try.vin
Log in

NHTSA vehicle safety data

2001 Ford E-150 Recalls & Complaints

The 2001 Ford E-150 has 4 NHTSA recall campaigns and 37 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Ford dealer.

NHTSA recall and complaint data for the 2001 Ford E-150. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2001 Ford E-150 owner complaints

Owners have filed 37 complaints with NHTSA about the 2001 Ford E-150, describing incidents dated May 25, 2001 to May 20, 2023.

Most-cited components

  • Service Brakes 11 complaints
  • Electrical System 7 complaints
  • Engine 6 complaints
  • Fuel/Propulsion System 4 complaints
  • Power Train 3 complaints
  • Steering 3 complaints

Of the 37 complaints on file, 1 reports a crash and 1 a fire; across all 37 complaints, owners report 1 injury (owner-reported, not verified by NHTSA).

Newest complaints

  • ODI #11523014 · Filed

    Frame/ chassis cracked at steering box mount due to rusting from the inside of the frame out. There are holes and small open areas in the 4 sided frame. There is no wheel well material protecting this area from excessive amount of salt, water, dirt and debris entering in these holes as well, there…

  • ODI #11429105 · Filed

    Frame corroded causing steering box to break through the frame and complete steering loss which nearly caused a head on collision and leaving van inoperable and completely without steering

  • ODI #10872846 · Filed

    SPARG PLUG BLOWN OUT OF PASSENGER SIDE CYLINDER #4, VEHICLE WAS STATIONARY IN IDLE

Read all 37 complaints

NHTSA defect investigations

NHTSA's investigations file lists the 2001 Ford E-150 in 1 investigation. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Open and recently closed NHTSA defect investigations

SPEED CONTROL DEACTIVATION SWITCH/OVERHEATS

NHTSA #09V399000 · Vehicle Speed Control · NHTSA notice

Reported October 13, 2009 · FORD MOTOR COMPANY

Potentially affected: 4,500,000 vehicles

Ford campaign 09S09 · Owners notified October 27, 2009 · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Safety consequence

A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.

Manufacturer remedy

FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.

Notes

FORD'S RECALL CAMPAIGN NUMBER IS 09S09.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

SPEED CONTROL DEACTIVATION SWITCH

NHTSA #08V051000 · Vehicle Speed Control — Cruise Control · NHTSA notice

Reported February 4, 2008 · FORD MOTOR COMPANY

Potentially affected: 225,000 vehicles

Ford campaign 08S01 · Owners notified February 18, 2008 · Vehicles built September 3, 1991 – September 15, 2003 (per NHTSA)

Defect description

FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.

Safety consequence

AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.

Manufacturer remedy

DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.

Notes

FORD RECALL NO. 08S01.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

SPEED CONTROL DEACTIVATION SWITCH

NHTSA #07V336000 · Vehicle Speed Control · NHTSA notice

Reported August 3, 2007 · FORD MOTOR COMPANY

Potentially affected: 3,600,000 vehicles

Ford campaign 05S28 · Owners notified August 13, 2007 · Vehicles built April 9, 1996 – August 2, 2002 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Safety consequence

THIS COULD RESULT IN AN UNDERHOOD FIRE.

Manufacturer remedy

DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.

Notes

FORD RECALL NO. 05S28.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION;S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

FORD/FUEL TANK CRACKS

NHTSA #01V114000 · Fuel System, Gasoline — Storage — Tank Assembly · NHTSA notice

Reported April 5, 2001 · FORD MOTOR COMPANY

Potentially affected: 151,000 vehicles

Ford campaign 01S14 · Owners notified April 19, 2001 · Vehicles built April 9, 1996 – November 14, 2000 (per NHTSA)

Defect description

VEHICLE DESCRIPTION: ON CERTAIN VANS WITH AMBULANCE PREP PACKAGES OR OTHER SEVERE-DUTY APPLICATIONS INVOLVING OPERATION AT OR NEAR THE GROSS VEHICLE WEIGHT WITH FREQUENT TWISTING OF THE VEHICLE BODY, SUCH AS OFF-ROAD, ROUGH ROAD OR SPEED BUMP EVENTS, THE 35 GALLON MID-SHIP FUEL TANK COULD DEVELOP A CRACK WHERE IT CONTACTS THE FRAME CROSS MEMBER. IF THE FUEL TANK CRACKS, FUEL LEAKAGE COULD OCCUR.

Safety consequence

FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Manufacturer remedy

DEALERS WILL INSPECT THE FUEL TANK AND, IF CRACKED, WILL REPLACE THE TANK. INSULATOR PADS WILL BE INSTALLED ON ALL VEHICLES TO REDUCE THE STRESS LEVELS IN THE FUEL TANK. OWNER NOTIFICATION BEGAN APRIL 19, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.

Notes

ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Other Ford E-150 model years

Check your 2001 Ford E-150 VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Ford E-150 at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Ford VIN