NHTSA vehicle safety data
2020 Chevrolet Express Recalls & Complaints
The 2020 Chevrolet Express has 1 NHTSA recall campaign and 17 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Chevrolet dealer.
NHTSA recall and complaint data for the 2020 Chevrolet Express. Recall data is refreshed daily from NHTSA.
2020 Chevrolet Express owner complaints
Owners have filed 17 complaints with NHTSA about the 2020 Chevrolet Express, describing incidents dated May 9, 2020 to September 14, 2026.
Most-cited components
- Power Train 9 complaints
- Electrical System 3 complaints
- Engine 3 complaints
- Structure 3 complaints
- Service Brakes 2 complaints
- Unknown or Other 2 complaints
Of the 17 complaints on file, 1 reports a crash (owner-reported, not verified by NHTSA).
Newest complaints
ODI #11766626 · Filed
The vehicle is experiencing an under-chassis manufacturing wiring harness restriction (Connector X185) that was installed too tightly from the factory, dropping the 5-volt reference power circuit down to 0 volts under load. This intermittent electrical failure completely starves the fuel pump…
ODI #11726848 · Filed
The contact owns a 2020 Chevrolet Express. The contact stated that while driving 60 MPH on the highway, the vehicle lost motive power and shuddered abnormally, causing the vehicle to decelerate to 40 MPH. The vehicle was pulled over and restarted; however, the failure persisted. The failure recurred…
ODI #11721782 · Filed
The contact owns a 2020 Chevrolet Express. The contact stated that while driving at 60 MPH, the vehicle experienced a sudden loss of power and was shuddering while driving on the highway. The vehicle was pulled over to the side of the road and restarted; however, the failure reoccurred shortly…
Tire Failure may Cause Sudden Air Loss
NHTSA #21V115000 · Tires · NHTSA notice
Reported February 25, 2021 · General Motors, LLC
Potentially affected: 33,838 vehicles
Repair completion: 81.78% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)
Manufacturer campaign N212329050 · Owners notified March 22, 2021
Defect description
General Motors LLC (GM) is recalling certain 2020 Buick Enclave, Cadillac XT4, XT5, Escalade, Escalade ESV, Chevrolet Suburban, Tahoe, Traverse, GMC Yukon, Yukon XL, 2018-2021 Chevrolet Express, GMC Savana, 2019-2020 Chevrolet Blazer, Silverado 1500, GMC Acadia, Sierra 1500, and certain Continental tires sold to the aftermarket for various model year 2018-2021 vehicles. The affected tires were cured for too long during production.
Safety consequence
Over cured tires may develop a break in the sidewall resulting in sudden air loss or a belt edge separation which could lead to a tread/belt loss. Either condition can cause a loss of vehicle control, increasing the risk of a crash.
Manufacturer remedy
GM will notify owners, and dealers will inspect the tires, replacing them as necessary, free of charge. The recall began March 22, 2021. Owners may contact GMC customer service at 1-888-988-7267, Buick customer service at 1-866-608-8080, Chevrolet customer service at 1-800-222-1020 or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N212329050.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Other Chevrolet Express model years
Check your 2020 Chevrolet Express VIN
Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Chevrolet Express at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.
Check a Chevrolet VIN