NHTSA vehicle safety data

2004 GMC Yukon Recalls, Ratings & Complaints

The 2004 GMC Yukon has 4 NHTSA recall campaigns and 159 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized GMC dealer.

NHTSA recall and complaint data for the 2004 GMC Yukon, plus NCAP crash-test ratings. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2004 GMC Yukon owner complaints

Owners have filed 159 complaints with NHTSA about the 2004 GMC Yukon, describing incidents dated January 5, 2004 to September 23, 2026.

Most-cited components

Electrical System 57 complaints
Service Brakes 36 complaints
Engine 17 complaints
Vehicle Speed Control 14 complaints
Visibility/Wiper 8 complaints
Air Bags 5 complaints

Of the 159 complaints on file, 6 report a crash and 1 a fire; across all 159 complaints, owners report 10 injuries (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11766458 · Filed September 23, 2026
The contact owns a Diono Child Safety Seat, Model Type: Radian 3R, Model Number: 50620-us-01, Manufactured Date: April 22, 2023. The contact stated that while unbuckling the child from the child seat, the buckle housing plastic part snapped. The failure occurred outside of a crash. The consumer was…
ODI #11706749 · Filed December 23, 2025
275 55r20 Sidewalls are separating like dryrotted. Bad and severe problems and have been reported to Bridgestone warranty and recall department with no actio taken at this time.
ODI #11706534 · Filed December 22, 2025
Odometer Fraud. The contact purchased a 2004 GMC Yukon. The contact stated that while attempting to trade the vehicle in, the dealer discovered that there was a mileage discrepancy, per the Carfax report. The vehicle was a dealer sale. At the time of purchase, the vehicle mileage was 165,563. The…

Read all 159 complaints

Owner-reported

2004 GMC Yukon mileage at failure

124 of the 159 complaints on file for the 2004 GMC Yukon give the vehicle's mileage when the problem happened.

Mileage at failure by component, from owners' complaints to NHTSA
Component	Median	Middle half	Based on
Electrical System	Median 70,000 miles	Middle half 50,000–95,000 miles	Based on 41 complaints
Service Brakes	Median 95,000 miles	Middle half 50,000–160,000 miles	Based on 31 complaints

A component's median is its 50th percentile, and its middle half runs from its 25th to its 75th percentile.

Owners give the mileage themselves, often as a round number, and NHTSA doesn't check it. A complaint that names several components counts under each one, and mileages that can't be right, such as 999,999, or 50 miles on a five-year-old car, are left out.

These figures describe the complaints owners filed. They don't predict when a particular vehicle will have a problem, and vehicles that never had one aren't counted.

Mileage from NHTSA's complaints file of October 31, 2026. How these figures are worked out

REPLACEMENT WHEEL HUB ASSEMBLIES

NHTSA #07E106000 · Wheels — Hub · NHTSA notice

Reported December 17, 2007 · FEDERAL-MOGUL CORPORATION

Potentially affected: 130,000 vehicles

Owners notified February 7, 2008

Defect description

CERTAIN FEDERAL-MOGUL REPLACEMENT WHEEL HUB ASSEMBLIES WITH THE BRAND NAMES: NATIONAL, CARQUEST P/NOS. 515020, 515021, 515025, 515053, 515054, 515059, AND 515060, SHIPPED BETWEEN JANUARY 23, 2006, AND DECEMBER 20, 2007, SOLD FOR LIGHT DUTY AND MEDIUM DUTY TRUCKS. THE INBOARD RETENTION NUT USED TO MAINTAIN HUB BEARING ASSEMBLY CAN LOOSEN RESULTING IN AN ABS LIGHT INDICATION, NOISE, AND/OR WHEEL SEPARATION.

Safety consequence

WHEEL SEPARATION CAN RESULT IN A VEHICLE CRASH.

Manufacturer remedy

FEDERAL-MOGUL WILL NOTIFY CUSTOMERS AND WILL REPLACE THE HUB ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 7, 2008. OWNERS CAN CONTACT FEDERAL-MOGUL TOLL-FREE AT 877-489-6659.

Notes

THIS RECALL ONLY PERTAINS TO REPLACEMENT NATIONAL, CARQUEST WHEEL HUB ASSEMBLIES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS OR FORD.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

AFTERMARKET FUEL FILTERS/FUEL LEAK

NHTSA #06E043000 · Fuel System, Gasoline · NHTSA notice

Reported May 19, 2006 · HONEYWELL INTERNATIONAL, INC.

Potentially affected: 88,303 vehicles

Owners notified October 18, 2006

Defect description

CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.

Safety consequence

THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.

Manufacturer remedy

HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

SEAT BELT ROUTING

NHTSA #05V163000 · Seat Belts — Rear/Other · NHTSA notice

Reported April 22, 2005 · GENERAL MOTORS CORP.

Potentially affected: 1,359,824 vehicles

Manufacturer campaign 05037 · Owners notified July 21, 2005 · Vehicles built April 8, 2003 – August 4, 2004 (per NHTSA)

Defect description

ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT OR BOOSTER SEAT, AS RECOMMENDED FOR SMALL CHILDREN, DOES IMPROVE THE FIT CONDITION FOR THIS USER GROUP. IN ADDITION TO INSTRUCTIONS ON PROPER INFANT AND YOUNG CHILD RESTRAINT (WITH CHILD SEATS OR BOOSTERS), SPECIAL VERBIAGE FOR RESTRAINING OLDER CHILD IS INCLUDED IN THE OWNER'S MANUAL. ALSO, THE SUGGESTED SEAT BELT FIT/ROUTING FOR ADULTS, IRRESPECTIVE OF SEATING POSITION, IS DESCRIBED IN THE OWNER'S MANUAL TEXT.

Safety consequence

A LAP PORTION OF THE SEAT BELT ROUTING THAT IS NOT LOW AND SNUG ON THE HIPS CAN ALLOW THE LAP BELT TO RIDE UP ON AN OCCUPANT'S ABDOMEN INSTEAD OF FITTING LOW AROUND THEIR HIPBONES, AND THEREFORE, CAN EXPOSE THEM TO MORE RISK OF ABDOMINAL AND INTERNAL ORGAN INJURY.

Manufacturer remedy

DEALERS WILL CUT OPEN THE GUIDE LOOP, REMOVE A PORTION OF THE LOOP, AND THEN THE REMAINING TWO SIDES SHOULD BE FOLDED OVER AND SECURED WITH A RETAINER FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR HUMMER AT 1-800-732-5493.

Notes

GM RECALL NO. 05037.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

GM/FMVSS 135/BRAKE VALVE

NHTSA #04V045000 · Service Brakes, Hydraulic · NHTSA notice

Reported February 4, 2004 · GENERAL MOTORS CORP.

Potentially affected: 68,875 vehicles

Manufacturer campaign 04004 · Owners notified June 18, 2004 · Vehicles built May 1, 2003 – June 30, 2003 (per NHTSA)

Defect description

CERTAIN SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND PASSENGER VANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, ?PASSENGER CAR BRAKE SYSTEMS.? SOME OF THESE VEHICLES WERE PRODUCED WITH AN OUT-OF-SPECIFICATION BRAKE HYDRO-BOOST HOUSING RELIEF VALVE BORE.

Safety consequence

CONSEQUENTLY, THE VALVE O-RING SEAL MAY FRACTURE. STEERING EFFORTS MAY BE SLIGHTLY INCREASED WHILE BRAKING OR PARKING. UNDER CERTAIN DRIVING CONDITIONS, A FRACTURED SEAL MAY REQUIRE A SLIGHT INCREASE IN THE APPLIED BRAKE PEDAL EFFORT TO ACHIEVE THE SAME VEHICLE DECELERATION RATE AS PRIOR TO THE SEAT FRACTURE.

Manufacturer remedy

DEALERS ARE TO REPLACE THE HYDRO-BOOST RELIEF VALVE. THE RECALL BEGAN ON JUNE 18, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339; CHEVROLET AT 1-800-630-2438; GMC AT 1-866-996-9463; OR HUMMER AT 1-866-486-6376.

Notes

GM RECALL NO. 04004.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

2004 GMC Yukon 4-DR.

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 4, Passenger: 4

Side Crash

Not Rated

Driver: Not Rated, Passenger: Not Rated

Side Pole

Not Rated

Rollover

26% rollover risk

Safety Technology

159 owner complaints have been filed with NHTSA for the 2004 GMC Yukon.

Child Seat

ODI #11766458

Incident: September 23, 2026 · Filed: September 23, 2026

The contact owns a Diono Child Safety Seat, Model Type: Radian 3R, Model Number: 50620-us-01, Manufactured Date: April 22, 2023. The contact stated that while unbuckling the child from the child seat, the buckle housing plastic part snapped. The failure occurred outside of a crash. The consumer was concerned about the structural integrity and that the fractured plastic piece compromised the restraint system, and the car seat would not perform as needed in a crash. The manufacturer was notified of the failure and informed the contact to purchase a replacement buckle.

Tires

ODI #11706749

Incident: November 21, 2025 · Filed: December 23, 2025

275 55r20 Sidewalls are separating like dryrotted. Bad and severe problems and have been reported to Bridgestone warranty and recall department with no actio taken at this time.

Electrical System

ODI #11706534

Incident: December 19, 2025 · Filed: December 22, 2025

Odometer Fraud. The contact purchased a 2004 GMC Yukon. The contact stated that while attempting to trade the vehicle in, the dealer discovered that there was a mileage discrepancy, per the Carfax report. The vehicle was a dealer sale. At the time of purchase, the vehicle mileage was 165,563. The actual mileage could not be determined because the Carfax report displayed that the mileage had drastically fluctuated over the years. No other agency was contacted.

Service Brakes

ODI #11674854

Incident: July 20, 2025 · Filed: July 20, 2025

My vehicle is supposed to have a sensor wire for a break master cylinder and it doesn’t

Electrical System; Engine

ODI #11646587

Incident: April 2, 2019 · Filed: March 5, 2025

The contact owns a 2004 GMC Yukon. The contact stated while driving 45 MPH, the vehicle started losing motive power. The check engine warning light and another unknown warning light were illuminated, and a message was displayed that the gas port was reducing power. On a separate occasion, the vehicle started to lose motive power and then the vehicle started to shake. The vehicle was losing power and shaking until the vehicle was turned off. The vehicle was restarted and drove normally for six months without failure. The vehicle was taken to an independent mechanic where it was diagnosed with throttle body failure; however, the failure persisted. The vehicle was repaired but the failure persisted three more times with different diagnoses. The vehicle was taken to other independent mechanics however, the cause for the failure was not yet determined. The vehicle was not repaired for the most recent failure. The dealer was not made aware of the failure. The manufacturer was made aware of the failure. The failure mileage was approximately 123,000.

Electrical System; Vehicle Speed Control; Engine

ODI #11561610

Incident: August 17, 2023 · Filed: December 23, 2023

It is just like the the service bulletin out for the 2006 and later gmc sierra except it’s for a 2004 gmc Yukon slt 4x4 4.8L. It is going into reduced engine power mode and it has to do with the throttle actuator control module. Throws code P2108

Electrical System; Service Brakes; Engine

ODI #11419417

Incident: May 31, 2021 · Filed: June 2, 2021

My kids and I was on the interstate and all of sudden my yukon reduce engine power.Dropping to 30 in a speed zone of 70.I was very afraid for our safety and appreciate there concerns for reducing engine power to save the truck,but that's very dangerous. So I paid to replace the throttle body and gas pedal cause that was the codes for the problem. But it's still doing the same thing and I don't have money to keep buying parts.Plus it a gm problem and I really need some help with the fixture..

Electrical System

ODI #11386256

Incident: January 5, 2004 · Filed: January 3, 2021

GM IGNITION SWITCH RECALL: GMC REFUSES TO HONOR THE RECALL AND FIX THIS ISSUE ON BOTH MY SUV'S. I CAN'T BE PART OF THE CLASS ACTION UNTIL THESE REPAIRS HAVE BEEN MADE, WHAT A SCAM. I OWN 2 GMC YUKON'S SLT AND BOTH QUALIFY FOR THE RECALL WHICH I WAS NEVER NOTIFIED OF FROM GMC. NEITHER CAR EVER GOT REPAIRED. THE MANUFACTURE AND LOCAL DEALERSHIPS REFUSED TO DO THE REPAIRS AT NO COST. THIS IS AFTER I PAID THESE [XXX] OVER $1000 TO FIX THIS PROBLEM ON ONE OF MY SUV'S MANY YEARS AGO WHICH DID NOT GET FIXED BECAUSE THEY CLAIM THEY COULDN'T FIND WHAT WAS WRONG WITH MY SUV'S BUT THEY KNEW ALL ALONG. I WANT GM TO HONOR THEIR LEGAL OBLIGATIONS AND FIX MY SUV'S FAULTY IGNITION SYSTEM. I ONLY FOUND OUT THAT THERE WAS A RECAL FROM THE CLASS ACTION ATTORNEYS. GM NEVER NOTIFIED ME OF ANY RECALLS EVER!! PLEASE HELP. THANK YOU. [XXX] PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

Electrical System

ODI #11331310

Incident: May 4, 2020 · Filed: June 28, 2020

THE INSTRUMENT PANEL LIGHT INDICATING WHAT GEAR THE TRANSMISSION IS IN IS OUT AND THEREFORE DRIVER CANNOT TELL WHICH GEAR THE VEHICLE IS IN, AND EXTREME SAFETY HAZARD.

Service Brakes

ODI #11307318

Incident: August 17, 2018 · Filed: February 5, 2020

TL* THE CONTACT OWNS A 2004 GMC YUKON. THE CONTACT STATED THE VEHICLE DOES NOT STOP WHEN THE BRAKE PEDAL WAS DEPRESSED. THE CONTACT WAS DRIVING ABOUT 45 MPH. THE VEHICLE WAS TAKEN TO SEARS (3655 SW 22ND ST, CORAL GABLES, FL 33145. MIAMI, FLORIDA) WHERE THE VEHICLE WAS REPAIRED. THE FAILURE RECURRED AFTER THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS UNKNOWN.

Other GMC Yukon model years

Check your 2004 GMC Yukon VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your GMC Yukon at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a GMC VIN