2017 Volvo XC90 Recalls & Complaints

Incident: September 18, 2026 · Filed: October 23, 2026

On 9/18/2026 at about 3:15 PM, the low coolant warning came on while I was driving in front of my child's school. Less than a minute later I pulled into the school pickup line, stopped, and turned the vehicle off. There was no smoke when I turned it off. After the engine was off, smoke began coming from the engine compartment, and within minutes the engine compartment was on fire. The fire occurred in a school pickup line surrounded by parents and children. An independent witness saw that the vehicle was off before any smoke appeared. The fire department and police responded. The engine compartment was destroyed and the vehicle is a total loss. Warning before failure: low coolant message, less than a minute before the vehicle was stopped. This vehicle has the B4204T27 (T6) engine. Volvo recalled 2016 XC90s with this engine (Recall 19V-308) because a cracked engine-side coolant bleeder hose could leak coolant onto the catalytic converter heat shield and cause a fire while the vehicle was stationary, with a low coolant warning as the sign. This 2017 was not included in that recall, but it gave the same warning and caught fire the same way while stationary. The vehicle was inspected by Volvo Car USA in October 2026. I have not received the inspection report. The failed component is UNKNOWN because the engine compartment was incinerated. I was exposed to smoke during the fire and am seeking medical evaluation.

Incident: September 30, 2026 · Filed: October 6, 2026

Volvo electric power steering system failure.

Incident: April 2, 2026 · Filed: September 23, 2026

Vehicle has exhibited lagging and stalling while driving in "Pure" (electric-only) mode since approximately April 2026, at approximately 85,000 miles, accompanied by an illuminated check engine light. This has occurred repeatedly at red lights, intersections, stop signs, and in stop-and-go traffic, creating a risk of sudden loss of propulsion in live traffic situations, including at intersections where an unexpected stall could result in a collision. The dealership (Volvo Cars of Fort Washington) has diagnosed this as originating from multiple hybrid drivetrain components over several repair visits: the High Voltage Coolant Heater (replaced per a referenced Volvo Technical Service Bulletin), the Inverter Electric Rear Axle Drive Module (IEM) — diagnostic data showed one internal transistor (phase W) reaching 135°C, a severe outlier compared to the other two phases reading approximately 25°C — the A/C refrigerant shutoff valve, and most recently the Electronic Rear Axle Drive (ERAD) transmission, where diagnostic monitoring showed the ERAD clutch slipping during test drives. Volvo's own internal case management system has classified this case as a "Repeat Repair." Despite multiple repair attempts, the underlying drivability defect (lagging/stalling) has recurred each time, including almost immediately after the vehicle was returned following the initial repair, with minimal intervening use. This pattern indicates a persistent, unresolved defect in the vehicle's hybrid drive system that presents a safety risk due to unpredictable loss of power while driving.

Incident: July 6, 2026 · Filed: September 22, 2026

2017 Volvo XC90 manufacturing defect where panoramic sunroof drainage network fails under normal rain, pooling water directly in the floorboard channels over safety module networks and wire harnesses.Water infiltration caused a catastrophic short-circuit of the floorboard-mounted amplifier while driving. This forced the audio system to emit an un-modulated, maximum-volume electronic blast through the cabin, causing severe driver distraction and documented temporary acute acoustic trauma/ear injuries to myself and my young child.Progressive electronic oxidation from ongoing water intrusion has since caused systemic failures of critical safety electronics. This includes spontaneous, unprompted activations of the automated emergency SOS calling network and dangerous operational delays in the backup camera engaging.Dealership service personnel inspected the vehicle and explicitly warned that the water-logged electrical networks are heavily compromised and at imminent risk of a complete blackout while in motion, posing a severe threat of sudden loss of power steering, braking, and propulsion on the highway. Rain is currently actively dripping from the interior ceiling onto passenger cabin components. This platform-wide engineering flaw creates an active fire, electrical, and crash hazard.

Incident: August 29, 2026 · Filed: September 20, 2026

I was driving my 2017 Volvo XC90 T6 Inscription when a ‘coolant low’ warning appeared. I immediately pulled over and the car began to smoke. I was unaware what to do so I called my husband and he told me to pop my hood. With 1.5 minutes of pulling over I open my door to find the lack to pop the hood and someone started yelling at me to get out. I looked up and the smoke had changed from white to brown- I exited the vehicle and called 911- Within approximately 5 minutes, the vehicle became fully engulfed in flames and was a total loss. The vehicle had been regularly maintained and to my knowledge, had no open recalls applicable at the time. After the fire, I became aware of a prior XC90 recall involving a coolant hose leak and fire risk. I understand that recall may not list my exact model year. I’m not claiming a specific cause, but due to the coolant warning preceding the fire, believe the circumstances warrant investigation. I was able to exit safely and no one was injured, but given how rapidly the fire developed, I’m concerned about the potential risk to others.

Incident: August 22, 2026 · Filed: September 1, 2026

2017 Volvo XC90 T8 plug-in hybrid, approximately 81,000 miles, experienced intermittent hesitation/loss of propulsion when accelerating. When acceleration is requested, the vehicle can hesitate before power is delivered, creating a serious safety concern when entering, merging into, or crossing traffic because expected acceleration is not immediately available. Diagnostic testing identified faults in the IEM/ERAD system, including P286D00, Clutch A Engagement Time Performance/Too Slow, and P0A1B62, Drive Motor A Control Module, Algorithm Based Failure. The vehicle is currently being evaluated by an authorized Volvo dealer. I was advised that the high-voltage battery cells appear to be functioning properly and that the dealer is consulting Volvo technical support regarding the loss-of-acceleration condition. Volvo has issued Technical Journal guidance addressing ERAD clutch DTCs, including P286D00, on this generation of XC90. I am concerned that delayed or failed engagement of the ERAD clutch can cause an unexpected delay or loss of propulsion during acceleration. I am also aware of another NHTSA complaint involving a 2017 Volvo XC90 ERAD clutch failure, NHTSA Complaint No. 11673211, describing a delay in propulsion followed by sudden power delivery. I am requesting that NHTSA review this condition as a potential safety defect involving ERAD clutch engagement and intermittent loss or delay of propulsion in Volvo XC90 T8 vehicles.

Incident: August 3, 2026 · Filed: August 10, 2026

The contact owns a 2017 Volvo XC90. The contact stated that while driving at an undisclosed speed, the window power switch was enabled; however, the window switch failed to function as intended. The contact stated that the rear-view camera, the door switch, and the air conditioner failed to function as intended. In addition, the contact became aware of water on the front passenger’s side floorboard. The vehicle was taken to the dealer. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact referenced an unknown recall; however, the VIN was not associated with a recall related to the failure. The manufacturer was not made aware of the failure. The failure mileage was approximately 94,000.

Incident: July 4, 2026 · Filed: July 11, 2026

Spark plugs, fuel injectors, cylinders and cylinder walls, pistons, oxygen sensor. Our safety was put at risk because the vehicles "reduced performance" was triggered and it affected the acceleration of the vehicle. The Volvo dealership was able to reproduce the issue because of the engine misfires.The only alert we received was the day prior our engine needed a liter of oil. We topped off the oil and that alert went away. The day we had the reduced performance we were alerted of that at the time on the highway. It's a little turtle icon. We were not able to accelerate efficiently and it was definitely unsafe to be driving but we had to get home.

Incident: June 2, 2026 · Filed: June 4, 2026

The contact's daughter owns a 2017 Volvo XC90. The contact stated that while her son-in-law was driving at an undisclosed speed, the brake pedal was firmly depressed, but the vehicle failed to stop immediately. No warning light was illuminated. The vehicle was towed to the dealer, who determined that the vacuum hose had detached and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 85,000.

Incident: April 19, 2026 · Filed: April 27, 2026

To whom it may concern. Our 2017 XC90 unexpectedly, spantaneously, and catastrophically caught fire under the hood and was a total loss 5 minutes after parking it on April 19, 2026. There were no leaks or other signs of mechanical issues. The vehicle had all regular maintenance completed at the Byers Volvo Service Department in Columbus, OH. It had no open recalls. It was always parked overnight in a garage. The Fire Inspector noted a possible vehicle manufacturing defect as the cause of the fire, however the vehicle was too heavily damaged to be definitive. We do have video of the entire incident as the Volvo was parked on Federal Government Property at the time. We are happy to share any and all information if this helps future vehicles to be safer. It should be noted that there is an active recall for the 2016 XC90 for a coolant hose leak that can cause a fire. Given that the 2017 XC90 is of the same design. Upon checking the internet and Reddit, it appears that our situation is not unique and there are other instances and reports of similar fires.