLOW THE ANCHOR TO SEPARATE FROM THE BODY OF THE VEHICLE.

Safety consequence

IF THE RESTRAINT SEPARATES FROM THE VEHICLE DURING A CRASH, THE BELT WILL NOT PROPERLY RESTRAIN THE SEAT OCCUPANT, INCREASING THE RISK OF INJURY OR DEATH TO THE OCCUPANT.

Manufacturer remedy

WINNEBAGO WILL NOTIFY OWNERS A DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 10, 2010. OWNERS MAY CONTACT WINNEBAGO AT 1-800-537-1885.

Notes

WINNEBAGO SAFETY RECALL NO. 119.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

WINNEBAGO/CROSSMEMBER CLEARANCE/FUEL LINE

NHTSA #04V609000 · Fuel System, Gasoline — Delivery — Hoses, Lines/Piping, and Fittings · NHTSA notice

Reported December 22, 2004 · WINNEBAGO INDUSTRIES, INC.

Potentially affected: 3,538 vehicles

Manufacturer campaign 93 · Owners notified January 7, 2005 · Vehicles built August 6, 2003 – September 3, 2004 (per NHTSA)

Defect description

ON CERTAIN MOTOR HOMES BUILT ON A 20,700 GVWR OR GREATER WORKHORSE CHASSIS, THERE MAY NOT BE SUFFICIENT CLEARANCE IN THE AREA WHERE THE FUEL LINE CROSSES THE FRAME CROSS MEMBER.

Safety consequence

WITHOUT CLEARANCE, A CONDITION COULD DEVELOP WHERE THE CROSS MEMBER MAY WEAR INTO THE FUEL LINE AND A FUEL LEAK MAY DEVELOP. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Manufacturer remedy

DEALERS WILL REPAIR THESE MOTOR HOMES BY PROVIDING CLEARANCE BETWEEN THE FUEL LINE AND FRAME CROSS MEMBER. THE FUEL LINE WILL BE INSPECTED AND, IF NECESSARY, REPLACED. THE RECALL BEGAN JANUARY 7, 2005. OWNERS SHOULD CONTACT WINNEBAGO AT 1-800-537-1885.

Notes

WINNEBAGO RECALL NO. 93. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-327-4236.

WINNEBAGO/AMSAFE/SEAT BELTS

NHTSA #04V608000 · Seat Belts — Front — Buckle Assembly · NHTSA notice

Reported December 18, 2004 · WINNEBAGO INDUSTRIES, INC.

Potentially affected: 6,201 vehicles

Manufacturer campaign 92 · Owners notified November 29, 2004 · Vehicles built September 8, 2003 – April 30, 2004 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

CERTAIN SEAT BELT BUCKLES ON SOME MOTOR HOMES FAIL TO CONFORM TO THE LOAD REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."

Safety consequence

THE SEAT BELT BUCKLE MAY UNLATCH IN THE EVENT OF A VEHICLE CRASH, POSSIBLY RESULTING IN PERSONAL INJURY TO THE SEAT OCCUPANT.

Manufacturer remedy

DEALERS WILL REPLACE THE BUCKLES. THE RECALL BEGAN ON NOVEMBER 12, 2004. OWNERS SHOULD CONTACT AMSAFE AT 1-574-266-8330 OR WINNEBAGO AT 1-800-537-1885.

Notes

WINNEBAGO RECALL NO. 92.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-327-4236.

try.vin has no NCAP crash-test rating on file for the 2005 Itasca Sunova. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

2 owner complaints have been filed with NHTSA for the 2005 Itasca Sunova.

Structure; Equipment

ODI #10154133

Incident: September 24, 2005 · Filed: March 27, 2006

2005 WINNEBAGO ITASCO SUNOVA HAS PROBLEMS WITH THE CHASSIS, IT IS UNSAFE TO DRIVE PAST 55M PH RV IS REACTIVE TO SLIGHT WIND GUST FROM SMALL TO LARGE VEHICLES. *TS THE CONSUMER HAD OTHER PROBLEMS WITH THE RV SUCH AS AN INOPERATIVE STOVE TOP O RING, SLIDE OUT FASCIA RIGHT SIDE, DRIVER SIDE AND PASSENGER FENDER BLEW OUT, THE WATER HEATER FAILED, DRIVER SIDE MIRROR HAD BLOWN OFF WHILE DRIVING, A SLIDE OUT LEAK, A TOILET SPRAY LEAK, BATHROOM CAULK CRACKING/SEPARATING, SHOWER CAULK/ SEPARATION, THE KITCHEN WAS DELAMINATING AND THE WALL PAPER WAS BUBBLING

Service Brakes, Hydraulic

ODI #10131470

Incident: December 1, 2004 · Filed: August 3, 2005

DT: THE CONTACT OWNED A 2005 ITASCA SUNOVA 29R. THERE WAS 3700 MILES ON THE MOTOR HOME. REAR BRAKES WERE SMOKING. THE BRAKES HAD BEEN SQUEALING EVERY SINCE HE PURCHASED VEHICLE. ITASCA CORPORATE HEADQUARTERS REPRESENTATIVE SAID CONSUME R MUST HAVE BEEN DRIVING IT HARD. THIS WAS ON FLAT LAND AND VEHICLE WAS SMOKING . COULD SMELL THE BRAKES. THE MOTOR HOME WAS NOT EVEN FULLY LOADED. THE DEALERSHIP SAID BRAKE PADS WHERE BURNT, AND WERE NOT CHECKING ON IT. THE MANUFACTURER WOULD NOT COVER ANYTHING THAN BLEEDING OF THE BRAKES. THE BRAKE JOB WOULD BE $1280 AT FIRST, AND CURREENTLY WAS UP TO ALMOST $2000. 2002-2004 MODELS WERE RECALLED FOR BRAKE PROBLEMS. *AK

Other Itasca Sunova model years

Check your 2005 Itasca Sunova VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Itasca Sunova at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check an Itasca VIN