2003 Chevrolet Silverado Recalls, Ratings & Complaints

Incident: March 5, 2016 · Filed: March 31, 2016

WHILE ROUTINELY DRIVING MY 03 CHEV SILVERADO TRUCK, THE BRAKES FAILED. WHEN I WAS ABLE TO SAFELY STOP AND MOVE TO A SAFE PLACE, I LOOKED UNDER THE VEHICLE AND SAW BRAKE FLUID LEAKING FROM ONE OF THE BRAKE LINES WHICH HAD FAILED DUE TO EXCESSIVE CORROSION. AS A RETIRED POLICE OFFICER, I HAVE EXCELLENT DRIVING SKILLS WHICH HELPED ME TO AVOID A COLLISION WITH ANOTHER VEHICLE WHEN THE BRAKES FAILED!

Incident: February 25, 2016 · Filed: February 26, 2016

SIGNIFICANT CORROSION OF THE FUEL (GASOLINE) LINES CAUSING LEAK AND POSSIBLE SAFETY HAZARD (FIRE). SEVERAL FORUMS REPORT BRAKE AND FUEL LINE PREMATURE FAILURE DUE TO CORROSION. GM NOT ADDRESSING THIS KNOWN PROBLEM.

Incident: January 1, 2013 · Filed: February 17, 2016

BRAKE LINES, GAS LINE, TRANSMISSION FLUID LINES ALL RUSTED/CORRODED BEGINNING AT UNDER 50,000 MILES. * HAD NEAR ACCIDENTS AS THE BRAKE LINES BLEW WHILE DRIVING ON A HIGHWAY AND WAS DECELERATING IN AN ATTEMPT TO COME TO A STOP..PEDAL WENT TO THE FLOOR, I CONTINUED ON (FOOT OFF THE GAS) UNTIL THE TRUCK SLOWED DOWN ENOUGH ON IT'S OWN, SHIFTED INTO LOW GEAR & WAS ABLE TO COME TO A STOP AND GET TOWED. * SHORTLY AFTER BRAKE LINE INCIDENT, THE SAME THING WITH THE GAS LINE, RUSTED/CORRODED AND LEAKED GASOLINE WHEN IGNITION WAS ON AND PUMP WAS RUNNING... TOWED * A FEW ,MONTHS LATER, I WAS PARKING THE TRUCK AND FLUID STARTED SPEWING FROM UNDER THE TRUCK - AFTER CLOSE EXAMINATION I DETERMINED IT WAS TRANSMISSION FLUID, THE LINES HAD RUSTED/CORRODED - AGAIN,TOWED. * REAR BUMPER ROTTED OUT COMPLETELY BEFORE HITTING 35,000 MILES- I HAD IT REPLACED, NOW THE WHEELS AND SIDE QUARTER PANELS AND EVERYTHING IN BETWEEN ARE ALSO ROTTING OUT. * CURRENTLY THE DASH LIGHTS/PANEL WILL INTERMITTENTLY BEGIN TO FLASH - THE WHOLE DASH GOES BLANK, LIGHTS OFF, THEN THEY COME BACK ON, WHILE DRIVING! **MY MECHANIC RECENTLY TOLD ME AFTER STATE INSPECTION, THAT THE FRAME IS THE NEXT THING TO GO, IT IS RUSTING OUT MORE THAN EXPECTED FOR A VEHICLE OF IT'S AGE/LOW MILEAGE. PERSONALLY, I FEEL THAT INFERIOR PRODUCTS WERE USED WHEN THE TRUCK WAS MANUFACTURED ONLY BECAUSE I HAVE ANOTHER CHEVROLET PRODUCT WITH TWICE THE MILEAGE AND 6 YEARS OLDER WITH BARELY ANY RUST/ROT/CORROSION.

Incident: January 31, 2016 · Filed: February 1, 2016

FRONT BRAKE LINES RUSTED THROUGH AND SPILLED BRAKE FLUID WHILE MOVING AT SLOW SPEED. HAD FRONT BRAKE LINES REPLACED. SIX MONTHS OR SO LATER, REAR BRAKE LINES RUSTED THROUGH AND SPILLED BRAKE FLUID WHILE MOVING AT SLOW SPEED. HAD REAR BRAKE LINES REPLACED. ABS IS NOW CONTAMINATED AND IS CAUSING STOP TIME DELAY, ESPECIALLY AT HIGH SPEED. ALMOST CRASHED ON SEVERAL OCCASIONS WHERE MY HEART DROPPED TO MY STOMACH. DECIDED NOT TO DRIVE TRUCK ANYMORE UNTIL I CAN REPLACE THE ENTIRE BRAKE SYSTEM WITH RUST FREE COMPONENTS.

Incident: January 4, 2016 · Filed: January 4, 2016

WHILE DRIVING, THE HEATER BLOWER STOPPED WORKING AND I SMELLED BURNING PLASTIC OR INSULATION. I PULLED OVER AND FIGURED OUT IT WAS COMING FROM UNDER THE DASH. LOGICALLY I PULLED THE BOTTOM COVER OFF FROM BELOW THE BLOWER ASSY.(FORMER MECHANIC). SMELL WAS COMING FROM PLUG HARNESS AND RELAY. MELTED WIRE INSULATION AND MELTED PLASTIC FROM PLUG HARNESS(OBVIOUS SHORT). I WAS NEAR AN AUTO PARTS STORE AND CHECKED TO SEE IF THEY HAD THIS WIRING PLUG ASSY. AND THEY INFORMED ME THAT THEY DID AND THIS WAS AN ISSUE THAT GM HAD AND THERE HAD BEEN A SAFETY RECALL ON THIS. IT'S WINTER AND I NEEDED A DEFROSTER! ROADSIDE FIX, BUT THIS COULD HAVE BEEN MUCH WORSE. CONTACTED GM AND THEY INFORMED ME THAT THIS WAS NOT THEIR PROBLEM BECAUSE THE VIN NUMBER WASN'T PART OF THEIR RECALL. GM CASE # 8-174060432. NOT DROPPING THIS, THIS COULD HAVE GOTTEN WORSE.

Incident: November 14, 2015 · Filed: November 23, 2015

BRAKE LINE RUPTURE.

Incident: October 30, 2015 · Filed: November 13, 2015

THE FRONT TO REAR BRAKES CORRODED TO THE POINT WHERE THEY BLEW OUT WHEN THE BRAKES WERE APPLIED WHILE DRIVING ON THE HIGHWAY.

Incident: October 22, 2015 · Filed: November 5, 2015

ON OCTOBER 22,2015 WHILE DRIVEING ON INTERSTATE 75 THE FUEL PUMP STOPPED FUNCTIONING AND RESULTING IN A NEAR DISASTEROUS SITUATION.RESULTS $751.81 REPAIR COST PLUS TOW. THEN ONE WEEK LATER,OCTOBER 29 2015 AT WILMINGTON PIKE AND INERTSTATE 675 RED LIGHT MY BRAKE LINES BURST AND I NARROWLY AVOIDED A WRECK. REPAIR COST $870.17 .I WAS NOT NOTEAFIDE OF ANY RECALL. SO BE FAIR WARNING IF I HAD KNOWN OR BEEN I WOULD HAVE FIXED IT

Incident: July 1, 2014 · Filed: September 4, 2015

TL* THE CONTACT OWNS A 2003 CHEVROLET SILVERADO. WHILE DRIVING 60 MPH, THE VEHICLE LOST POWER AND FAILED TO ACCELERATE. THE ABS, CHECK ENGINE, AND PASSENGER SIDE AIR BAG LIGHTS REMAINED ILLUMINATED. IN ADDITION, THE POWER STEERING FAILED. THE FAILURES RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED, BUT A FAILURE COULD NOT BE DUPLICATED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

Incident: May 21, 2015 · Filed: August 25, 2015

THIS IS THE SECOND OF THREE FATAL COLLISIONS INVESTIGATED THIS YEAR BY MY OFFICE INVOLVING CHEVROLET PICKUPS THAT CAUGHT FIRE AFTER BEING INVOLVED IN FRONTAL COLLISIONS. THIS WAS AN OFF SET HEAD ON, PASSENGER SIDE TO PASSENGER SIDE. PASSENGER IN PICKUP WAS PINNED IN VEHICLE DUE TO CRUSH AND CONSUMED BY FIRE.