2023 Hyundai Tucson Recalls, Ratings & Complaints

Incident: October 10, 2026 · Filed: October 23, 2026

SAFETY DEFECT SUPPLEMENT TO NHTSA COMPLAINT #11685540 | VIN: [XXX] | MILEAGE: 27,370 ​This filing supplements Complaint #XXX regarding an uncorrected, compounded steering safety failure following the catastrophic detachment of the steering column while driving on XXX (Repair Order #XXX). ​COMPONENTS FAILED: Steering column assembly, footwell closeout shield, dashboard lower crash pad structural frame, and push-start switch. All components and vehicle are available for immediate inspection. ​SAFETY RISK: Following an invasive warranty teardown for an ignition switch failure under R/O #XXX at [XXX] Hyundai, the vehicle was released in an incomplete, hazardous condition. The factory lower footwell closeout shield was completely omitted, leaving the rotating intermediate steering shaft, universal joint, electric power steering motor, brake clevis linkage, and wiring harness fully exposed directly above driver foot controls. This creates a severe entrapment and mechanical binding hazard. An unauthorized exterior screw was drilled directly through the finished lower crash pad trim to pinch broken internal plastic tabs together, and hardware was left rattling inside the column housing. ​DEALER CONFIRMATION & RECORD FALSIFICATION: Management dismissed the exposed shaft. On R/O #XXX Line 3, the dealership falsified the narrative as "customer needs screws put in behind steering wheel" under an engine line to conceal shop rework. Authorized remedy has completely failed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident: September 4, 2026 · Filed: October 7, 2026

Horn in vehicle stopped working it’s been 3 weeks and dealer can’t get parts. I feel it’s unsafe driving without ihaving access no horn especially around school.

Incident: July 5, 2026 · Filed: October 1, 2026

2023 Hyundai Tucson Limited, 2.5L GDI, Alabama-built (VIN 5NMXXXXXXXXXXXXXX), built [XXX]. On [XXX], at about 37,550 miles, the check engine light came on flashing and the engine ran rough while I was traveling in Canada. My scan tool showed P0300, P0302 and P0304 (misfires on cylinders 2 and 4). On July 6, 2026, Experience Hyundai in Charlottetown, PE (service order 92XXX) replaced one ignition coil under warranty. No fuel injector leak test was performed. The misfires returned. On [XXX], at 39,409 miles, my scan showed P0302 active and P0304 pending. The car also had extended cranking after sitting and the check engine light was on. I was told I could keep driving the car unless it started to jerk or engine light started to flash, then immediately stop driving it and have it towed. On September 25, 2026, the car was towed to McGovern Hyundai Route 2, Leominster, MA (invoice 148XXX). The dealer found all 4 fuel injectors leaking and replaced them under warranty with injector service kit 35399-2S133QQH. My vehicle is outside the production range of Hyundai TSBs 23-FL-002H-1 and 26-FL-001H, which cover this injector failure only for Alabama-built Tucsons produced through July 11, 2022. Yet it failed in the same way. I am concerned the defect extends beyond the bulletin dates and that a sudden misfire could cause loss of power in traffic. There is no recall for this condition. The dealer found all 4 fuel injectors leaking, even though only cylinders 2 and 4 had set misfire codes and replaced them under warranty with injector service kit 35399-2S133QQH. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident: July 27, 2026 · Filed: September 17, 2026

See attached document for complaint.

Incident: August 28, 2026 · Filed: September 9, 2026

The car was working perfectly fine I drive it for work all the time and one day it started shaking weirdly. A couple days later the check engine light turned on. It was throwing the code that was pointing to "misfiring in the 3rd cylinder" We changed all the spark plugs, 3rd cylinder coil pack, and switch the coil pack to see if it would say a misfiring in a different cylinder. We then took it to a mechanic saying that it is the high pressure fuel injectors and that he has seen this problem with other Hyundai Tucson around the same year as us and that there was a bulletin on it.

Incident: July 20, 2026 · Filed: August 27, 2026

The right rear shock absorber failed and was replaced under warranty at approximately 22,000 miles. The car was making noise, the shock was leaking, and not working properly. The dealer admitted to problems with rear shock absorbers failing at low mileage on Hyundai Tucson Hybrid SUVs 2022 through 2025 Tucson Hybrids. The left and right rear shock absorbers are the same part number so we now expect the left side to fail but the dealer will not replace the left until it fails.

Incident: July 18, 2026 · Filed: August 7, 2026

Under Hyundai Recall 290, the dealership permanently removed the functional trailer light wiring harness and replaced it with a nonfunctional rubber dust cap. A Hyundai case manager informed me that a replacement harness is "in development," but official NHTSA remedy filings show the cap is the final remedy, resulting in the permanent loss of a factory feature I paid for. The removal of towing functionality without a clear timeline for a safe replacement parts remedy constitutes a failure to properly correct the vehicle defect.

Incident: August 6, 2026 · Filed: August 7, 2026

Emergency Brake applied while driving. Had been driving with vehicle in front, on each side and one at rear with issues and all of sudden the emergency brake was applied causing the vehicle in back to get very close to my car. This is has happened multiple times and reported to dealership multiple times. This was the second occurence on this day.

Incident: August 6, 2026 · Filed: August 7, 2026

While backing out of driveway, with parked vehicle along side and one moving vehicle in the road, I was applying the break and the Emergency Stop feature activated. My speed was 2-3 MPH and slowing.

Incident: April 1, 2025 · Filed: August 3, 2026

My client lost her right eye and suffered a brain injury when an aftermarket rhinestone emblem decal from her steering wheel shot into her face during a low-impact crash with a deer. The crash left minimal damage to the front end of the vehicle, but caused the airbags to deploy, shooting the decal into my client’s head. She purchased this dangerous decoration on Amazon, and despite NHTSA notices in 2023 and 2024 telling consumers to “avoid purchasing these steering wheel decals for all vehicle makes and models” and to “remove any such decals that they have already applied to their steering wheels,” this warning was not passed on to my client, even though records are kept of individual customer purchases, and these warnings could have been easily shared. A recent check of Amazon’s Safety Recalls and Alerts webpage did not turn up the 2024 NHTSA notice. I am sure there are other Amazon customers out there, who, like my client, have no idea just how dangerous these things are.