2022 Volvo XC90 Recalls & Complaints

Incident: October 22, 2026 · Filed: October 24, 2026

I own a 2022 Volvo XC90 Recharge T8 plug-in hybrid. An authorized Volvo dealer diagnosed an internal fault in high-voltage battery Cell Module E. According to the technician's written report, diagnostic code BECM-P0BBE62 was present. The technician ran the Cell Module component test through Volvo's VIDA diagnostic system, which returned a “fault found” status for Cell Module E. The technician recommended replacing the faulty module. The replacement part is on back order, and I have been advised that obtaining battery modules into the United States is a known supply bottleneck that could delay repairs for several months. Volvo has confirmed that the repair is covered under warranty, but the vehicle remains unrepaired while I wait for the part. Of particular concern, the technician documented that the vehicle would not start when they attempted to move it into a parking space. The technician noted that this failure may or may not occur again. This creates uncertainty about the vehicle's ability to start and operate reliably. The vehicle previously displayed a “Propulsion System Service Required” warning. Although the vehicle had reportedly behaved normally during earlier driving, the subsequent diagnostic findings and failure to start raise concerns about the reliability and safe operation of the high-voltage propulsion system. I am concerned about: The high-voltage battery cell module failure and the possibility of a recurrence or additional battery faults. The vehicle's documented failure to start. The potentially prolonged period during which the vehicle cannot be repaired because the replacement module is unavailable. Whether similar failures and parts delays are affecting other Volvo plug-in hybrid vehicles. I request that NHTSA review this report alongside similar complaints to determine whether there is a broader safety-related defect or pattern involving high-voltage battery cell modules in affected Volvo plug-in hybrid vehicles, and whether further

Incident: October 2, 2026 · Filed: October 19, 2026

My 2022 Volvo XC90 (VIN: [XXX]) has a recurring failure of the center touchscreen display, which controls the climate system. Almost daily, the display shuts off while I’m driving and does not reboot. When it fails, I cannot use the heat, the windshield defroster, or the defogger. As cold weather sets in, this is a serious visibility and safety hazard. On XXX, at approximately 35,400 miles, I took the vehicle to the authorized Volvo dealership in [XXX] (repair order #XXX). I paid approximately $366 for a software reset. The repair did not fix the problem. Since then, the system crashes right after startup. It also intermittently plays loud white noise through the speakers, at random times and without warning while I’m driving. The sudden loud noise startles and distracts the driver. The dealer’s technician said he would submit a report to Volvo engineering. I have also opened a case with Volvo Car USA Customer Care. As of XXX, the vehicle has not been repaired, and the failures continue regularly. I have heard nothing back from Customer Care or the dealership despite repeated attempts to contact them respectively. Summary of hazards: Loss of windshield defrost and defog, which reduces visibility. Loss of cabin heat in winter conditions. Sudden loud audio noise that distracts the driver. A control screen that cannot be relied on while driving. I am asking NHTSA to review this as a potential safety defect affecting the center display and climate control on this model. Thank you. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident: June 2, 2026 · Filed: July 17, 2026

This is my 2nd Volvo xc90. Both models have turbo issues that is costly repairs. Volvo dealership also stated that turbo repairs usually are an issue in Volvo. My first Volvo was 2016 which had a turbo issue. Now my 2022 is now in shop due to turbo and oil spills on inside. There should be a recall.

Incident: April 1, 2026 · Filed: May 4, 2026

The electrical/infotainment display failure causes the factory rearview camera image not to display when the vehicle is shifted into reverse. The center infotainment display on my 2022 Volvo XC90 intermittently goes completely black and remains inoperable for days at a time. When the screen is black, the factory rearview camera image does not display when the vehicle is shifted into reverse. All sound, including warning signals, is inoperable. Climate controls are also inaccessible through the screen, and inoperable. This has happened repeatedly: the screen goes dark for several days, returns temporarily, then goes dark again. The failure affects rear visibility during backing events and creates a safety risk because the driver cannot see the rear camera image. I brought the vehicle to a Volvo dealer. The dealer stated that the infotainment head unit must be replaced and quoted approximately $4,000 to replace it with the same non-Google system. Volvo corporate denied assistance. I believe this is a safety-related defect because the failed infotainment display disables the rearview camera function.

Incident: February 25, 2026 · Filed: February 25, 2026

In the middle of a cold snowstorm the screen froze and started glitching. As I was trying to change the drive mode to all wheel drive the ESC off button triggered and ESC stayed off without AWD mode and screen was unresponsive. Had to pull over and turn car off and back on for screen to reset.

Incident: April 28, 2025 · Filed: October 29, 2025

There is a flaw in Volvo sunroof drains. There are class action lawsuits because of this. 6 months after purchasing my car, there was a leak into my car due to a clogged sunroof drains causing damage to electronics and potentially to computers within the car. I fixed it at a quote of over $2k. Volvo refused to cover it under my warranty. Now, 6 months after the fix, the SAME issue is happening.

Incident: September 18, 2025 · Filed: September 22, 2025

My car is a 2022 Volvo hybrid T8, 6-passenger XC90. I purchased the SUV in August of 2023 as a "certified pre-owned" vehicle with only 17,923 miles on it at the time of purchase. This SUV has been fine until within the last two to three months (July-Sept. 2025). Now, in Sept. of 2025, my SUV only has 30,795 miles and we have had it serviced regularly, as required, and taken care of it as responsible vehicle owners. Beginning around June or July of 2025, I began seeing the "check engine" light, so I called the dealership where I purchased the vehicle and took it in for servicing. After a day, they said it was fixed and that it was a blown fuse or two, and it was good to go. Not even 3 weeks to a month later, the "check engine" light came on again. I called and took it back to the dealership. Same story, after less than a day they called me back after fixing something else (don't remember off the top of my head what they said it was, but it was allegedly minor). Now, about 3 days ago, Sept. of 2025, I began seeing the "check engine" light again, so for the 3rd time in less than 3 months I arranged for it to be serviced by the dealership again on 9/30. A day later, another "Propulsion System/maintenance required!!!" light came on as well, so I called to get servicing sooner because obviously the message is scary. I was told to bring it in, they would "work me in" but had no loaners I could use to get to and from work. So, at that point, I got my husband involved and now no one from the dealership is returning either of our calls, AND I'm being told there is no recall on my car, even though a simple google search reveals there is a recall on my same make/model/year SUV. I'm getting the same messages people got about the recall, so no clue why my vehicle isn't considered as part of the recall when I am having the SAME issues as the recalled vehicles are having. I am beyond frustrated and ready to dump this SUV if they are unable to properly repair it!!!!!

Incident: July 21, 2025 · Filed: July 21, 2025

I park my Volvo in my driveway which has a blind exit to a pedestrian sidewalk. When I start the car and put it in D or B mode, it does not make any sound. This happens in any of the vehicle modes including "Pure" electric where the ICE is not engaged unless the battery runs out. There is no way for oncoming pedestrians to hear the vehicle or to understand that it might pull out of the blind corner. According to the NHTSA Federal Motor Vehicle Safety Standard Number 141 "The final rule requires hybrid and electric vehicles to emit sound at minimum levels while the vehicle is stationary (although not when the vehicle is parked, i.e., when the transmission is in “park”), while in reverse, and while the vehicle is in forward motion up to 30 km/h. (sic) full compliance should be by September 1, 2020" Our 2022 XC90 T8 Recharge does not make any sound while stationary in N, D, or B tranmission modes or while in Hybrid or Pure drive modes. I see this as a serious safety issue and wanted to report it before I have an actual safety incident. Volvo claims that my vehicle is in compliance with all NHTSA safety standards. Their response is attached.

Incident: June 18, 2025 · Filed: June 20, 2025

The contact owns a 2022 Volvo XC90. The contact received notification of NHTSA Campaign Number: 25V179000 (ELECTRICAL SYSTEM); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

Incident: February 23, 2024 · Filed: September 20, 2024

I received an SRS airbag, service urgent, drive to workshop warning. I took the car in six times the first two times they said it was a software update and they failed to update the software the third time they updated the software. It didn’t work the fourth time they said it was the passenger seat and the scale wasn’t working or connecting so it was throwing off the airbag. They fixed that, it didn’t change that warning. I still got the warning. And the last time they said it was a battery issue the battery wires weren’t connecting. They fix that, but after five minutes of driving out of the dealership and a repair shop, the warning came up again.I’ve sent an email to Corporate asking for either a refund or or a new car in accordance with the lemon law of California. They want me to take it in the seventh time which I refuse to do because the car is on safe safe to drive and I have two kids that I cannot keep driving in this car.