2010 Chevrolet Express Recalls & Complaints

Incident: August 13, 2021 · Filed: August 24, 2021

My 2010 Chevrolet Express 1500 AWD Passenger Van was recently in the dealer's shop for work on various sensors and other problems. When the codes were downloaded from the computer, one indicated a faulty passenger side air bag module. At no time had any of the dashboard warning lights indicated a problem with the air bag system, so I had driven an unknown amount of miles without any indication it was malfunctioning, even though the vehicle's computer had an indication of a problem. I have also had repeated intermittent indications of problems with the ABS and Stabilitrack systems, but their cause has never been identified.

Incident: August 6, 2018 · Filed: August 6, 2018

THE SIDE AIRBAGS DEPLOYED WHILE DRIVING DOWN THE ROAD AT ABOUT 10 MPH. WE HAD JUST TURNED OUT OF OUR DRIVEWAY AND HEADING TO A STOP SIGN AT THE HIGHWAY. LUCKILY IT HAPPENED BEFORE GETTING ON THE HIGHWAY. NOTHING HIT THE VAN AND NO PRIOR DAMAGE. MY WIFE WAS DRIVING AND SHE HAS BRUISING ON HER ARM AND WE BOTH HAVE RINGING AND SORE EARS. SOUNDED LIKE A BOMB WENT OFF INSIDE THE VAN. WE WERE KIND OF DISORIENTED AND FEEL LIKE WE MAY HAVE BLACKED OUT FOR A BIT AFTER IT HAPPENED. WE HAVE NOT SEEKED MEDICAL YET BUT MIGHT IN THE NEXT COUPLE DAYS IF SOME OF THE ISSUES DON'T GET BETTER.

Incident: September 15, 2017 · Filed: November 15, 2017

LAST MONTH THE RIGHT SIDE REAR BRAKE LITE AND BLINKER DID NOT WORK AND THIS MONTH THE DRIVERS SIDE TAIL LITE DOESN"T WORK . THEY REPLACED THE MAIN COMPUTER BCM LAST MONTH ,WAITING TO SEE WHAT THEY DO THIS TIME. BOTH TIMES I WAS ON THE HWY DRIVING

Incident: April 10, 2010 · Filed: April 21, 2017

TL* THE CONTACT OWNS A 2010 CHEVROLET EXPRESS. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 45 MPH AND ATTEMPTING THE GO DOWN A HILL OR A LIGHT SLOPE, THE VEHICLE REVVED AND SHOOK VIOLENTLY. THE CONTACT SOFTLY APPLIED THE BRAKE PEDAL AND SLOWED DOWN TO STEADY THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE VEHICLE WAS UNABLE TO BE DIAGNOSED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THE FAILURE WAS AN UNKNOWN ISSUE. THE CONTACT STATED THAT THE MANUFACTURER DID NOT OFFER ANY ASSISTANCE. THE FAILURE RECURRED SEVERAL TIMES AND WAS NOT REMEDIED. THE FAILURE MILEAGE WAS APPROXIMATELY 5,000.

Incident: September 29, 2015 · Filed: September 29, 2015

THE FRAME OF THIS VEHICLE BEHIND THE RIGHT REAR WHEEL WHERE THE BOLT GOES THROUGH TO SECURE THE AMBULANCE BODY TO THE FRAME HAS CRACKED. THIS HAS HAPPENED TWICE ON THIS SAME VEHICLE. IT WAS REPAIRED ONCE AT A CHEVROLET DEALERSHIP.

Incident: May 4, 2015 · Filed: May 15, 2015

GOING UP STEEP HILLS THE TRUCKS SHUDDERS VERY BADLY. THIS HAPPENS ONLY AT LOW SPEED AND IN 2ND AND OR 3 RD GEAR. THIS IS VERY DANGEROUS AND COULD CAUSE A ACCIDENT. THIS HAPPENED AFTER GM ISSUED A RECALL LETTER TO HAVE THE TRANSMISSION REPROGRAMED. IT WORKED FINE BEFORE. NO GM WILL NOT ALLOW THE DEALER TO PUT THE ORIGINAL PROGRAMING BACK AND TRANSMISSION IS SHUDDERING REALLY BAD GOING UP HILLS. TOLD TO MANUALLY SIFT TRANSMISSION GOING UP HILLS. WHICH IS STUPID BECAUSE IT IS A AUTOMATIC TRANSMISSION. VERY UNHAPPY ABOUT THIS. THERE WAS NOTHING WRONG WITH THIS VEHICLE UNTIL GM ISSUED A SERVICE LETTER. THIS WILL CAUSE A ACCIDENT . BECAUSE THE TRUCK SHAKES SO BADLY. GM TOLD ME THEY WILL NOT FIX IT OR DO ANYTHING FOR IT. SPENT 3 HOURS ON THE PHONE WITH GM AND THEY BASICALLY TOLD YOU ARE UP A CREEK WITHOUT A PADDLE AND GO LUCK. TRUCK STILL UNDER WARRANTY BUT GM WILL NOT FIX IT.

Incident: November 17, 2014 · Filed: November 17, 2014

TL* THE CONTACT OWNS A 2010 CHEVROLET EXPRESS. THE CONTACT RECEIVED A NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V117000 (AIR BAGS). HOWEVER, THE PART NEEDED TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

Incident: April 1, 2014 · Filed: November 7, 2014

TL* THE CONTACT OWNS A 2010 CHEVROLET EXPRESS VAN. THE CONTACT STATED THAT WHILE MAKING A TURN, THE STEERING WHEEL SHOOK UNCONTROLLABLY AND BECAME VERY HARD TO MANEUVER. THE CONTACT WAS A CERTIFIED MECHANIC WHO DIAGNOSED THAT THE LOWER ISOLATION GROMMET ON THE FRONT SHOCK FAILED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS UNAVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 65,000.

Incident: June 1, 2014 · Filed: June 12, 2014

TL* THE CONTACT OWNS A 2010 CHEVROLET EXPRESS. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 5 MPH, ANOTHER VEHICLE CRASHED INTO THE FRONT DRIVER'S SIDE WHICH CAUSED THE VEHICLE TO FLIP OVER AND THEN LANDED ON ALL FOUR WHEELS. THERE WERE FIVE OCCUPANTS IN THE VEHICLE THAT SUFFERED FROM INJURIES TO THE BACK, INCLUDING LACERATIONS AND CONTUSIONS TO THE BODY. ONE OF THE PASSENGER WAS EJECTED FROM THE VEHICLE AND FRACTURED THEIR PELVIS AND FEMUR. THE FRONT DRIVER'S SIDE SEAT BELT BUCKLE UNLATCHED INDEPENDENTLY HOWEVER, THE DRIVER DID NOT SUSTAIN ANY INJURIES. A POLICE REPORT WAS FILED OF THE INCIDENT. THE VEHICLE WAS DESTROYED AND TOWED TO A SALVAGE FACILITY. THE MANUFACTURER WAS NOT NOTIFIED OF THE DEFECT. THE FAILURE MILEAGE WAS UNAVAILABLE.

Incident: August 29, 2013 · Filed: September 10, 2013

TL* THE CONTACT OWNS A 2010 CHEVROLET EXPRESS CARGO VAN. THE CONTACT STATED THAT THE CONNECTORS AND CABLES NEAR THE FUEL TANK WERE FOUND TO BE BURNED. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS BUT THE MECHANIC STATED THAT THEY COULD NOT DETERMINE THE PROBLEM. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 65,000.