2011 Hyundai Tucson Recalls & Complaints

Incident: December 31, 2024 · Filed: April 21, 2026

I own a 2011 Hyundai Tucson (VIN: [XXX] ). The vehicle had an engine replacement performed by Hyundai service. Immediately after picking up the car, I noticed a loud abnormal noise coming from underneath the vehicle. I reported the issue right away, but was told nothing was heard and it was dismissed. The noise has continued and worsened over time. I am concerned there may be damage or improper installation affecting the exhaust system or flex pipe, which could be a safety issue. Exact service dates are with Hyundai records, as I do not have them available. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident: January 12, 2026 · Filed: January 26, 2026

While driving my speedometer became erratic, just one time. My cruise control is no longer working, my trip odometer is not working and possibly the odometer is not working properly. I googled for speedometer problems with 2011 Hyundai speedometers and found an article that may be false on Reuters "Hyundai Motor to recall nearly 84,000 US vehicles over instrument panel display failure, NHTSA says" I called Hyundai last week and the lady I spoke with said there was a service bulletin and said it would be repaired at no cost! She even set me up with an appointment at the local dealer. About 2 days later I received an email that said there was no tsb and that it was not covered under warranty. I cancelled the appointment and stopped at the Hyundai dealership. The man I spoke with seemed to know exactly what I was talking about and said it would be almost $200 to diagnose and that would be applied to the repair which would be $7-800. He also said there are 2 different switches and it coud be either switch. I know there's a lot of garbage on the internet but when I saw the article that said that "NHTSA says" and then was told by someone at Hyundai that there is a service bulletin, I believed it. I'm [XXX] old and my wife and I have had this vehicle since new. It's a good vehicle and most likely our last. However I am totally bewildered by this situation. Is there a recall/service bulletin that you are aware of or not? Thank you! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident: June 29, 2025 · Filed: July 21, 2025

I purchased a brand new fuel pump on 2-28-24 after car died on freeway. Mission Hills Hyundai diagnosed as pump not turning on, so recommended replacing fuel pump assembly. On [XXX] car wouldn’t start, so took vehicle in and the next day it was determined as faulty starter. Car was picked up 7-3-25 after buying a new starter, but car would not start again the next day. The car was actually misdiagnosed and the ruling was tank fuel pump had an intermittent short circuit. I’ve driven on the fuel pump I purchased on 2-28-24 for about a year in a half. It only lasted 40,000 miles. Fuel pumps last 100,000 to 200,000 miles. I’ve driven other vehicles going over 100,000 miles on the same fuel pump. How did this fuel pump go out so quick? Was it installed right? Was it bad wiring? Was it a defective part? Thankfully the fuel pump went out when I wasn’t driving. This is a major safety issue and Lithia, who is the parent company of Mission Hills Hyundai, should be looked into. Also the misdiagnosis from the technician should be in question to. Integrity is also an issue here, so how can I feel safe if I want to to continue getting my car serviced here. Yes they gave me a new fuel pump with no charge, but still had to pay for a starter I didn’t need. Basically I spent $3000 for a part that went out on my vehicle in over a year. Just like how Ford has a recent recall of fuel pumps, Hyundai should be checked into this issue also. I will attach invoices including a service for my fuel system cleaning. I thought all this work I got done would prevent a major failure on a vital vehicle component. Thank you, Hope to hear from you INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident: March 11, 2025 · Filed: April 7, 2025

The contact's daughter owns a 2011 Hyundai Tucson. The contact stated that upon his daughter attempting to enter the vehicle through the front driver’s side door, the door failed to open. The contact stated that his daughter opened the front passenger’s side door and there was black smoke coming from inside the vehicle. The contact’s daughter discovered that the front driver’s side seat, driver’s side door panel, and headliner was burned. The contact stated that the Fire Department was not called to the scene. There was no one injured. Upon investigation, the contact discovered that the vehicle was included in NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic). The dealer was notified of the failure and a tow truck was sent to the residence. While the vehicle was in the dealer's possession, the failure was acknowledged, but the dealer stated that the damages would not be covered for free. The manufacturer was notified of the failure but offered no assistance. The vehicle as not repaired and remained with the dealer. The failure mileage was unknown.

Incident: September 1, 2022 · Filed: March 30, 2025

Recall # 251 has been going on at great length and I have an appointment for 11:30am April 1,2025 for what they deem as a solution to # 251 Recall that does not fix the problem and goes against everything that the NHTSA and FEDERAL GOVERMENT LAWS are in place for, you are allowing them to continue to not do what the laws clearly state and in a certain time period have repaired, replaced or make restiitution for the recalled issue it also is stated that they do not need to for automobiles older than 15years.Their Bandaid only creates other problems and dangers and by 02/11/2026 my car will be 16years old but it wasn’t when all this first started,I own a time bomb and can not afford to buy another vehicle,Im retired and live on a fixed income. Im not sure if letting them change a fuse to a lower wattage so it would fail and make the ABS System Disabled there by stopping leaking brake fluid from igniting.Does Not Meet Any Requirements and Creates More Issues.My Car has AWD and is low mileage for the age.I don’t agree with letting them do this but Im afraid of what NHTSA or They can do if I don’t,Why aren’t you stopping them perpetrate a fraud.This is not by your own law's fines have not helped the millions involved in this #251 Recall Thankyou.

Incident: January 23, 2025 · Filed: January 27, 2025

Happened to be driving our car (11/23/25) to drop off our other car for brake pad replacement. On the way to our mechanic the brake light came on in the dash cluster. After having spoken to our mechanic we prepared to leave the car we planned to drop off. Got in our Hyundai Tucson and the brake light was still on, odd. Proceed to back up and he brake pedal almost went to the floor. Got out looked underneath the car and there was a puddle of brake fluid. The Hyundai was unsafe to drive as it had no brakes and we left it at our mechanic. He called Friday to say Hyundai longer makes the brake lines and he was searching for the front brake lines that corroded away and failed. He said the rear lines we coated to protect them from corrosion and the front lines were not. Learned over the weekend that the Canadian government recalled almost 300K Hyundai vehicles for corroded or failed brake lines. Why hasn't the US addressed this serious safety issue? My image is too large to be accepted by your system. Is there another way to submit it? We were incredibly fortunate as we were going home on a highway at rush. If the brakes failed I'm certain we and others would have been injured.

Incident: July 22, 2024 · Filed: November 20, 2024

I am writing regarding the NHTSA Recall Number23V651000. I have been on a waiting list since July when the recall notice about a remedy finally being determined was sent in the mail. I have now called Hyundai of Cool Springs in Tennessee about where I am on the list. At one point they were saying September, then when I called again they were thinking some time in November. We are now almost out of November and I am not getting any updates and would like to park my daughter's vehicle in the garage. The dealership is saying that parts or something on back order with no idea on when I can expect an appointment to resolve this issue. I didn't let my daughter take the car to college thinking I would be able to resolve this by the time we were hitting winter break and her returning to school in January. Please provide guidance on other options to get this remedy taken care of. Thank you

Incident: September 23, 2023 · Filed: September 24, 2024

The contact owns a 2011 Hyundai Tucson. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

Incident: July 17, 2024 · Filed: July 17, 2024

The contact owns a 2011 Hyundai Tucson. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. Parts distribution disconnect.

Incident: June 10, 2024 · Filed: June 10, 2024

The contact owns a 2011 Hyundai Tucson. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.