NHTSA vehicle safety data

2006 Hyundai Tucson Recalls, Ratings & Complaints

The 2006 Hyundai Tucson has 5 NHTSA recall campaigns and 135 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Hyundai dealer.

NHTSA recall and complaint data for the 2006 Hyundai Tucson, plus NCAP crash-test ratings. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2006 Hyundai Tucson owner complaints

Owners have filed 135 complaints with NHTSA about the 2006 Hyundai Tucson, describing incidents dated January 5, 2006 to December 6, 2025.

Most-cited components

Air Bags 37 complaints
Engine 21 complaints
Electrical System 16 complaints
Service Brakes 15 complaints
Steering 13 complaints
Structure 13 complaints

Of the 135 complaints on file, 15 report a crash and 3 a fire; across all 135 complaints, owners report 17 injuries (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11703603 · Filed December 7, 2025
Rear subframe corrosion
ODI #11622348 · Filed October 28, 2024
The contact owns a 2006 Hyundai Tucson. The contact stated while the vehicle was parked, the contact noticed that the rear subframe had become inoperable and the contact noticed that the rear subframe was corroded. The vehicle was towed to an independent mechanic but was not diagnosed or repaired…
ODI #11603602 · Filed July 21, 2024
ESC OFF light does not turn off. I press it off and on while driving and nothing happens. It stays on all the time.

Read all 135 complaints

NHTSA defect investigations

NHTSA's investigations file lists the 2006 Hyundai Tucson in 1 investigation. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Preliminary Evaluation PE09-003: STOP LAMP SWITCH FAILURE
Closed April 24, 2009
- Recall 09V-122

Open and recently closed NHTSA defect investigations

Stop Lamp Switch may Function Intermittently

NHTSA #13V113000 · Exterior Lighting — Brake Lights — Switch · NHTSA notice

Reported April 1, 2013 · Hyundai Motor Company

Potentially affected: 1,712,336 vehicles

Hyundai campaign 110 · Owners notified April 22, 2013 · Vehicles built March 1, 2006 – November 30, 2010 (per NHTSA)

Defect description

Hyundai Motor Company (Hyundai) is recalling certain model year 2006-2009 Accent, model year 2007-2011 Azera, Sonata and Sante Fe,2006-2011 Tucson, 2009-2011 Elantra Touring, 2007-2010 Elantra, 2008-2011 Veracruz, 2009-2011 Genesis, 2010-2011 Genesis Coupe, 2007-2008 Entourage, and 2006-2008 Tiburon vehicles. Originally, in April 2013, Hyundai recalled 1,059,824 model year 2007-2009 Accent and Tucson, model year 2007-2010 Elantra, model year 2007-2011 Santa Fe, model year 2008-2009 Veracruz, model year 2010-2011 Genesis Coupe, and model year 2011 Sonata vehicles. In September 2013, Hyundai informed the agency that it was adding more vehicles to this campaign, representing an additional 652,512 units. The total number of vehicles being recalled is now 1,712,336. In the affected vehicles, the stop lamp switch may malfunction. A malfunctioning stop lamp switch may cause the brake lights to not illuminate when the brake pedal is depressed or may cause an inability to deactivate the cruise control by depressing the brake pedal. Additionally, a malfunctioning stop lamp switch may also result in intermittent operation of the push-button start feature, affect the operation of the brake transmission shift interlock feature, preventing the shifter from being moved out of the PARK position and cause the Electronic Stability Control (ESC) malfunction light to illuminate.

Safety consequence

Failure to illuminate the stop lamps during braking or inability to disengage the cruise control could increase the risk of a crash. Additionally, when the ignition is in the 'ON' position, the transmission shifter may be able to be moved out of Park without first applying the brake. This may lead to unintentional movement of the car which may increase the risk of a crash.

Manufacturer remedy

Hyundai will notify owners, and dealers will replace the stop lamp switch, free of charge. The safety recall began on April 22, 2013. Owners may contact Hyundai at 1-800-633-5151. Hyundai's recall campaign number is 110.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

STOP LAMP SWITCH

NHTSA #09V280000 · Exterior Lighting · NHTSA notice

Reported July 21, 2009 · HYUNDAI CARIBBEAN-PUERTO RICO

Potentially affected: 3,011 vehicles

Hyundai campaign 91B026 · Owners notified September 2, 2009 · Vehicles built April 4, 2005 – October 20, 2006 (per NHTSA)

Defect description

HYUNDAI IS RECALLING 3,011 MODEL YEAR 2005-2007 ELANTRA, TUCSON, SONATA, AZERA AND ACCENT VEHICLES. A MALFUNCTIONING STOP LAMP SWITCH MAY CAUSE THE BRAKE LIGHTS TO FAIL TO ILLUMINATE WHEN THE BRAKE PEDAL IS DEPRESSED OR MAY CAUSE THE BRAKE LIGHTS TO REMAIN ILLUMINATED WHEN THE BRAKE PEDAL IS RELEASED. A DEFECTIVE STOP LAMP SWITCH MAY ALSO AFFECT THE OPERATION OF THE BRAKE-TRANSMISSION SHIFT INTERLOCK FEATURE SO THE TRANSMISSION WOULD NOT BE ABLE TO BE SHIFT OUT OF THE "PARK" POSITION. IT MAY ALSO CAUSE THE ELECTRONIC STABILITY CONTROL (ESC) MALFUNCTION LIGHT TO ILLUMINATE, AND IT MAY NOT DEACTIVATE THE CRUISE CONTROL WHEN THE BRAKE PEDAL IS DEPRESSED.

Safety consequence

ANY OF THESE MALFUNCTIONS COULD LEAD TO A CRASH.

Manufacturer remedy

DEALERS WILL REPLACE THE STOP LAMP SWITCH FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 2, 2009. OWNERS MAY CONTACT HYUNDAI OF PUERTO RICO CUSTOMER SERVICE AT 1-787-999-4310.

Notes

HYUNDAI OF PUERTO RICO RECALL NO.91B026.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

STOP LAMP SWITCH ASSEMBLY

NHTSA #09V122000 · Exterior Lighting — Brake Lights — Switch · NHTSA notice

Reported April 15, 2009 · HYUNDAI MOTOR COMPANY

Potentially affected: 532,633 vehicles

Hyundai campaign 092 · Owners notified June 29, 2009 · Vehicles built April 1, 2005 – April 30, 2007 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

HYUNDAI IS RECALLING 532,633 MY 2006-2007 ACCENT, ENTOURAGE, SONATA, MY 2007 AZERA, ELANTRA AND SANTA FE, MY 2005-2007 TUCSON AND MY 2007-2008 VERACRUZ VEHICLES. THE STOP LAMP SWITCH IN THE AFFECTED VEHICLES MAY MALFUNCTION. A MALFUNCTIONING STOP LAMP SWITCH MAY CAUSE THE BRAKE LIGHTS TO NOT ILLUMINATE WHEN THE BRAKE PEDAL IS DEPRESSED OR MAY CAUSE THE BRAKE LIGHTS TO REMAIN ILLUMINATED WHEN THE BRAKE PEDAL IS RELEASED. A STOP LAMP SWITCH MALFUNCTION MAY ALSO AFFECT THE OPERATION OF THE BRAKE-TRANSMISSION SHIFT INTERLOCK FEATURE SO THE TRANSMISSION SHIFTER WOULD NOT BE ABLE TO BE SHIFTED OUT OF THE PARK POSITION. IT MAY ALSO CAUSE THE ELECTRONIC STABILITY CONTROL (ESC) MALFUNCTION LIGHT TO ILLUMINATE, AND IT MAY NOT DEACTIVATE THE CRUISE CONTROL WHEN THE BRAKE PEDAL IS DEPRESSED.

Safety consequence

ANY OF THESE MALFUNCTIONS, ALONE OR IN COMBINATION, MAY LEAD TO A CRASH.

Manufacturer remedy

DEALERS WILL REPLACE THE STOP LAMP SWITCH FREE OF CHARGE. THE RECALL BEGAN ON JUNE 29, 2009. OWNERS MAY CONTACT THE HYUNDAI CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151.

Notes

HYUNDAI RECALL NO. 092.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

FMVSS 208/DRIVER AIR BAG MODULE REPLACEMENT

NHTSA #07V197000 · Air Bags — Frontal — Driver Side — Inflator Module · NHTSA notice

Reported May 8, 2007 · HYUNDAI CARIBBEAN-PUERTO RICO

Potentially affected: 2,967 vehicles

Hyundai campaign 079 · Owners notified September 6, 2007 · Vehicles built July 30, 2004 – November 1, 2006 (per NHTSA)

Defect description

ON CERTAIN VEHICLES, STATIC AIR BAG DEPLOYMENT TESTING CONDUCTED BY NHTSA USING FIFTH PERCENTILE FEMALE DUMMIES INDICATED THAT A SMALL STATURE ADULT DRIVER NOT WEARING A SEAT BELT AND INVOLVED IN A FRONTAL OR NEAR FRONTAL CRASH, THE DEPLOYMENT OF THE DRIVER AIR BAG MAY NOT OCCUR.

Safety consequence

THIS CAN CAUSE INCREASED RISK OF INJURY TO THE DRIVER UNDER CERTAIN CRASH CONDITIONS.

Manufacturer remedy

DEALERS WILL REPLACE THE DRIVER AIR BAG MODULE WITH ONE THAT IS DESIGNED TO PROVIDE AN INCREASED MARGIN OF COMPLIANCE FOR LOW RISK DEPLOYMENT FOR SMALL STATURE ADULTS WHO ARE NOT PROPERLY WEARING THE SEAT BELTS. THE RECALL BEGAN ON SEPTEMBER 6, 2007, AND WILL BE PERFORMED IN TWO MAILINGS. OWNERS MAY CONTACT HYUNDAI DE PUERTO RICO AT 1-800-981-0188.

Notes

HYUNDAI RECALL NO. 079.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

FMVSS 208/AIR BAG SYSTEM

NHTSA #06V445000 · Air Bags — Frontal — Driver Side — Inflator Module · NHTSA notice

Reported November 22, 2006 · HYUNDAI MOTOR COMPANY

Potentially affected: 128,300 vehicles

Hyundai campaign 079 · Owners notified January 29, 2007 · Vehicles built July 30, 2004 – November 1, 2006 (per NHTSA)

Defect description

ON CERTAIN SPORT UTILITY VEHICLES, DURING STATIC AIR BAG DEPLOYMENT TESTING CONDUCTED BY NHTSA USING FIFTH PERCENTILE FEMALE DUMMIES INDICATED IF A SMALL STATURED ADULT DRIVER, NOT WEARING A SEAT BELT, IS INVOLVED IN A FRONTAL OR NEAR FRONTAL CRASH, DEPLOYMENT OF THE DRIVER AIR BAG MAY RESULT IN AN INSUFFICIENT MARGIN OF COMPLIANCE AS MEASURED BY THE TEST DUMMY USED IN THE NHTSA TEST.

Safety consequence

THIS CAN CAUSE INCREASED RISK OF INJURY TO THE DRIVER UNDER CERTAIN CRASH CONDITIONS.

Manufacturer remedy

DEALERS WILL REPLACE THE DRIVER AIR BAG MODULE. THE RECALL BEGAN ON JANUARY 29, 2007, AND WILL BE CONDUCTED THROUGH SIX MAILINGS. OWNERS MAY CONTACT HYUNDAI AT 1-800-633-5151.

Notes

HYUNDAI RECALL NO. 079.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

2006 Hyundai Tucson 4-DR w/SAB

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 5, Passenger: 5

Side Crash

Not Rated

Driver: 5, Passenger: 5

Side Pole

Not Rated

Rollover

18% rollover risk

Safety Technology

Electronic Stability Control

1 investigation

135 owner complaints have been filed with NHTSA for the 2006 Hyundai Tucson.

Unknown or Other

ODI #11703603

Incident: December 6, 2025 · Filed: December 7, 2025

Rear subframe corrosion

Structure

ODI #11622348

Incident: October 28, 2024 · Filed: October 28, 2024

The contact owns a 2006 Hyundai Tucson. The contact stated while the vehicle was parked, the contact noticed that the rear subframe had become inoperable and the contact noticed that the rear subframe was corroded. The vehicle was towed to an independent mechanic but was not diagnosed or repaired. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 180,000.

Unknown or Other; Service Brakes

ODI #11603602

Incident: April 10, 2024 · Filed: July 21, 2024

ESC OFF light does not turn off. I press it off and on while driving and nothing happens. It stays on all the time.

Tires; Engine

ODI #11598019

Incident: November 16, 2023 · Filed: July 1, 2024

The contact owns a 2006 Hyundai Tucson. The contact stated that while attempting to start the vehicle, the vehicle hesitated. The vehicle was taken to an independent mechanic, where it was diagnosed; however, the cause of the failure was not yet determined. The contact stated while driving at an undisclosed speed, the vehicle stalled. The check engine warning light and the TPMS warning light were illuminated. Additionally, the engine overheated. The contact related the failure to an unknown recall and Technical Service Bulletin: 952. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 140,000.

Suspension; Structure; Service Brakes

ODI #11577140

Incident: January 10, 2022 · Filed: March 13, 2024

At first brakes were making noise so I went to replace them after getting parts and I noticed that the brake pedal went to the floor I was able to get it on concrete pad but when I jacked it up I say big chunks of rust falling when I looked under car rear axle subframe was pretty much gone after I say that I decided to order the replacement subframe but when it come in and I was getting ready to do it I body mount where it is bolted also needs replaced I was trying to find them when I come across a factory recall about this issue when I contacted them and the dealer about this issue dealer said it couldn't be done because there was nothing left and he refused to put on a lift because he said the rear subframe would fall on ground but manufacturer denied to repair or make any resolutions for it even though they had in past and they new about the problem I have found over 1000 issues listed and they have repaired a bunch of the same vehicles for the same issue I told them I never received anything about the issue and they said it was my responsibility not there's so not only did they not do or even try to do what they have on recall but they refused to do anything for me and I was glad I didn't try driving after I heard noise because I could of caused a major accident and been severely injured in process not to mention someone else due to rear frame and brakes falling and falling out of car

Suspension

ODI #11572948

Crash

Incident: February 1, 2024 · Filed: February 20, 2024

Rear cross member frame broke in 2 spots due to rust. I’ve searched this and found numerous vehicles with same problem contacted dealer and they said they can’t do anything about it. What steps should I take. I called there corporate office left They don’t don’t return calls callsor or texts complaints.

Unknown or Other

ODI #11489382

Incident: October 7, 2022 · Filed: October 15, 2022

Driver side rear unibody sub frame rusted through

Steering; Suspension; Unknown or Other

ODI #11478061

Incident: August 6, 2022 · Filed: August 7, 2022

Rear control arm mount broke away from subframe while on the highway going 65mph. Violent shaking and steering malfunction occurred immediately. Passed WV inspection just a few months ago.

Firerelated

ODI #11477625

Fire

Incident: August 2, 2022 · Filed: August 4, 2022

The contact owned a 2006 Hyundai Tucson. The contact stated that after parking his vehicle in the driveway, he looked through the window of his residence and noticed that the vehicle had caught fire from underneath the hood. The contact related the fire to an electrical system failure. The fire department was able to extinguish the fire. Police and fire department reports were filed. The vehicle was towed to a tow yard and deemed totaled by the insurance company. The manufacturer was not made aware of the failure. The failure mileage was approximately 198,000.

Engine

ODI #11453396

Incident: February 5, 2022 · Filed: February 22, 2022

When I drive my car and right after I put gas in my car I smell gas to the point that my husband and I are coming home with headaches and we're sick to her stomach I've taken it to a mechanic and they say there's nothing wrong the engine check engine light keep on coming on and then it will go off after it sit for a couple minutes turned off I'm about ready to have a baby in June and I'm so worried to have the baby in the car the brakes have stopped working to the point that I've gone in through lights and I can hardly put the brakes on I have to use emergency brake sometimes and nobody will help me get it taken care of I have had almost couple wrecks because I cannot get the brakes to stop take a lock on me and it's scary when you're having a baby and you know your seatbelt your brakes are locking but you for your seat belt to keep safe and my brakes locked to the point I cannot get them after the kick hit them with all my might just to unlock them and nobody will help me fix it

Other Hyundai Tucson model years

Check your 2006 Hyundai Tucson VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Hyundai Tucson at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Hyundai VIN