2021 GMC Yukon Recalls, Ratings & Complaints

Incident: October 25, 2026 · Filed: October 28, 2026

While stopped in a parking lot. I returned my vehicle to drive home, and the car would not start. I had it towed to the dealer. They did a diagnostic inspection for "crank-no-start ". Two trouble codes: P0340 intake single camshaft ignition sensor circuit and P00C6- fuel rail pressure load during engine cranking. Performed diagnostic checks and suspect a broken timing chain and timing tensioner that causes the bottom of the engine to free spin while the top 0.5 does not. These engines are known as interference engines, and anytime there is a mismatch between the top 0.5 and the bottom 0.5, there is the potential for catastrophic failure due to the design of the valve train and bottom 0.5 of the engine. The technician suggested a full engine replacement. I went to the dealer and spoke with the Service Manager, Greg, and he stated that he would reach out to GMC because the VIN number was not part of the recall, although the YEAR/MAKE/MODEL is. I also reached out to GMC to open a claim. To date, I have not heard back, and they have not yet accepted responsibility for replacing the engine.

Incident: October 23, 2026 · Filed: October 26, 2026

As I was driving down the road at 60mph, no dash lights or warnings were present. All of a sudden, my 2021 yukon lost all power and I nearly crashed as I was in heavy, fast paced traffic. I got to the side of the road, and it was at this time the engine light came on. Car died and wouldnt start back up.

Incident: August 31, 2026 · Filed: October 24, 2026

About 1 month ago while driving down the highway, my vehicle dash and screen went completely back for a few seconds and came back on. As if it shorted out

Incident: October 15, 2026 · Filed: October 23, 2026

crank/rod failure on 6.2 engine. yes it is available same as other people with blown 6.2s yes, GMC dealer diagnosed crank failure no no. engine still runs but is knocking and squealing but dies after a few mins and won't restart till it cools off

Incident: August 21, 2026 · Filed: October 20, 2026

Our 2021 GMC Yukon Denali has repeatedly experienced sudden, violent braking and apparent rear-wheel lockup without the driver applying the brakes. These incidents occur without warning at highway speeds, moderate speeds, and in traffic. The vehicle abruptly decelerates, fishtails, loses stability, and produces smoke. The wheels have locked severely enough to leave skid marks on the roadway. This creates an immediate risk of losing control or being struck by another vehicle. We took the Yukon to Alpine Buick GMC on October 12, 2026. After eight days, the dealership reported that it could not reproduce the malfunction. However, its written findings confirm that an engineering case was opened and GM engineering recommended replacing the transmission valve body based on data collected from other vehicles with related concerns. The dealership proposed approximately $3,300 in repairs without providing diagnostic evidence establishing that the valve body was definitively responsible or that replacement would resolve the dangerous condition. We declined the repair and paid $229 for diagnostics. GM recalls 24V797 and 26V085 address transmission valve failures capable of causing unexpected rear-wheel lockup. Although our gasoline-powered Yukon is excluded from these recall populations, it is exhibiting similar dangerous behavior, and GM engineering has recommended replacement of the same type of component. Exclusion from a recall based on VIN does not establish that a vehicle is free from a similar safety defect. We request that NHTSA investigate whether this failure extends to 2021 gasoline-powered Yukons and other GM vehicles outside existing recall populations. This is a recurring, unpredictable loss-of-control hazard that could result in a serious or fatal collision. It has come very close on E470 in the center lane at 75 mph with cars in all positions around us. Do you want YOUR family in one of the cars around us?

Incident: October 7, 2026 · Filed: October 20, 2026

VEHICLE: 2021 GMC Yukon, 5.3L V8 (L84). VIN: [XXX]. Mileage at failure: approximately 88,000. Component: Engine. INCIDENT DATE: XXX While I was driving on a highway, the engine began to misfire and I heard a ticking noise. The check engine light then began flashing, indicating a severe misfire. I pulled off the highway immediately to a rest area. The vehicle was towed to a GMC dealer. The dealer's diagnosis suspected failed valve lifters, and the repair orders call for a misfire diagnosis with the Bank 1 cylinder head removed, and replacement of the camshaft, lifters, and related parts. This failure caused sudden loss of engine performance at highway speed. The engine began smoking. My family and I were in the vehicle, and we were fortunate there was a safe place to stop. I believe this is a known defect. GM Service Bulletin PIP5776, "Misfire Due to Collapsed Lifter," covers 2021 GMC Yukons with the 5.3L L84 engine. It describes a misfire with a bent pushrod leading to a collapsed lifter or a lifter that comes apart, and it attributes the cause to an internal lifter concern. Many other owners of GM V8 trucks and SUVs have reported the same failure, and a class action over the AFM/DFM lifters has been pending against GM in federal court in [XXX] since 2021. I bought this vehicle new and have maintained it. This is the second time this vehicle has left my family stranded on a highway. In 2024, a separate known issue left us, including three children under [XXX], on the side of a major highway about 7 hours from home. GM repaired that issue. For the current failure, GM has not agreed to cover the repair. It has offered $5,951.39 toward an engine replacement, which would leave me responsible for $13,886.59 plus teardown labor. I am filing this complaint so NHTSA is aware of this failure, which can cause sudden loss of power on the highway. GM case number: XXX. Dealer: Fred Beans Buick GMC, [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident: October 9, 2026 · Filed: October 16, 2026

Bought 2021 GMC Yukon Denali new. Transmission failed at 70,000 miles. Engine has now failed at 111,000 miles. Both diagnosed at Capital GMC Atlanta, GA. Cost to replace transmission $8k (GMC paid half). Cost to replace engine $12k (GMC offered no assistance). Engine failure not related to current engine recall/investigation on GMC 6.2L V8 engines. This failure was on the top vs on the bottom (current recall).

Incident: September 1, 2026 · Filed: October 16, 2026

I believe it’s a transmission. While driving down the interstate and the car just won’t get up and go like it should, and I’m gonna get rear ended. I’ve I’ve taken it to the dealership three or four times. I keep telling me nothing’s wrong.

Incident: March 1, 2026 · Filed: October 13, 2026

In late February / early March 2026, at approximately 139,000 miles, my 2021 GMC Yukon Denali with the 6.2L V8 (L87) engine developed a loud knocking/rattling noise that sounded like a loose part inside the engine. The vehicle kept running, but the noise persisted. I took the vehicle to a GMC dealer. The dealer checked the VIN and told me there was no recall covering my vehicle. The engine was found to have internal damage consistent with connecting rod / bearing failure. A replacement engine was quoted at approximately $8,000. Because I could not afford that, an independent mechanic in Connecticut rebuilt the engine for approximately $5,500 in total (about $4,500 in parts plus $1,000 in labor), paid out of my own pocket. I have all the invoices for the repair. This failure appears to be the same connecting rod and crankshaft bearing defect covered by Recall 25V-274 for other 2021–2024 vehicles with the 6.2L L87 engine, but my VIN is excluded from that recall according to the dealer and the NHTSA/GM VIN lookups. No crash and no injuries occurred. I am reporting this failure so it is documented in NHTSA's investigation of L87 engines outside the recall population, and I respectfully request a review of why this VIN was excluded and whether reimbursement for the repair is possible if coverage is expanded.

Incident: October 5, 2026 · Filed: October 9, 2026

The contact owns a 2021 GMC Yukon. The contact stated that while driving, the engine started making abnormal sounds. The vehicle was towed to a dealer. The manufacturer was notified of the issue. The dealer confirmed that the vehicle had experienced lifter failure and stated that further diagnostic tests were needed to determine if the engine needed to be replaced or if the lifters only needed to be replaced. The failure mileage was approximately 69,000.