try.vin
Log in

NHTSA vehicle safety data

2000 Chevrolet Silverado Recalls, Ratings & Complaints

The 2000 Chevrolet Silverado has 20 NHTSA recall campaigns and 1,302 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Chevrolet dealer.

NHTSA recall and complaint data for the 2000 Chevrolet Silverado, plus NCAP crash-test ratings. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2000 Chevrolet Silverado owner complaints

Owners have filed 1,302 complaints with NHTSA about the 2000 Chevrolet Silverado, describing incidents dated January 1, 1999 to January 27, 2016.

Most-cited components

  • Service Brakes 554 complaints
  • Power Train 103 complaints
  • Structure 94 complaints
  • Engine 91 complaints
  • Vehicle Speed Control 82 complaints
  • Fuel/Propulsion System 80 complaints

Of the 1,302 complaints on file, 140 report a crash and 11 a fire; across all 1,302 complaints, owners report 89 injuries and 2 deaths (owner-reported, not verified by NHTSA).

Newest complaints

  • ODI #10824595 · Filed

    TOOK VEHICAL TO GET INSPECTED SHOP SAID VEHICAL IS UNSAFE TO DRIVE AND REFUSED TO INSPECT UNDER FUTHER INSEPTION THERE IS EXSESIVE RUST ON FRAME THAT IS NOT NORMAL WEAR AND TEAR GM NEEDS TO STEP UP LIKE TOYOTA DID AND REPLACE THESE FRAMES PLS LOOK IN TO THIS . THIS WAS MY ONLY VEHICAL AND NOW I DONT…

  • ODI #10823123 · Filed

    TL* THE CONTACT OWNS A 2000 CHEVROLET SILVERADO. WHILE THE VEHICLE WAS STOPPED WITH THE AIR CONDITIONER ENGAGED, THE VEHICLE BEGAN TO OVERHEAT. IN ADDITION, THE CONTACT STATED THAT THE TEMPERATURE GAUGE DISPLAYED A HIGH READING. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO AN…

  • ODI #10820039 · Filed

    "DASH BOARDS".... MY 2000 CHEVROLET SILVERADO DASHBOARD IS CRACKING AND CRUMBLING EVERYDAY. IT IS TO THE POINT NOW THAT I AM ADDING DUCK TAPE JUST TO KEEP IT UP. CHEVROLET SHOULD TAKE RESPONSIBILITY FOR THIS AND REPAIR MY DASHBOARD AND ISSUE A RECALL. THIS PROBLEM BEGAN 1 YEAR AGO, AND I HAVE NEVER…

Read all 1,302 complaints

NHTSA defect investigations

NHTSA's investigations file lists the 2000 Chevrolet Silverado in 13 investigations. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

8 more NHTSA investigations
Open and recently closed NHTSA defect investigations

FMVSS 108/REPLACEMENT HEADLAMPS/AMBER REFLECTOR

NHTSA #09E025000 · Exterior Lighting — Headlights · NHTSA notice

Reported May 11, 2009 · DOPE, INC.

Potentially affected: 42,540 vehicles

Owners notified July 28, 2009

Defect description

DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Safety consequence

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Manufacturer remedy

DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY DOPE, INC.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

FMVSS 108/AFTERMARKET COMBINATION LAMPS

NHTSA #09E012000 · Exterior Lighting · NHTSA notice

Reported April 7, 2009 · SABERSPORT

Potentially affected: 16,270 vehicles

Owners notified May 11, 2009

Defect description

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Safety consequence

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Manufacturer remedy

SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

FMVSS 108/HEADLAMPS/MISSING AMBER SIDE REFLECTORS

NHTSA #08E050000 · Exterior Lighting — Headlights · NHTSA notice

Reported August 11, 2008 · K2 MOTOR CORPORATION

Potentially affected: 1,921 vehicles

Owners notified December 17, 2008

Defect description

K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."

Safety consequence

WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.

Manufacturer remedy

K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY HONDA, FORD, OR CHRYSLER LLC. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

REPLACEMENT WHEEL HUB ASSEMBLIES

NHTSA #07E106000 · Wheels — Hub · NHTSA notice

Reported December 17, 2007 · FEDERAL-MOGUL CORPORATION

Potentially affected: 130,000 vehicles

Owners notified February 7, 2008

Defect description

CERTAIN FEDERAL-MOGUL REPLACEMENT WHEEL HUB ASSEMBLIES WITH THE BRAND NAMES: NATIONAL, CARQUEST P/NOS. 515020, 515021, 515025, 515053, 515054, 515059, AND 515060, SHIPPED BETWEEN JANUARY 23, 2006, AND DECEMBER 20, 2007, SOLD FOR LIGHT DUTY AND MEDIUM DUTY TRUCKS. THE INBOARD RETENTION NUT USED TO MAINTAIN HUB BEARING ASSEMBLY CAN LOOSEN RESULTING IN AN ABS LIGHT INDICATION, NOISE, AND/OR WHEEL SEPARATION.

Safety consequence

WHEEL SEPARATION CAN RESULT IN A VEHICLE CRASH.

Manufacturer remedy

FEDERAL-MOGUL WILL NOTIFY CUSTOMERS AND WILL REPLACE THE HUB ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 7, 2008. OWNERS CAN CONTACT FEDERAL-MOGUL TOLL-FREE AT 877-489-6659.

Notes

THIS RECALL ONLY PERTAINS TO REPLACEMENT NATIONAL, CARQUEST WHEEL HUB ASSEMBLIES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS OR FORD.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS/TOW ASSEMBLIE

NHTSA #07E066000 · Equipment — Electrical · NHTSA notice

Reported August 28, 2007 · CEQUENT ELECTRICAL PRODUCTS

Potentially affected: 175 vehicles

Owners notified September 5, 2007

Defect description

CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.

Safety consequence

IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.

Manufacturer remedy

ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET CEQUENT TOW PACKAGES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON DAIMLERCHRYSLER, GMC, OR FORD VEHICLES.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

FMVSS 108/PHOTOMETRY REQUIREMENTS

NHTSA #06E075000 · Exterior Lighting — Headlights · NHTSA notice

Reported August 28, 2006 · GUIDE CORPORATION

Potentially affected: 17,268 vehicles

Owners notified August 31, 2006

Defect description

CERTAIN GUIDE REPLACEMENT HEADLAMPS, P/NOS. 16526133 AND 16526134, MANUFACTURED FROM JANUARY 1 TO JULY 11, 2006, SOLD FOR USE ON MY 1999-2002 CHEVROLET SILVERADO PICKUP TRUCKS. THE HEADLAMP FAIL TO COMPLY WITH THE PHOTOMETRY REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Safety consequence

TOO MUCH LIGHT IN CERTAIN POINTS OF THE HEADLAMP COULD CREATE A DISTRACTION, POSSIBLY RESULTING IN A VEHICLE CRASH.

Manufacturer remedy

GUIDE CORPORATION WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 31, 2006. OWNERS MAY CONTACT GUIDE AT 248-874-0355.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET GUIDE HEADLAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON CHEVROLET SILVERADO VEHICLES MANUFACTURED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

FMVSS 108/AMBER SIDE REFLECTORS

NHTSA #06E060000 · Exterior Lighting · NHTSA notice

Reported June 29, 2006 · AAI MOTORSPORTS USA, LLC

Potentially affected: 87,745 vehicles

Owners notified August 1, 2006

Defect description

CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."

Safety consequence

LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH

Manufacturer remedy

AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.

Notes

THIS RECALL ONLY PERTAINS TO AAI MOTORSPORTS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

FMVSS 108/AFTERMARKET HEADLAMP ASSEMBLIES

NHTSA #06E057000 · Exterior Lighting — Headlights · NHTSA notice

Reported June 23, 2006 · MAXZONE AUTO PARTS CORPORATION

Potentially affected: 12,861 vehicles

Owners notified July 10, 2006

Defect description

CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 332-1182L-AS AND 332-1182R-AS, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR 1999-2000 CHEVROLET SILVERADOS. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Safety consequence

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Manufacturer remedy

MAXZONE WILL NOTIFY OWNERS AND OFFER FOR REIMBURSEMENT ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON JULY 10, 2006. OWNERS MAY CONTACT MAXZONE AT 909-822-3288.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

FMVSS 108/INSUFFICIENT LIGHTING VISIBILITY

NHTSA #06E042000 · Exterior Lighting — Headlights · NHTSA notice

Reported May 22, 2006 · SABRY LEE, INC.

Potentially affected: 15,974 vehicles

Owners notified May 10, 2006

Defect description

CERTAIN EAGLE EYES REPLACEMENT HEADLAMPS, MODEL NOS. GM159-B001L AND GM159-B001R, SOLD FOR USE ON 1999-2002 CHEVROLET SILVERADO MODEL VEHICLES. THE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Safety consequence

THE HEADLAMPS HAVE DECREASED LIGHTING VISIBILITY WHICH COULD RESULT IN A VEHICLE CRASH.

Manufacturer remedy

SABRY LEE WILL NOTIFY OWNERS AND ISSUE FULL CREDIT. THE RECALL BEGAN ON MAY 10, 2006. OWNERS MAY CONTACT SABRY LEE AT 1-866-467-2279.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET EAGLE EYES HEADLAMP ASSEMBLIES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON CHEVROLET SILVERADO VEHICLES MANUFACTURED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

FMVSS 108/AMBER SIDE REFLEX REFLECTORS

NHTSA #06E026000 · Exterior Lighting · NHTSA notice

Reported March 23, 2006 · PRO-A MOTORS, INC.

Potentially affected: 61,944 vehicles

Owners notified April 3, 2006

Defect description

CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Safety consequence

WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Manufacturer remedy

PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.

Notes

THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

TAILGATE SUPPORT CABLES

NHTSA #06V066000 · Structure — Body — Tailgate — Hinge and Attachments · NHTSA notice

Reported March 8, 2006 · GENERAL MOTORS CORP.

Potentially affected: 805,368 vehicles

Manufacturer campaign 06019 · Owners notified April 10, 2006 · Vehicles built February 1, 1999 – October 31, 1999 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

CERTAIN PICKUP TRUCKS HAVE GALVANIZED-BRAIDED-STEEL TAILGATE SUPPORT CABLES USED TO SUPPORT THE TAILGATE IN THE FULL OPEN (HORIZONTAL) POSITION. OVER TIME THESE CABLES CAN CORRODE AND FRACTURE WHEN LOADS ARE APPLIED TO THEM.

Safety consequence

IF ONE CABLE FRACTURES, THE REMAINING CABLE MAY RETAIN THE TAILGATE IN A HORIZONTAL POSITION. IF BOTH CABLES FRACTURE, THE TAILGATE WOULD DROP AND STRIKE THE TOP SURFACE OF THE REAR BUMPER. IF ANYONE IS SITTING OR STANDING ON THE HORIZONTAL SURFACE OF THE TAILGATE WHEN BOTH CABLES FRACTURED, THEY COULD FALL AND BE INJURED. ON VEHICLES WITHOUT A BUMPER, THE TAILGATE MAY DROP TO A LOWER POSITION.

Manufacturer remedy

DEALERS WILL REPLACE THE GALVANIZED SUPPORT CABLES WITH STAINLESS STEEL SUPPORT CABLES. IN ADDITION, DEALERS ARE TO INSPECT THE TAILGATE HINGE AND REPLACE IT, IF NECESSARY. THE RECALL IS EXPECTED TO BEGIN DURING APRIL 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.

Notes

GM RECALL NO. 06019.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

UNWANTED ABS ACTIVATION

NHTSA #05V379000 · Service Brakes, Hydraulic — Antilock/Traction Control/Electronic Limited Slip · NHTSA notice

Reported August 29, 2005 · GENERAL MOTORS CORP.

Potentially affected: 1,353,718 vehicles

Manufacturer campaign 05068 · Owners notified September 22, 2005 · Vehicles built February 1, 1999 – July 31, 2000 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES MAY EXPERIENCE UNWANTED ANTILOCK BRAKE SYSTEM (ABS) ACTIVATION. THIS CONDITION IS MORE LIKELY TO OCCUR IN ENVIRONMENTALLY CORROSIVE AREAS. THIS RECALL WILL BE LAUNCHED IN THE "SALT BELT" STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MARYLAND, MASSACHUSETTS, MAINE, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN AND THE DISTRICT OF COLUMBIA ONLY.

Safety consequence

THIS CAN CAUSE INCREASED STOPPING DISTANCES DURING LOW-SPEED BRAKE APPLICATIONS, WHICH COULD RESULT IN A CRASH.

Manufacturer remedy

DEALERS ARE TO REMOVE THE WHEEL SPEED SENSOR AND THOROUGHLY CLEAN THE WHEEL SPEED SENSOR MOUNTING SURFACE ON THE BEARING, APPLY RUST INHIBITOR TO THE CLEANED SURFACE, GREASE THE MOUNTING SURFACE, REINSTALL THE WHEEL SPEED SENSOR, AND CHECK THE PEAK-TO-PEAK OUTPUT VOLTAGE TO ENSURE THE WHEEL SPEED SIGNAL IS WITHIN SPECIFICATIONS. THE RECALL BEGAN SEPTEMBER 22, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.

Notes

GM RECALL NO. 05068. GM REVISED THE INVOLVED VEHICLES BY AMENDING THE ORIGINAL 573 REPORT ON OCTOBER 4, 2005. GM REVISED THE ORIGINAL 573 REPORT ON DECEMBER 16, 2005, TO INCLUDE ADDITIONAL STATES AND VEHICLE POPULATION.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

PARKING BRAKE SYSTEM

NHTSA #05V161000 · Parking Brake · NHTSA notice

Reported April 22, 2005 · GENERAL MOTORS CORP.

Potentially affected: 90,242 vehicles

Manufacturer campaign 05042 · Owners notified July 29, 2005 · Vehicles built February 1, 1999 – July 31, 2000 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

ON CERTAIN PICKUP TRUCKS EQUIPPED WITH MANUAL TRANSMISSIONS AND BUILT WITH EITHER PBR PARKING BRAKE SYSTEMS OR TRW PARKING BRAKE SYSTEMS, THE PARKING BRAKE FRICTION LININGS MAY WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.

Safety consequence

IF THE PARKING BRAKE DOES NOT HOLD, UNINTENDED VEHICLE MOVEMENT COULD OCCUR, WHICH COULD RESULT IN A CRASH.

Manufacturer remedy

DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH A PBR PARKING BRAKE SYSTEM. ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM, DEALERS WILL INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY. THE RECALL BEGAN ON JULY 29, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.

Notes

GM RECALL NO. 05042.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

FRACTURE POWER STEERING PUMP DRIVESHAFT

NHTSA #05V005000 · Power Train — Driveline — Driveshaft · NHTSA notice

Reported January 7, 2005 · GENERAL MOTORS CORP.

Potentially affected: 98,221 vehicles

Manufacturer campaign 05001 · Owners notified February 14, 2005 · Vehicles built May 1, 1999 – October 31, 1999 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

SOME PICKUP TRUCKS, VANS, AND SPORT UTILITY VEHICLES EQUIPPED WITH A HYDRAULIC PUMP DRIVESHAFT THAT CAN FRACTURE, RESULTING IN IMMEDIATE LOSS OF HYDRAULIC POWER STEERING ASSIST. ON CERTAIN VEHICLES EQUIPPED WITH HYDRO-BOOST POWER BRAKES, THE SAME CONDITION CAN RESULT IN LOSS OF POWER ASSIST FOR BRAKING AFTER THE RESERVE PRESSURE IS DEPLETED.

Safety consequence

AN INOPERATIVE PUMP CAN CAUSE INCREASED STEERING EFFORT, AND IN HYDRO-BOOST EQUIPPED VEHICLES ALSO INCREASED BRAKING EFFORT, BUT DOES NOT COMPLETELY ELIMINATE THE ABILITY TO STEER OR SLOW THE VEHICLE.

Manufacturer remedy

DEALERS WILL REPLACE THE HYDRAULIC PUMP. THE CAMPAIGN BEGAN ON FEBRUARY 14, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.

Notes

GM CAMPAIGN NO. 05001.THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT.THE COMPANY HAS INFORMED NHTSA THAT IT WILL PROVIDE THE MODIFICATIONS DESCRIBED ABOVE FREE OF CHARGE.

DURAKON/BEDLINER DETACHES FROM THE TRUCK

NHTSA #04E022000 · Equipment · NHTSA notice

Reported March 23, 2004 · DURAKON INDUSTRIES, INC.

Potentially affected: 8,000 vehicles

Owners notified March 31, 2004

Defect description

AFTERMARKET PICKUP TRUCK OVER-THE-RAIL BEDLINERS MANUFACTURED FOR INSTALLATION ON 1999-2004 CHEVROLET SILVERADO AND GMC SIERRA PICKUP TRUCKS. THE TOGGLE WING ASSEMBLY USED TO ATTACH THE BEDLINER TO THE TRUCK BED IS NOT ENGAGING FULLY IN THE STAKE POCKET OF THE PICKUP TRUCK.

Safety consequence

THE BEDLINER CAN BECOME DETACHED FROM THE PICKUP WHILE IT IS MOTION, POSSIBLY ENDANGERING FOLLOWING MOTORISTS OR PEDESTRIANS.

Manufacturer remedy

DURAKON WILL ISSUE A PRESS RELEASE IN ATTEMPT TO NOTIFY CUSTOMERS THAT COULD HAVE PURCHASED THE DEFECTIVE BEDLINER. IF YOU PURCHASED EITHER A DURAKON ALLSTAR OF PATRIOT OVERRAIL BEDLINER SINCE AUGUST 1, 2003, FOR 1999 TO 2004 CHEVROLET SILVERADO OR GMC SIERRA TRUCKS, OR PURCHASED ONE OF THESE PICKUP TRUCKS WITH EITHER BRAND BEDLINER ALREADY INSTALLED, YOU SHOULD RETURN TO AN AUTHORIZED DURAKON DEALER SO THAT THE BEDLINER CAN BE INSPECTED AND, IF NECESSARY, REPAIRED WITH A NEWLY DESIGNED TOGGLE WING FASTENING SYSTEM, OR IF REQUIRED, REPLACED WITH A NEW BEDLINER FREE OF CHARGE. PLEASE CALL THE DURAKON HOTLINE AT 1-800-933-4200 TO FIND THE NEAREST AUTHORIZED DURAKON DEALER.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET OVERRAIL BEDLINERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON CHEVROLET SILVERADO AND GMC SIERRA PICKUP TRUCKS BY GENERAL MOTORS.CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

GM/TAILGATE SUPPORT CABLE

NHTSA #04V129000 · Structure — Body — Tailgate — Hinge and Attachments · NHTSA notice

Reported March 17, 2004 · GENERAL MOTORS CORP.

Potentially affected: 3,662,211 vehicles

Manufacturer campaign 04007 · Owners notified September 18, 2004 · Vehicles built October 1, 1999 – July 31, 2000 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE GALVANIZED STEEL TAILGATE SUPPORT CABLES THAT RETAIN THE TAILGATE IN THE FULL OPEN (HORIZONTAL) POSITION MAY CORRODE, WEAKEN, AND EVENTUALLY FRACTURE. IF BOTH CABLES FRACTURED, THE TAILGATE WOULD SUDDENLY DROP AND STRIKE THE TOP SURFACE OF THE REAR BUMPER.

Safety consequence

ANYONE SITTING OR STANDING ON THE HORIZONTAL SURFACE OF THE TAILGATE WHEN BOTH CABLES FRACTURED COULD BE INJURED BY FALLING FROM THE TAILGATE. ON VEHICLES THAT HAVE HAD THE BUMPER REMOVED, THE TAILGATE MAY DROP EVEN LOWER. ADDITIONALLY, IF THERE IS CARGO ON THE TAILGATE THE CARGO MAY FALL OFF IF THE SUPPORT CABLES FRACTURE.

Manufacturer remedy

DEALERS WILL REPLACE THE CABLES. INTERIM OWNER NOTIFICATION BEGAN ON APRIL 7, 20004. THE RECALL BEGAN ON SEPTEMBER 24, 2004, WHEN REPLACEMENT PARTS WERE AVAILABLE, AND WILL CONTINUE THROUGH OCTOBER 29, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463, OR VISIT WWW.MYGMLINK.COM, AND ENTER YOUR VEHICLE IDENTIFICATION NUMBER.

Notes

GM RECALL NO. 04007.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

GM/AIR BAG SENSING MODULE

NHTSA #02V178000 · Air Bags — Frontal — Sensor/Control Module-Inactive · NHTSA notice

Reported July 1, 2002 · GENERAL MOTORS CORP.

Potentially affected: 525,254 vehicles

Manufacturer campaign 02029 · Owners notified August 28, 2002 · Vehicles built February 1, 1999 – February 28, 2000 (per NHTSA)

Defect description

ON CERTAIN PICKUP AND UTILITY TRUCKS, SOME OF THESE VEHICLES HAVE AN AIR BAG SENSING DIAGNOSTIC MODULE (SDM) WHICH CONTAINS AN ANOMALY THAT COULD RESULT IN THE DRIVER AND PASSENGER'S AIR BAG FAILING TO DEPLOY DURING CERTAIN FRONTAL CRASHES.

Safety consequence

IN A VEHICLE CRASH, FRONT SEAT OCCUPANTS MAY RECEIVE MORE SEVERE INJURIES.

Manufacturer remedy

DEALERS WILL RECALIBRATE THE SDM ON THE AFFECTED VEHICLES. OWNER NOTIFICATION BEGAN AUGUST 28, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.

Notes

ALSO, CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

GM/BRAKE LINE CHAFFING

NHTSA #00V345000 · Service Brakes, Hydraulic — Foundation Components — Hoses, Lines/Piping, and Fittings · NHTSA notice

Reported October 30, 2000 · GENERAL MOTORS CORP.

Potentially affected: 1,383,922 vehicles

Manufacturer campaign 00093 · Owners notified February 5, 2001 · Vehicles built February 1, 1999 – June 30, 2000 (per NHTSA)

Defect description

VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES. SOME OF THESE VEHICLES HAVE A CLEARANCE CONDITION BETWEEN THE FRONT RIGHT-HAND BRAKE PIPE AND THE BODY CROSS SILL THAT COULD DECREASE TO THE POINT OF ALLOWING CONTACT DURING THE LIFE OF THE VEHICLE. IF CONTACT OCCURS AND THE BRAKE PIPE BECOMES DAMAGED, IN HALF OF THE BRAKE SYSTEM THERE CAN BE A LOSS OF BRAKE FLUID AND PRESSURE. THE BRAKE WARNING LAMP WILL BE ACTIVATED WHEN THE BRAKE FLUID LEVEL REACHES THE INDICATOR LIMIT.

Safety consequence

DURING BRAKING, THE PEDAL WILL BE LOWER THAN NORMAL AND STOPPING DISTANCES WILL BE LONGER. IF THIS OCCURS WHEN STOPPING DISTANCE IS LIMITED, A CRASH COULD OCCUR.

Manufacturer remedy

DEALERS WILL INSPECT THE FRONT RIGHT-HAND BRAKE PIPE FOR WEAR. IF THERE ARE SIGNS OF WEAR, THIS SECTION OF THE BRAKE PIPE WILL BE REPLACED WITH A NEW DESIGNED BRAKE PIPE SECTION. IF THERE ARE NOT SIGNS OF WEAR ON THE BRAKE PIPE, THE DEALER WILL INSTALL A SPACER CLIP TO ENSURE SUFFICIENT CLEARANCE BETWEEN THE BRAKE PIPE AND THE BODY CROSS SILL.

Notes

OWNER NOTIFICATION BEGAN FEBRUARY 5, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Service Brakes, Hydraulic — Foundation Components — Disc — Caliper

NHTSA #00X001000 · NHTSA notice

Reported May 23, 2000 · GENERAL MOTORS CORP.

Potentially affected: 777,873 vehicles

Recall influenced by NHTSA's Office of Defects Investigation

Defect description

THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 1/2 TON LIGHT DUTY PICKUP TRUCKS. ON CERTAIN TRUCKS, FAILURE TO FOLLOW THE SERVICE PROCEDURE SET FORTH IN THE SERVICE MANUAL FOR REMOVAL OF THE FRONT BRAKE CALIPER CAN RESULT IN MOVEMENT OF THE FRONT BRAKE HOSE RELATIVE TO ITS KNUCKLE MOUNTING BRACKET. IF THIS MOVEMENT RESULTS IN INCREASED LENGTH BETWEEN THE BRACKET AND THE BANJO FITTING THAT ATTACHES TO THE BRAKE CALIPER, IT IS POSSIBLE FOR THE BRAKE HOSE TO COME IN CONTACT WITH THE WHEEL RIM.

Safety consequence

THIS CONTACT WITH THE WHEEL RIM COULD, IN TIME, CAUSE THE BRAKE HOSE TO BECOME WORN TO THE POINT THAT BRAKE FLUID LEAKAGE COULD OCCUR. IF THIS OCCURRED, LOSS OF FRONT BRAKES IS POSSIBLE.

Manufacturer remedy

DEALERS WILL ATTACH A NOTICE LABEL TO THE FRONT BRAKE HOSES STATING THAT THE CALIPERS MUST BE SUPPORTED WHEN REMOVED.

Notes

GM HAS DECIDED TO CONDUCT A SERVICE PROGRAM TO INSTALL A LABEL ON THE HOSE WITH WARNING AND RECOMMENDATIONS TO SUPPORT THE BRAKE CALIPERS WHEN REMOVING THEM.OWNERS CAN CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782, CONCERNING THIS PROGRAM.

GM/ABS SPRING CLIP

NHTSA #00V055000 · Service Brakes, Hydraulic — Antilock/Traction Control/Electronic Limited Slip · NHTSA notice

Reported February 28, 2000 · GENERAL MOTORS CORP.

Potentially affected: 10,674 vehicles

Manufacturer campaign 00013 · Owners notified March 27, 2000 · Vehicles built August 1, 1999 – August 31, 1999 (per NHTSA)

Defect description

VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS EQUIPPED WITH 4-WHEEL DISC BRAKES. SOME OF THESE VEHICLES HAVE AN ANTILOCK BRAKE SYSTEM (ABS) MOTOR CONTAINING AN OUT-OF-SPECIFICATION SPRING CLIP. THIS CLIP COULD ALLOW THE MOTOR BEARING TO BECOME MISALIGNED. IF MISALIGNMENT OCCURS, EVENTUALLY THE ABS WOULD BE NON-FUNCTIONAL.

Safety consequence

THE BASE BRAKES WOULD REMAIN FULLY FUNCTIONAL, BUT THE DYNAMIC REAR PROPORTIONING (DRP) SYSTEM, WHICH OPTIMIZES FRONT TO REAR BRAKE BALANCE, WOULD BECOME INOPERATIVE.

Manufacturer remedy

DEALERS WILL REPLACE THE BRAKE PRESSURE MODULE VALVE ASSEMBLY.

Notes

GM RECALL NO. 00013.OWNER NOTIFICATION BEGAN MARCH 27, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Other Chevrolet Silverado model years

Check your 2000 Chevrolet Silverado VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Chevrolet Silverado at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Chevrolet VIN