NHTSA vehicle safety data

2002 Ford E-150 Recalls & Complaints

The 2002 Ford E-150 has 3 NHTSA recall campaigns and 28 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Ford dealer.

NHTSA recall and complaint data for the 2002 Ford E-150. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2002 Ford E-150 owner complaints

Owners have filed 28 complaints with NHTSA about the 2002 Ford E-150, describing incidents dated April 23, 2002 to June 21, 2024.

Most-cited components

Service Brakes 5 complaints
Electrical System 3 complaints
Engine 3 complaints
Fuel/Propulsion System 3 complaints
Power Train 3 complaints
Steering 3 complaints

Of the 28 complaints on file, 1 reports a crash and 3 a fire; across all 28 complaints, owners report 1 injury (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11595957 · Filed June 23, 2024
My power steering and brakes went out as I was driving. I was making a turn in town, and I almost collided with another car at the intersection. I pushed the brakes as hard as I could, but it didn't slow down, the car just eventually rolled to a stop on its own. The exact cause is unknown, but it…
ODI #11575938 · Filed March 7, 2024
The contact owns a 2002 Ford E-150. The contact stated while driving at approximately 75 MPH, he smelled a burning odor in the passenger cabin. The contact stated that he turned the A/C on to help clear the cabin. The contact stated that he noticed smoke was being emitted from the driver's side rear…
ODI #11385180 · Filed December 28, 2020
IN A PARKING LOT, I WENT TO TURN LEFT, HEARD A LOUD CLUNK AND THE VAN JUST WENT STRAIGHT. LOST ALL STEERING CONTROL. LUCKILY THIS HAPPENED IN A PARKING LOT AND NOT ON THE ROAD AT HIGHER SPEED. IF THIS HAD OCCURRED AT SPEED, I WOULD HAVE HIT ONCOMING TRAFFIC , OR GONE OFF THE ROAD INTO WHO KNOWS…

Read all 28 complaints

NHTSA defect investigations

NHTSA's investigations file lists the 2002 Ford E-150 in 1 investigation. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Defect Petition DP05-005: SPARK PLUG EJECTION FROM CYLINDER HEAD
Closed January 4, 2006

Open and recently closed NHTSA defect investigations

SPEED CONTROL DEACTIVATION SWITCH/OVERHEATS

NHTSA #09V399000 · Vehicle Speed Control · NHTSA notice

Reported October 13, 2009 · FORD MOTOR COMPANY

Potentially affected: 4,500,000 vehicles

Ford campaign 09S09 · Owners notified October 27, 2009 · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Safety consequence

A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.

Manufacturer remedy

FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.

Notes

FORD'S RECALL CAMPAIGN NUMBER IS 09S09.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

SPEED CONTROL DEACTIVATION SWITCH

NHTSA #08V051000 · Vehicle Speed Control — Cruise Control · NHTSA notice

Reported February 4, 2008 · FORD MOTOR COMPANY

Potentially affected: 225,000 vehicles

Ford campaign 08S01 · Owners notified February 18, 2008 · Vehicles built September 3, 1991 – September 15, 2003 (per NHTSA)

Defect description

FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.

Safety consequence

AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.

Manufacturer remedy

DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.

Notes

FORD RECALL NO. 08S01.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

SPEED CONTROL DEACTIVATION SWITCH

NHTSA #07V336000 · Vehicle Speed Control · NHTSA notice

Reported August 3, 2007 · FORD MOTOR COMPANY

Potentially affected: 3,600,000 vehicles

Ford campaign 05S28 · Owners notified August 13, 2007 · Vehicles built April 9, 1996 – August 2, 2002 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Safety consequence

THIS COULD RESULT IN AN UNDERHOOD FIRE.

Manufacturer remedy

DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.

Notes

FORD RECALL NO. 05S28.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION;S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

try.vin has no NCAP crash-test rating on file for the 2002 Ford E-150. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

28 owner complaints have been filed with NHTSA for the 2002 Ford E-150.

Steering; Service Brakes

ODI #11595957

Incident: June 21, 2024 · Filed: June 23, 2024

My power steering and brakes went out as I was driving. I was making a turn in town, and I almost collided with another car at the intersection. I pushed the brakes as hard as I could, but it didn't slow down, the car just eventually rolled to a stop on its own. The exact cause is unknown, but it seems like it was a failure in the power steering pump. After turning off the van and turning it back on again a minute later, it started driving normally again.

Wheels; Service Brakes

ODI #11575938

Fire

Incident: February 29, 2024 · Filed: March 7, 2024

The contact owns a 2002 Ford E-150. The contact stated while driving at approximately 75 MPH, he smelled a burning odor in the passenger cabin. The contact stated that he turned the A/C on to help clear the cabin. The contact stated that he noticed smoke was being emitted from the driver's side rear tire and wheel well. The contact stated that the tire separated from the rim and the vehicle dropped to the road. The contact stated he had not noticed any warning lights. The contact stated that he managed to pull over and saw smoke emitted from the rotor and brake pads. The contact stated that the rim was almost destroyed. The contact observed that there was fluid leaking from the rotor and brake pads and had started to burst into flames. The contact stated that he was able to smother the flames with a blanket. The contact stated that he had the vehicle towed to an independent mechanic. The vehicle was not diagnosed and was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 228,000.

Steering

ODI #11385180

Incident: December 21, 2020 · Filed: December 28, 2020

IN A PARKING LOT, I WENT TO TURN LEFT, HEARD A LOUD CLUNK AND THE VAN JUST WENT STRAIGHT. LOST ALL STEERING CONTROL. LUCKILY THIS HAPPENED IN A PARKING LOT AND NOT ON THE ROAD AT HIGHER SPEED. IF THIS HAD OCCURRED AT SPEED, I WOULD HAVE HIT ONCOMING TRAFFIC , OR GONE OFF THE ROAD INTO WHO KNOWS WHAT. TWO SEPARATE MECHANICS HAVE DIAGNOSED A COMPLETE FRAME FAILURE WIHICH ALLOWED THE STEERING BOX TO DETACH FROM THE FRAME. THE FRAME IS NOT REPAIRABLE. IF THIS IS A COMMON PROBLEM WITH THE 2002 FORD E150 FRAME PEOPLE ARE GOING TO GET HURT OR KILLED!!!

Steering; Structure

ODI #11115083

Incident: July 20, 2018 · Filed: August 1, 2018

TL* THE CONTACT OWNS A 2002 FORD E-150. THE CONTACT STATED THAT THE FRAME EXPERIENCED SEVERE CORROSION. AS A RESULT, THE VEHICLE LOST STEERING ABILITY BECAUSE THE BOLTS CONNECTED TO THE GEAR BOX, WHICH WERE ALL CONNECTED TO THE FRAME, DETACHED FROM THE VEHICLE. THE CONTACT WAS ABLE TO SAFELY MANEUVER THE VEHICLE TO THE SIDE OF THE ROAD. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND ADVISED THE CONTACT TO TAKE THE VEHICLE TO A DEALER FOR DIAGNOSTIC TESTING. THE VEHICLE WAS TAKEN TO LES STUMPF FORD (3030 W COLLEGE AVE, APPLETON, WI) WHERE THE FAILURE WAS CONFIRMED; HOWEVER, NO FURTHER ASSISTANCE WAS OFFERED BECAUSE THE VIN WAS NOT INCLUDED IN A RECALL. THE FAILURE MILEAGE WAS APPROXIMATELY 86,000.

Engine

ODI #10918802

Incident: October 22, 2016 · Filed: October 25, 2016

SPARK PLUG BLEW OUT OF ENGINE BLOCK. I WAS GOING IN REVERSE WHEN THIS HAPPENED.

Suspension

ODI #10490603

Fire

Incident: December 26, 2012 · Filed: December 31, 2012

TL* THE CONTACT OWNS A 2002 FORD REGENCY. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 50-55 MPH, THE DRIVER'S SIDE REAR TIRE DETACHED FROM THE VEHICLE. THE CONTACT WAS RIDING ON THE ROTOR, WHICH STARTED A SMALL FIRE, BUT HE WAS ABLE TO STOP THE VEHICLE SAFELY. THE VEHICLE WAS LATER TOWED TO AN INDEPENDENT MECHANIC WHERE THEY ADVISED HIM THAT THE C-CLAMP WAS FRACTURED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND OFFERED NO ASSISTANCE. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 125,000.

Fuel System, Gasoline

ODI #10451299

Incident: June 16, 2010 · Filed: March 12, 2012

THE GAS PEDAL ON OUR E150 FORD TRAVELER VAN IS STICKY. THIS HAS BEEN GOING ON SOME TIME NOW. MY WIFE HAS COMPLAINED ABOUT IT FOR SEVERAL YEARS. A CO-WORKER AND I BORROWED A FRIENDS FORD PICKUP TRUCK AND HE MENTIONED THE SAME PROBLEM, I TOLD HIM ABOUT OUR VAN(THIS WAS A MONTH AGO). *TR

Fuel System, Gasoline

ODI #10417976

Incident: March 1, 2011 · Filed: August 8, 2011

TL* THE CONTACT OWNS A 2002 FORD E-150. THE CONTACT STATED THAT AFTER HAVING THE VEHICLE SERVICED FOR ROUTINE MAINTENANCE, HE WAS ADVISED THAT THE TWO STRAPS WHICH HELD THE FUEL TANK IN PLACE WERE CORRODED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED AND A COMPLAINT WAS FILED. THE FAILURE MILEAGE WAS APPROXIMATELY 40,000. UPDATED 09/19/11 *BF UPDATED 2/23/12 *CN

Suspension

ODI #10379322

Incident: January 14, 2011 · Filed: January 27, 2011

TL*THE CONTACT OWNS A 2002 FORD E150. WHILE DRIVING APPROXIMATELY 35 MPH, THE CONTACT HEARD A LOUD NOISE SUCH AS A SPRING POPPING, WHEN HE NOTICED THAT THE FLAT PLATE THAT THE FRONT DRIVER SIDE COIL SPRING MOUNT WAS MOUNTED ON HAD RUSTED, CAUSING HIM TO LOSE CONTROL OF THE VEHICLE. NEITHER THE DEALER NOR THE MANUFACTURER HAD BEEN NOTIFIED AND THE VEHICLE WAS NOT REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE 132,000. THE VIN WAS UNAVAILABLE.

Fuel System, Gasoline

ODI #10357486

Incident: September 1, 2010 · Filed: September 25, 2010

FUEL TANK FILLER NECK RUST AND LEAK SPILLS GASOLINE ON EVERY FUEL FILLUP--EXTREME DANGER OF FIRE. *TR

Other Ford E-150 model years

Check your 2002 Ford E-150 VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Ford E-150 at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Ford VIN