try.vin
Log in

NHTSA vehicle safety data

2005 GMC Sierra 3500 Recalls & Complaints

The 2005 GMC Sierra 3500 has 1 NHTSA recall campaign and 24 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized GMC dealer.

NHTSA recall and complaint data for the 2005 GMC Sierra 3500. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2005 GMC Sierra 3500 owner complaints

Owners have filed 24 complaints with NHTSA about the 2005 GMC Sierra 3500, describing incidents dated July 17, 2005 to September 12, 2024.

Most-cited components

  • Service Brakes 9 complaints
  • Steering 5 complaints
  • Electrical System 3 complaints
  • Engine 3 complaints
  • Tires 2 complaints
  • Equipment 1 complaint

Of the 24 complaints on file, 1 reports a fire (owner-reported, not verified by NHTSA).

Newest complaints

  • ODI #11614819 · Filed

    The contact owns a 2005 GMC Sierra 3500. The contact stated that while driving at an undisclosed speed, the vehicle failed to come to a stop while the brake pedal was depressed. The contact stated that the brake pedal felt loose. The ABS warning light was illuminated. The contact was able to bring…

  • ODI #11012979 · Filed

    I HAVE HAD THE LOWER STEERING ARM REPLACED THREE TIMES DUE TO A BAD BUSHING. ONCE UNDER WARRANTY & TWICE I HAD TO PAY FOR IT WHICH IS OVER $300.00 EACH TIME. THIS IS NOT AN UNCOMMON PROBLEM WITH THE CHEVROLET & GMC TRUCKS. THIS IS ONLY NOTICEABLE WHILE IN MOTION.

  • ODI #10904906 · Filed

    TL* THE CONTACT OWNS A 2005 GMC SIERRA 3500. WHEN THE BRAKE PEDAL WAS DEPRESSED AT 20 MPH, THE VEHICLE HESITATED TO RESPOND WITHOUT WARNING. AFTER INSPECTING THE VEHICLE, IT WAS DISCOVERED THAT THE BRAKE LINES WERE CORRODED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE…

Read all 24 complaints

AFTERMARKET FUEL FILTERS/FUEL LEAK

NHTSA #06E043000 · Fuel System, Gasoline · NHTSA notice

Reported May 19, 2006 · HONEYWELL INTERNATIONAL, INC.

Potentially affected: 88,303 vehicles

Owners notified October 18, 2006

Defect description

CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.

Safety consequence

THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.

Manufacturer remedy

HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

Other GMC Sierra 3500 model years

Check your 2005 GMC Sierra 3500 VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your GMC Sierra 3500 at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a GMC VIN