NHTSA vehicle safety data

2000 GMC Sierra 2500 Recalls & Complaints

The 2000 GMC Sierra 2500 has 3 NHTSA recall campaigns and 48 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized GMC dealer.

NHTSA recall and complaint data for the 2000 GMC Sierra 2500. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2000 GMC Sierra 2500 owner complaints

Owners have filed 48 complaints with NHTSA about the 2000 GMC Sierra 2500, describing incidents dated November 1, 1999 to July 5, 2026.

Most-cited components

Service Brakes 32 complaints
Structure 5 complaints
Engine 4 complaints
Electrical System 3 complaints
Steering 3 complaints
Suspension 3 complaints

Of the 48 complaints on file, 3 report a crash and 1 a fire; across all 48 complaints, owners report 4 injuries (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11749361 · Filed July 9, 2026
The contact owns a 2000 GMC Sierra 2500. The contact stated that the spare tire detached from the vehicle after the cable securing the spare tire fractured. The contact discovered the failure upon returning to the residence from an errand and found the spare tire in the driveway. No warning lights…
ODI #11076167 · Filed March 4, 2018
WHILE DRIVING THE BRAKE AND ABS LIGHTS ON THE INSTRUMENT PANEL LIGHT UP. THIS HAS OCCURRED WHILE DRIVING OF THE FREEWAY AND ON CITY STREETS. SOMETIMES THESE LIGHTS GO OFF AND SOMETIMES THEY REMAIN LIGHTED. WHEN THIS HAPPENS I FEAR THAT THERE IS A PROBLEM WITH THE BRAKES AND HAVE TAKEN THIS MATTER TO…
ODI #11052382 · Filed December 4, 2017
I PURCHASED THIS TRUCK USED AND WAS ABLE TO USE FOR A BOUT A MONTH BEFORE BOTH REAR SPRING PERCHES BROKE ALLOWING THE SPRINGS TO REST UNDER THE PICKUP BODY, AFTER REPLACING THEM THE BRAKE LINES RUPTURED BECAUSE OF RUST ANOTHER POOR QUALITY PRODUCT FROM GM !

Read all 48 complaints

NHTSA defect investigations

NHTSA's investigations file lists the 2000 GMC Sierra 2500 in 1 investigation. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Preliminary Evaluation PE04-004: HYDRAULIC PUMP SHAFT FAILURES
Closed April 30, 2004

Open and recently closed NHTSA defect investigations

OIL FILTER/OIL LEAK/POSSIBLE FIRE

NHTSA #07E088000 · Equipment · NHTSA notice

Reported October 24, 2007 · HONEYWELL INTERNATIONAL, INC.

Potentially affected: 121,680 vehicles

Owners notified November 8, 2007

Defect description

CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.

Safety consequence

THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.

Manufacturer remedy

HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.

Notes

CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

AFTERMARKET FUEL FILTERS/FUEL LEAK

NHTSA #06E043000 · Fuel System, Gasoline · NHTSA notice

Reported May 19, 2006 · HONEYWELL INTERNATIONAL, INC.

Potentially affected: 88,303 vehicles

Owners notified October 18, 2006

Defect description

CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.

Safety consequence

THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.

Manufacturer remedy

HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

GM/FMVSS 105/BRAKE HOSE

NHTSA #00V222000 · Service Brakes, Hydraulic — Power Assist — Vacuum · NHTSA notice

Reported August 8, 2000 · GENERAL MOTORS CORP.

Potentially affected: 3,758 vehicles

Manufacturer campaign 00051 · Owners notified September 22, 2000 · Vehicles built September 1, 1999 – December 31, 1999 (per NHTSA)

Defect description

VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH VACUUM POWER, 4-WHEEL DISC BRAKES. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 105, "HYDRAULIC BRAKE SYSTEMS." THESE VEHICLES WERE BUILT WITH A KINKED BRAKE BOOSTER VACUUM SUPPLY HOSE.

Safety consequence

THESE VEHICLES DO NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 105.

Manufacturer remedy

DEALERS WILL RE-ROUTE THE BRAKE BOOSTER VACUUM SUPPLY HOSE.

Notes

OWNER NOTIFICATION BEGAN SEPTEMBER 22, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

try.vin has no NCAP crash-test rating on file for the 2000 GMC Sierra 2500. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

48 owner complaints have been filed with NHTSA for the 2000 GMC Sierra 2500.

Equipment

ODI #11749361

Incident: July 5, 2026 · Filed: July 9, 2026

The contact owns a 2000 GMC Sierra 2500. The contact stated that the spare tire detached from the vehicle after the cable securing the spare tire fractured. The contact discovered the failure upon returning to the residence from an errand and found the spare tire in the driveway. No warning lights illuminated, and no unusual sounds occurred prior to the failure. The contact expressed concern that the detached spare tire could become a road hazard and increase the risk of a crash. The vehicle was not taken to a dealer. The manufacturer was not notified of the failure. The failure mileage was approximately 178,000.

Electrical System; Service Brakes

ODI #11076167

Incident: December 23, 2017 · Filed: March 4, 2018

WHILE DRIVING THE BRAKE AND ABS LIGHTS ON THE INSTRUMENT PANEL LIGHT UP. THIS HAS OCCURRED WHILE DRIVING OF THE FREEWAY AND ON CITY STREETS. SOMETIMES THESE LIGHTS GO OFF AND SOMETIMES THEY REMAIN LIGHTED. WHEN THIS HAPPENS I FEAR THAT THERE IS A PROBLEM WITH THE BRAKES AND HAVE TAKEN THIS MATTER TO A MECHANIC. THE BRAKES WERE EXAMINED AND HE FOUND NOTHING WRONG. THIS IS VERY STARTLING TO THE DRIVER AND OF GREAT CONCERN. THIS APPEARS ON INTERNET SEARCHES AND IT APPEARS THAT 100,000 PLUS INDIVIDUALS HAVE THIS PROBLEM. I HAVE CONTACTED THE DEALER AND OBVIOUSLY THIS MATTER HAS BEEN BROUGHT TO THERE ATTENTION. YET THEY CLAIM THEY ARE UNFAMILIAR AND WANT TO CHARGE $600 TO DIAGNOSE AND THEN LIKELY MORE TO FIX. THIS IS OBVIOUSLY A LIE AS THERE IS NO WAY THAT ONE COULD BE READING SO MUCH ABOUT THIS ON THE INTERNET IF IT WAS NOT A PROBLEM IN THE GMC SIERRA TRUCKS. SOME CLAIM IT IS A FAULTY CIRCUIT BOARD WHILE OTHERS HAVE LOST THE USE OF THEIR BRAKES. THIS IS OF GREAT CONCERN. THIS OCCURS WHILE DRIVING AND THE VEHICLE IS IN MOTION AND SOMETIMES AT HIGH SPEEDS ON A FREEWAY.

Suspension; Service Brakes

ODI #11052382

Incident: August 30, 2017 · Filed: December 4, 2017

I PURCHASED THIS TRUCK USED AND WAS ABLE TO USE FOR A BOUT A MONTH BEFORE BOTH REAR SPRING PERCHES BROKE ALLOWING THE SPRINGS TO REST UNDER THE PICKUP BODY, AFTER REPLACING THEM THE BRAKE LINES RUPTURED BECAUSE OF RUST ANOTHER POOR QUALITY PRODUCT FROM GM !

Service Brakes

ODI #11016132

Incident: August 17, 2017 · Filed: August 18, 2017

BRAKE LINES RUSTED TO POINT OF REPLACEMENT

Structure

ODI #10970893

Crash

Incident: January 1, 2017 · Filed: April 6, 2017

GMC TRUCK FRAMES CRACKING, ROTTING OUT, BRAKING DUE TO POOR DESIGN AND COATING AND GM WON'T STEP UP AND TAKE RESPONSIBILITY AS TOYOTA HAS. THE CONSUMER GETS AN UNSAFE VEHICLE BECAUSE OF FRAMES GIVING OUT WELL BEFORE THE BODY, THE FRAMES SHOULD BE STRONG. IN UNDER 2 YEARS THE FRAME WENT FROM STRONG AND SAFE TO NOW RUSTED UP SCRAP METAL. AMERICAN QUALITY SHOULD BE OF GREAT STANDARDS IN MY UP MOST OPINION BEING AN ARMY VETERAN. GENERAL MOTORS SHOULD COMPANSATE OWNERS OR BUY THEM BACK AS TOYOTA HAS.

Suspension; Structure; Service Brakes

ODI #10881739

Incident: October 23, 2000 · Filed: June 30, 2016

TL* THE CONTACT OWNS A 2000 GMC SIERRA 2500. WHILE DRIVING APPROXIMATELY 35 MPH, THE REAR OF THE VEHICLE SLIGHTLY LOWERED TOWARDS THE GROUND. THE VEHICLE WAS DRIVEN WITH CAUTION TO THE CONTACT'S RESIDENCE. THE CONTACT INSPECTED THE VEHICLE AND NOTICED THAT THAT THE DRIVER SIDE MAIN FRAME RAIL WAS FRACTURED IN THE CENTER. ADDITIONALLY, THE PASSENGER SIDE MAIN RAIL WAS PARTIALLY FRACTURED. THE FAILURE WAS BEYOND REPAIR. THE CONTACT MENTIONED THAT THE BRAKE LINE AND REAR CROSS MEMBER NEAR THE FUEL TANK WERE COMPLETELY CORRODED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 92,000.

Service Brakes

ODI #10678693

Incident: January 21, 2015 · Filed: January 24, 2015

I WAS TURNING AROUND IN MY DRIVEWAY, WHEN SUDDENLY THE BRAKE PEDDLE WENT TO THE FLOOR AND ALL BRAKING POWER WAS LOST. TRIED PUMPING THE BRAKES MULTIPLE TIMES WITH NO SUCCESS. THERE WAS NO WARNING (LIGHTS OR OTHERWISE) BEFORE THE INCIDENT, AND NO DASH LIGHTS LIT DURING THE INCIDENT EITHER. *TR

Steering; Suspension; Structure

ODI #10597059

Incident: June 2, 2014 · Filed: June 9, 2014

FRONT CROSSMEMBER WELDS SEVERELY RUSTED AND ROTTED OUT. CROSSMEMBER ABOUT READY TO BREAK LOOSE FROM FRAME. FRONT FRAME RAILS SEVERELY RUSTED AND ROTTED OUT. FRONT SUSPENSION PARTS SEVERELY RUSTED AND ROTTING AWAY. REAR FRAME SEVERELY RUSTED AND ROTTED OUT. SHOCK MOUNTS ABOUT READY TO BREAK LOOSE FROM FRAME. ABSOLUTELY UNACCEPTABLE AND PATHETIC FOR A 13 YEAR OLD, 32,000 DOLLAR TRUCK TO BE UN-DRIVABLE AND IN THIS CONDITION. *TR

Engine and Engine Cooling

ODI #10578313

Fire

Incident: March 12, 2014 · Filed: April 8, 2014

I BEEN HAVING A PROBLEM WITH THE EXHAUST MANIFOLD BOLTS BREAKING OFF. I SPENT A TON OF MONEY REPLACING O2 SENSORS OVER THE LAST 4 YEARS. I'VE JUST CURRENTLY FOUND OUT THAT THE O2 SENSORS WERE NOT BAD, IT WAS ACTUALLY THE EXHAUST HEADER BOLTS BREAKING ALLOWING MY EMISSION SYSTEM TO MALFUNCTION. I'VE HAD 3 BOLTS REPLACED 2 MONTHS AGO AT A TIDY COST OF $1000.00. ONE WEEK AGO I WAS DRIVING DOWN THE ROAD AND SMELLED EXHAUST FUMES IN MY TRUCK CAB. I TOOK MY TRUCK TO MY MECHANIC AND HE FOUND 3 MORE BOLTS ON THE RIGHT SIDE OF THE ENGINE BROKEN OFF. NOT ONLY AM I WITHOUT A VEHICLE (BECAUSE AT THIS TIME I CANNOT AFFORD THE REPAIR) I THINK GENERAL MOTORS SHOULD CORRECT MY PROBLEM AND PAY FOR PREVIOUS REPAIRS. THIS IS POOR WORKMAN SHIP ON THEIR PART NOT TO MENTION A SERIOUS SAFETY HAZARD. ALL GM TRUCKS MANUFACTURED BETWEEN 1999 AND 2007 WITH V-8 ENGINES HAVE THIS PROBLEM. GM SHOULD MAN UP TO THIS ISSUE AND RECALL AND REPAIR THE FAULTY EXHAUST MANIFOLD BOLT PROBLEM. I FOR ONE THINK THIS COULD BE A SAFETY ISSUE AND ENVIRONMENTAL CONCERN. MY TRUCK CANNOT PASS AN ENVIRONMENTAL EMISSIONS TEST AT THIS TIME. *TR

Service Brakes, Hydraulic

ODI #10567236

Incident: October 8, 2013 · Filed: February 27, 2014

I WAS RETURNING HOME FROM LEXINGTON KY WHEN I CAME AROUND A CURVE THERE WERE TWO DEER IN THE ROAD. I HIT THE BRAKES HARD AND THE PEDAL WENT TO THE FLOOR. I HIT ONE OF THE DEER WITH A GLANCING BLOW. THERE WAS NO DAMAGE TO MY TRUCK AND THE DEER RAN AWAY. THANK GOD I WAS NOT IN LEXINGTON WHEN THIS HAPPENED AND THE DEER WAS NOT A CHILD. I AM 72 YEARS OLD AND I DON'T HAVE THE MONEY OR THE ENERGY TO MAKE THIS REPAIR. LAST YEAR MY SON WAS BACKING HIS 2001 SILVERADO TO THE LAKE TO LOAD A BOAT WHEN THIS SAME THING HAPPENED. THE TRUCK WENT INTO THE WATER UP TO THE CAB BEFORE HE GOT IT INTO ANOTHER GEAR. AFTER A 1100.00 REPAIR HE TRADED FOR A FORD. GENERAL MOTORS NEEDS TO BE HELD ACCOUNTABLE FOR THIS DEFECT

Other GMC Sierra 2500 model years

Check your 2000 GMC Sierra 2500 VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your GMC Sierra 2500 at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a GMC VIN