try.vin
Log in

NHTSA vehicle safety data

2003 Itasca Sunova Recalls & Complaints

The 2003 Itasca Sunova has 7 NHTSA recall campaigns and 4 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Itasca dealer.

NHTSA recall and complaint data for the 2003 Itasca Sunova. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2003 Itasca Sunova owner complaints

Owners have filed 4 complaints with NHTSA about the 2003 Itasca Sunova, describing incidents dated November 18, 2003 to October 11, 2012.

Most-cited components

  • Electrical System 3 complaints
  • Service Brakes 2 complaints
  • Latches/Locks/Linkages 1 complaint
  • Parking Brake 1 complaint
  • Tires 1 complaint

Of the 4 complaints on file, 1 reports a fire (owner-reported, not verified by NHTSA).

Newest complaints

  • ODI #10481018 · Filed

    TL* THE CONTACT OWNS A 2003 ITASCA SUNOVA. WHILE DRIVING APPROXIMATELY 10 MPH, THE CONTACT SMELLED A BURNING ODOR AND NOTICED THAT THE STEERING WHEEL WAS ABNORMALLY PULLING TO THE LEFT. IN ADDITION, THE BRAKE PEDAL BEGAN TO STICK. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC…

  • ODI #10384767 · Filed

    BRAKE FAILURE ITASCA RV. *TR

  • ODI #10384757 · Filed

    TL*THE CONTACT OWNS A 2003 ITASCA SUNOVA. THE CONTACT STATED THAT WHILE DRIVING AT LOW SPEEDS THE BRAKES WERE APPLIED AND THEY WOULD NOT RELEASE. THE VEHICLE WAS ABLE TO BE DRIVEN AFTER WAITING A WHILE. THE VEHICLE WAS INSPECTED BY AN INDEPENDENT MECHANIC WHO ADVISED HIM THAT THE BRAKES NEEDED TO BE…

Read all 4 complaints

REFRIGERATORS/POSSIBLE FIRE/NORCOLD

NHTSA #10V525000 · Equipment · NHTSA notice

Reported October 26, 2010 · WINNEBAGO INDUSTRIES, INC.

Potentially affected: 18,461 vehicles

Owners notified December 15, 2010

Defect description

WINNEBAGO IS RECALLING CERTAIN RECREATIONAL VEHICLES EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWER ARE NOT SUFFICIENT.

Safety consequence

THE SENSING ALGORITHM OR THERMAL SWITCH INSTALLED TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED DUE TO A POSSIBLE HYDROGEN GAS LEAK MAY NOT SHUT OFF IN SUFFICIENT TIME TO PREVENT A FIRE.

Manufacturer remedy

WINNEBAGO IS WORKING WITH NORCOLD TO IDENTIFY AND NOTIFY ANY AFFECTED OWNERS. OWNERS WILL BE INSTRUCTED TO CONTACT NORCOLD DEALERS TO RECEIVE THE REMEDY FREE OF CHARGE. PLEASE SEE NORCOLD'S DEFECT REPORT 10E-049 FOR ADDITIONAL INFORMATION. THE RECALL BEGAN DURING DECEMBER 2010. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101 OR WINNEBAGO AT 1-641-585-3535.

Notes

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

WINNEBAGO/CROSSMEMBER CLEARANCE/FUEL LINE

NHTSA #04V609000 · Fuel System, Gasoline — Delivery — Hoses, Lines/Piping, and Fittings · NHTSA notice

Reported December 22, 2004 · WINNEBAGO INDUSTRIES, INC.

Potentially affected: 3,538 vehicles

Manufacturer campaign 93 · Owners notified January 7, 2005 · Vehicles built August 6, 2003 – September 3, 2004 (per NHTSA)

Defect description

ON CERTAIN MOTOR HOMES BUILT ON A 20,700 GVWR OR GREATER WORKHORSE CHASSIS, THERE MAY NOT BE SUFFICIENT CLEARANCE IN THE AREA WHERE THE FUEL LINE CROSSES THE FRAME CROSS MEMBER.

Safety consequence

WITHOUT CLEARANCE, A CONDITION COULD DEVELOP WHERE THE CROSS MEMBER MAY WEAR INTO THE FUEL LINE AND A FUEL LEAK MAY DEVELOP. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Manufacturer remedy

DEALERS WILL REPAIR THESE MOTOR HOMES BY PROVIDING CLEARANCE BETWEEN THE FUEL LINE AND FRAME CROSS MEMBER. THE FUEL LINE WILL BE INSPECTED AND, IF NECESSARY, REPLACED. THE RECALL BEGAN JANUARY 7, 2005. OWNERS SHOULD CONTACT WINNEBAGO AT 1-800-537-1885.

Notes

WINNEBAGO RECALL NO. 93. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-327-4236.

WINNEBAGO\SAMSUNG\MICROWAVE

NHTSA #04V358000 · Equipment — Recreational Vehicle/Trailer · NHTSA notice

Reported July 19, 2004 · WINNEBAGO INDUSTRIES, INC.

Potentially affected: 5,645 vehicles

Vehicles built August 2, 2002 – August 29, 2003 (per NHTSA)

Defect description

ON CERTAIN MOTOR HOMES EQUIPPED WITH SAMSUNG MICROWAVE OVENS, MODELS MR1031WB, MR1032BB, MR1033SB, MR1351WB, AND MR1352BB, THE MICROWAVES WERE PRODUCED WITH A DEFECTIVE PANEL. AN ELECTRICAL SHORT CAN OCCUR BETWEEN CIRCUIT PATTERNS ON THE MEMBRANE PANEL, ESPECIALLY OVERLAPPED BY A "JUMPER" OR JUMP WIRE. THIS MAY CAUSE THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS.

Safety consequence

AN ELECTRICAL SHORT CAN OCCUR CAUSING THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS. THIS COULD RESULT IN EXCESSIVE HEAT, SMOKE, OR POSSIBLY A FIRE.

Manufacturer remedy

SAMSUNG WILL NOTIFY CUSTOMERS AND REPAIR THE PANEL FREE OF CHARGE. IN THE MEANTIME, CONSUMERS SHOULD UNPLUG THEIR MICROWAVE, IF POSSIBLE. IF THE CONSUMER IS UNABLE TO UNPLUG THE MICROWAVE, THEY SHOULD LEAVE THE DOOR AJAR UNTIL THE PANEL IS REPLACED. CONSUMERS SHOULD NEVER USE THE MICROWAVE OVEN FOR STORAGE OR LEAVE ANY TOWELS, PAPER, CLOTH OR OTHER PRODUCTS IN THE MICROWAVE AFTER USE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SAMSUNG AT 1-800-932-3837 OR WINNEBAGO AT 1-641-585-3535.

Notes

CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

WINNEBAGO/SAMSUNG/MICROWAVES

NHTSA #03V405000 · Equipment — Recreational Vehicle/Trailer · NHTSA notice

Reported October 16, 2003 · WINNEBAGO INDUSTRIES, INC.

Potentially affected: 15,337 vehicles

Vehicles built May 1, 2000 – October 31, 2003 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

ON CERTAIN MOTOR HOMES EQUIPPED WITH SAMSUNG MICROWAVE OVENS, THESE UNITS WERE PRODUCED WITH A DEFECTIVE PANEL. AN ELECTRICAL SHORT CAN OCCUR BETWEEN CIRCUIT PATTERNS ON THE MEMBRANE PANEL, ESPECIALLY OVERLAPPED BY A "JUMPER" OR JUMP WIRE. THIS MAY CAUSE THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS.

Safety consequence

AN ELECTRICAL SHORT CAN OCCUR CAUSING THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS. THIS COULD RESULT IN EXCESSIVE HEAT, SMOKE, OR POSSIBLY A FIRE.

Manufacturer remedy

SAMSUNG WILL NOTIFY CUSTOMERS AND REPAIR THE PANEL FREE OF CHARGE. IN THE MEANTIME, CONSUMERS SHOULD UNPLUG THEIR MICROWAVE, IF POSSIBLE. IF THE CONSUMER IS UNABLE TO UNPLUG THE MICROWAVE, THEY SHOULD LEAVE THE DOOR AJAR UNTIL THE PANEL IS REPLACED. CONSUMERS SHOULD NEVER USE THE MICROWAVE OVEN FOR STORAGE OR LEAVE ANY TOWELS, PAPER, CLOTH OR OTHER PRODUCTS IN THE MICROWAVE AFTER USE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SAMSUNG AT 800-932-3837 OR WINNEBAGO AT 641-585-3535.

Notes

CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

WINNEBAGO/COOKING RANGE

NHTSA #03V243000 · Equipment — Recreational Vehicle/Trailer · NHTSA notice

Reported July 8, 2003 · WINNEBAGO INDUSTRIES, INC.

Potentially affected: 2,684 vehicles

Manufacturer campaign 89 · Owners notified July 10, 2003 · Vehicles built March 27, 2001 – May 8, 2003 (per NHTSA)

Defect description

ON CERTAIN MOTOR HOMES, WHEN THE COOKING RANGE AND FURNACE ARE OPERATING AT THE SAME TIME, THE FLAME ON THE COOKING RANGE COULD BE FORCED DOWNWARD OVER THE BURNER OR FLAME OUTAGE COULD OCCUR. THIS CONDITION IS DUE TO THE LOCATION OF THE FURNACE AND COOKING RANGE WHEREBY THE FURNACE MAY DRAW AIR IN FROM ABOVE THE RANGE BURNERS AND CAUSE A DOWNDRAFT.

Safety consequence

SHOULD THIS OCCUR, THE FLAME MAY GO OUT, AND THE LIQUID PROPANE (LP) GAS WILL CONTINUE TO FLOW. THIS IS A HAZARDOUS SITUATION THAT COULD RESULT IN AN EXPLOSION OR FIRE.

Manufacturer remedy

DEALERS WILL INSTALL AN AIR RESTRICTOR PANEL UNDER THE RANGE. OWNER NOTIFICATION BEGAN JULY 10, 2003. OWNERS SHOULD CONTACT WINNEBAGO AT 1-641-585-6939.

Notes

WINNEBAGO RECALL NO. 89.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

WINNEBAGO/BRAKE SYSTEM WARNING INDICATOR

NHTSA #03V060000 · Service Brakes, Hydraulic — Brake Fluid Low Warning — Lamp · NHTSA notice

Reported February 21, 2003 · WINNEBAGO INDUSTRIES, INC.

Potentially affected: 8,532 vehicles

Manufacturer campaign 88 · Owners notified April 25, 2003 · Vehicles built August 1, 1999 – January 31, 2003 (per NHTSA)

Defect description

CERTAIN MOTOR HOME CHASSIS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 105,"HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." THE BRAKE SYSTEM WARNING INDICATOR MAY NOT FUNCTION AS REQUIRED BY THE STANDARD.

Safety consequence

IN SOME OF THE AFFECTED VEHICLES, THE BRAKE SYSTEM WARNING INDICATOR WILL NOT ILLUMINATE WHEN THE IGNITION IS IN THE START POSITION OR FOR A LOW BRAKE FLUID CONDITION, IF THE BODY BUILDER RELIED SOLELY UPON FORD'S IVM COMPLIANCE STATEMENT FOR THE SYSTEM WARNING INDICATOR.

Manufacturer remedy

DEALERS WILL REPAIR THESE VEHICLES. OWNER NOTIFICATION BEGAN APRIL 25, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT WINNEBAGO AT 1-641-585-3535.

Notes

WINNEBAGO RECALL NO. 88.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

WINNEBAGO/SPARE TIRE MOUNTING PLATE

NHTSA #03V049000 · Tires — Temporary/Emergency Spare Tire · NHTSA notice

Reported February 20, 2003 · WINNEBAGO INDUSTRIES, INC.

Potentially affected: 176 vehicles

Manufacturer campaign 87 · Owners notified March 7, 2003 · Vehicles built January 31, 2002 – September 30, 2002 (per NHTSA)

Defect description

ON CERTAIN MODEL D30B MOTOR HOMES BUILT ON A FORD CHASSIS, A PLATE, WHICH IS USED TO SUPPORT THE SPARE TIRE, WAS INADVERTENTLY LEFT OFF A NUMBER OF THESE MOTOR HOMES.

Safety consequence

WITHOUT THIS ADDITIONAL SUPPORT, THE SPARE TIRE COULD FALL OFF THE VEHICLE RESULTING IN PROPERTY DAMAGE AND POSSIBLY PERSONAL INJURY.

Manufacturer remedy

DEALERS WILL INSPECT THE SPARE TIRE MOUNT AND, IF NECESSARY, INSTALL A NEW SUPPORT PLATE. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING MARCH 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT WINNEBAGO AT 1-641-585-6939.

Notes

WINNEBAGO RECALL NO. 87. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Other Itasca Sunova model years

Check your 2003 Itasca Sunova VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Itasca Sunova at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check an Itasca VIN