2001 GMC Sierra 3500 Recalls & Complaints

Incident: August 21, 2018 · Filed: October 25, 2018

SOLD ME A "GOOD RUNNING VEHICLE" THAT THE FUEL SYSTEM FAILED CAUSE ENGINE TO SHUTDOWN, CAUSED NO BRAKING, VEHICLE PULLED OUT OF CENTER DO TO STEERING COMPONENTS, NO SAFETY BELTS IN REAR OF VEHICLE

Incident: May 12, 2016 · Filed: May 12, 2016

I ALMOST RAN INTO ANOTHER CAR BECAUSE THE OTHER DRIVER STOPPED SUDDENLY AND I HAD TO PUMP THE BRAKES OVER AND OVER TO STOP WHEN THE RUSTED LINE BROKE. I WAS ON A CITY STREET DRIVING SPEED LIMIT AND WAS LUCKY TO BE ABLE TO STOP. I WAS TOWING MY TRAILER LAST WEEK AND ALMOST LOST THE TRAILER BECAUSE THE ENTIRE UNDERBODY IS RUSTED. I HAVE HAD SEVERAL TRUCKS AND NEVER HAVE SEEN THIS HAPPEN. IT WAS A SCARY SITUATION IN BOTH CASES.

Incident: October 10, 2014 · Filed: November 7, 2014

BRAKE LINE RUPTURED LEADING TO COMPLETE LOSS OF BRAKING. HIT CAR IN FRONT OF ME AS IT CAME TO A STOP. THIS IS THE SECOND TIME THAT THE BRAKES HAVE FAILED DUE TO BRAKE LINE RUPTURE DUE TO EXCESSIVE CORROSION OF THE BRAKE LINE METAL. PLEASE FORCE GM TO ISSUE A RECALL. *TR

Incident: October 7, 2009 · Filed: July 18, 2014

TL* THE CONTACT OWNS A 2001 GMC 3500. THE CONTACT STATED THAT WHILE DRIVING 10 MPH, THE ENGINE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER, WHO DIAGNOSED THAT THE INJECTION PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE RECURRED TWO YEARS LATER. THE DEALER STATED THAT THE INJECTION PUMP NEEDED TO BE REPLACED AGAIN. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 19,000.

Incident: May 13, 2014 · Filed: May 14, 2014

THREE WEEKS AGO NOTICED LOW BRAKE FLUID. FILLED RESERVOIR AND DIDN'T SEE AND LEAKS. YESTERDAY I WAS IN TOWN SHOPPING AND WHEN I CAME OUT OF STORE AND LEAVING BRAKE PEDDLE WENT TO FLOOR WHEN I TRIED TO STOP HAD ENOUGH BRAKE TO STOP BEFORE HITTING CAR IN FRONT OF ME. BOUGHT A QUART OF FLUID AND REFILLED TANK AND CAUTIOUSLY MADE IT THE 25 MILES HOME AFTER REFILLING TWICE. LOOKED UNDER TRUCK AND SAW LEAK ABOVE THE FUEL FILTER. THE WHOLE LINE UNDER TRUCK IS TERRIBLY CORRODED AND WILL NEED REPLACING. I LIVE IN HAWAII AND HAVE HAD THE TRUCK FOR 5 YEARS SO NO SALT DAMAGE HERE. *TR

Incident: September 6, 2013 · Filed: September 9, 2013

MY 2001 GMC SIERRA 3500 WITH A 8.1L V8 ENGINE STALLED WHILE ON THE FREEWAY. IT WOULD NOT RESTART UNTIL A "COOL" DOWN PERIOD. THIS PROBLEM SURFACED AS NOT BEING ABLE TO START THE ENGINE AFTER IT HAD RUN AND THEN SET FOR 30 - 60 MINUTES AND WOULD NOT START UNTIL SEVERAL ATTEMPTS WERE MADE TO START IT. THIS HAS BEEN AN ONGOING PROBLEM FOR THE LAST YEAR AND HAS PROGRESSED TO THE STALL ON THE FREEWAY. I WAS FINALLY ABLE TO GET AN ENGINE FAILURE CODE FROM THE VEHICLE LISTED AS CRANKSHAFT POSITION SENSOR FAILURE. UPON DOING SOME RESEARCH I FOUND THE RECALL FROM GMC (06083 -- CRANKSHAFT POSITION SENSOR ENGINE STALL) AND CALLED THE DEALER WHICH INFORMED ME THAT MY VIN WAS NOT COVERED UNDER THE RECALL. I THEN CALLED GMC'S CUSTOMER SERVICE AND EXPLAINED THAT I'M HAVING THE EXACT PROBLEMS LISTED ON THE EXACT VEHICLE WITH THE EXACT ENGINE LISTED. ALSO I HAVE SINCE FOUND 3 OTHER COMPLAINTS WITH NHTSA OF THIS EXACT SAME PROBLEM ON OTHER VEHICLES THAT WERE NOT COVERED. IT IS EVIDENT TO ME THAT THIS PROBLEM EXISTS BEYOND THE BLOCK OF VIN'S GMC RECALLED AND SHOULD BE EXTENDED TO COVER THESE OTHER VEHICLES. GMC DOES NOT SEEM TO BE INTERESTED IN EXTENDING THIS RECALL AND IT SHOULD BE LOOKED INTO AS A VEHICLE STALLING ON THE FREEWAY IS AN EXTREMELY DANGEROUS SITUATION THAT SHOULD BE RESOLVED. *TR

Incident: July 13, 2012 · Filed: July 23, 2012

BRAKES FAILED DUE TO RUPTURE OF RUSTED BRAKE LINE, NO WARNING LIGHT WHILE DRIVING ON THE INTERSTATE. WAS BARELY ABLE TO STOP BY PRESSING BRAKE PEDAL TO THE FLOOR. ABS DID NOT ACTIVATE. TOOK VEHICLE TO MECHANIC. MULTIPLE BRAKE LINES RUSTED OUT. *TR

Incident: October 13, 2011 · Filed: October 25, 2011

EXHAUST MANIFOLD BOLTS BROKE ON DRIVER SIDE, BACK TWO. THESE BOLTS ARE FAR TOO SMALL FOR THE JOB AND THIS EXPOSES HEAT AND EXHAUST GASES TO THE ENVIRONMENT. CREATING A FIRE DANGER TOO. *TT

Incident: January 1, 2011 · Filed: January 21, 2011

WHILE DRIVING I HAD MY BRAKES FAIL, THE PEDAL WENT TO THE FLOOR. IT WAS A RESULT OF A BROKEN STEEL BRAKE LINE UNDER THE DRIVERS SEAT. WHAT I FOUND WHEN I LOOKED UNDER THE TRUCK WAS ALL THE LINES THAT WENT TO THE ABS UNIT WERE BADLY RUSTED. ONE OF MY COWORKERS HAD THE SAME PROBLEM ON HIS 2001 GMC SUBURBAN BUT HE CHUCKED IT UP TO ALL THE CAMPING TRIPS HE WENT ON WHERE HE LEFT HIS TRUCK PARKED OFF ROAD. MY TRUCK HOWEVER ONLY HAS 30,000 MILES AND IT HAS NEVER BEEN TAKEN OFF ROAD. I ALSO FLUSH THE BRAKE FLUID ONCE A YEAR AS PREVENTATIVE MAINTENANCE, SO THEY CAN'T CLAIM THEY RUSTED FROM THE INSIDE OUT. I DRIVE MY TRUCK EVERY DAY TO WORK ABOUT ONE MILE AWAY. MY DRIVEWAY IS PAVED AND THE PARKING LOT AT MY PLACE OF WORK IS ALSO PAVED. I DON'T PULL ANY HEAVY TRAILERS OR DO ANYTHING ELSE THAT WOULD CONTRIBUTE TO THE LINE FAILURE. I AM NOT PUTTING DOWN GM PRODUCTS BECAUSE ALL MY VEHICLES ARE GM VEHICLES INCLUDING TWO ANTIQUES. ONE A 1955 CHEVY WHICH HAD ORIGINAL BRAKE LINES UNTIL I DID A DISC BRAKE CONVERSION SEVERAL YEARS BACK. THE OTHER A 1970 CHEVELLE WHICH IS CURRENTLY A RESTORATION PROJECT BUT THE LINE ARE STILL ORIGINAL. THERE IS OBVIOUS A PROBLEM WITH THE MATERIAL USED TO MAKE THESE LINES. I WAS RESEARCHING THE PROBLEM ONLINE AND IT APPEARS THAT THERE ARE TO MANY OTHER PEOPLE WITH THE SAME PROBLEM. ALSO GM NO LONGER SELLS THE LINES WHICH MAKES IT A MUCH MORE TROUBLESOME REPAIR. I ALSO DON'T OWN A BOAT, JET SKI OR ANYTHING ELSE THAT WOULD REQUIRE ME TO PUT MY VEHICLE IN SALT WATER.

Incident: August 20, 2010 · Filed: August 25, 2010

AFTER EXPERIENCING ABS BRAKING PROBLEMS ON MY 2001 GMC TRUCK MODEL NK3, I BECAME AWARE OF GM RECALL NO. 05068, 05V379000, WHICH THE LOCAL DEALER SAYS THIS ISSUE DOES NOT INVOLVE MY VEHICLE. FOR SAFETY REASONS, I DID REPAIR THE PROBLEM. *TR