NHTSA vehicle safety data

2000 Volvo S80 Recalls, Ratings & Complaints

The 2000 Volvo S80 has 5 NHTSA recall campaigns and 318 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Volvo dealer.

NHTSA recall and complaint data for the 2000 Volvo S80, plus NCAP crash-test ratings. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2000 Volvo S80 owner complaints

Owners have filed 318 complaints with NHTSA about the 2000 Volvo S80, describing incidents dated September 1, 1999 to September 5, 2022.

Most-cited components

Vehicle Speed Control 93 complaints
Engine 71 complaints
Electrical System 54 complaints
Fuel/Propulsion System 41 complaints
Suspension 29 complaints
Power Train 23 complaints

Of the 318 complaints on file, 16 report a crash and 8 a fire; across all 318 complaints, owners report 13 injuries (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11494075 · Filed November 18, 2022
The contact owns a 2000 Volvo S80. The contact stated that while at a complete stop, the vehicle intermittently hesitated in responding while depressing the accelerator pedal. The contact stated that the check engine warning light was illuminated during the failure. The contact called the dealer and…
ODI #11351616 · Filed August 27, 2020
SWAPPED BATTERY AT O'REILLY'S AUTO PARTS. ALL MANUFACTURER SAFETY PROTOCOLS FOLLOWED. AFTER SWAPPING OUT W/NEW BATTERY: CLIMATE CONTROL MODULE NOT WORKING- SRS AIRBAG 'SERVICE URGENT' ERRORS. VOLVO QUOTING $2500 TO REPLACE CCM, $800 FOR REBUILD-PROCESS. DIM IS ALSO FRIED. NO HEAT OR A/C- AIRBAG…
ODI #11128657 · Filed September 11, 2018
I WANT TO MAKE YOU AWARE OF A VERY SERIOUS CAR ACCIDENT THAT MY MOTHER HAD ON 9-5-18. SHE WAS DRIVING HER 2000 VOLVO S80 WHEN HER CAR BEGAN TO ACCELERATE ON ITS OWN. SHE WAS NOT ABLE TO CONTROL THE CAR. MY MOM HAD HER FOOT ON THE BRAKE BUT THAT DID NOT STOP THE VEHICLE. UNFORTUNATELY, AT THAT POINT…

Read all 318 complaints

Owner-reported

2000 Volvo S80 mileage at failure

223 of the 318 complaints on file for the 2000 Volvo S80 give the vehicle's mileage when the problem happened.

Mileage at failure by component, from owners' complaints to NHTSA
Component	Median	Middle half	Based on
Vehicle Speed Control	Median 70,000 miles	Middle half 50,000–90,000 miles	Based on 70 complaints
Engine	Median 80,000 miles	Middle half 55,000–95,000 miles	Based on 51 complaints
Electrical System	Median 80,000 miles	Middle half 60,000–95,000 miles	Based on 41 complaints
Fuel/Propulsion System	Median 85,000 miles	Middle half 65,000–120,000 miles	Based on 34 complaints

A component's median is its 50th percentile, and its middle half runs from its 25th to its 75th percentile.

Owners give the mileage themselves, often as a round number, and NHTSA doesn't check it. A complaint that names several components counts under each one, and mileages that can't be right, such as 999,999, or 50 miles on a five-year-old car, are left out.

These figures describe the complaints owners filed. They don't predict when a particular vehicle will have a problem, and vehicles that never had one aren't counted.

Complaints received before December 15, 2002 rarely give a mileage, so they aren't counted here.

Mileage from NHTSA's complaints file of October 31, 2026. How these figures are worked out

NHTSA defect investigations

NHTSA's investigations file lists the 2000 Volvo S80 in 2 investigations. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Engineering Analysis EA05-021: THROTTLE CONTROL MALFUNCTION
Closed December 12, 2006
- Recall 06V-441
Preliminary Evaluation PE05-041: THROTTLE CONTROL MALFUNCTION
Closed December 7, 2005

Open and recently closed NHTSA defect investigations

760 PORTABLE AUTOMOTIVE GPS UNITS/GARMIN

NHTSA #10V566000 · Equipment — Electrical — Navigational System(GLOBAL POSITIONING SYSTEM) · NHTSA notice

Reported November 8, 2010 · VOLVO CARS OF N.A. LLC.

Potentially affected: 416 vehicles

Volvo campaign R231 · Owners notified November 18, 2010

Defect description

VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.

Safety consequence

AN OVERHEATED BATTERY COULD LEAD TO A FIRE.

Manufacturer remedy

VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 18, 2010. OWNERS MAY CONTACT GARMIN AT 866-957-1981 OR VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.

Notes

VOLVO SAFETY RECALL NO. R231.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

MASTER CYLINDER LEAK

NHTSA #07E023000 · Service Brakes, Hydraulic — Foundation Components — Master Cylinder · NHTSA notice

Reported March 29, 2007 · CARDONE INDUSTRIES, INC.

Potentially affected: 13,128 vehicles

Owners notified April 2, 2007

Defect description

CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.

Safety consequence

LOSS OF BRAKE FLUID CAN RESULT IN POOR BRAKING PERFORMANCE, POSSIBLY RESULTING IN A VEHICLE CRASH.

Manufacturer remedy

CARDONE WILL NOTIFY OWNERS AND OFFER TO REPURCHASE ANY DEFECTIVE MASTER CYLINDERS. THE RECALL BEGAN DURING APRIL 2007. OWNERS CAN CONTACT CARDONE AT 1-800-777-4780.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET CARDONE MASTER CYLINDERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED ABOVE.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

THROTTLE CONTROL MALFUNCTION

NHTSA #06V441000 · Vehicle Speed Control · NHTSA notice

Reported November 15, 2006 · VOLVO CARS OF N.A. LLC.

Potentially affected: 170,099 vehicles

Volvo campaign R155 · Owners notified December 29, 2006 · Vehicles built May 11, 1998 – August 27, 2001 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

ON CERTAIN PASSENGER VEHICLES, A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING, AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.

Safety consequence

THIS RESULTED IN A HIGH NUMBER OF VEHICLES GOING INTO THE LIMP HOME MODE WITHOUT NEED.

Manufacturer remedy

DEALERS WILL INSTALL THE CURRENT SOFTWARE UPGRADE ONTO THE INVOLVED VEHICLES. THE RECALL BEGAN ON DECEMBER 29, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.

Notes

VOLVO RECALL NO. R155. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

VOLVO/BOSCH/COOLING FANS

NHTSA #04V451000 · Engine and Engine Cooling — Cooling System — Fan · NHTSA notice

Reported September 13, 2004 · VOLVO CARS OF N.A. LLC.

Potentially affected: 149,799 vehicles

Volvo campaign 141 · Owners notified November 29, 2004 · Vehicles built May 6, 1998 – May 15, 2000 (per NHTSA)

Defect description

ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES, UNDER CERTAIN OPERATING CONDITIONS, SOME ELECTRIC COOLING FANS MAY OVERHEAT POTENTIALLY CAUSING HEAT DAMAGE AND, IN RARE INSTANCES, A FIRE IN THE ENGINE COMPARTMENT.

Safety consequence

A FIRE IN THE ENGINE COMPARTMENT COULD OCCUR.

Manufacturer remedy

DEALERS WILL REPLACE THE COOLING FAN. THE RECALL BEGAN ON NOVEMBER 29, 2004. CUSTOMERS SHOULD CONTACT VOLVO CARS AT 1-800-458-1552.

Notes

VOLVO RECALL NO. 141.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

VOLVO CARS/BALL JOINT

NHTSA #00V238000 · Suspension — Front — Control Arm — Upper Ball Joint · NHTSA notice

Reported August 24, 2000 · VOLVO CARS OF NA, INC.

Potentially affected: 49,488 vehicles

Volvo campaign 99 · Owners notified September 18, 2000 · Vehicles built April 1, 1998 – December 31, 1999 (per NHTSA)

Defect description

VEHICLE DESCRIPTION: PASSENGER VEHICLES. OVER TIME, THE BALL JOINT BETWEEN THE FRONT WHEEL KING PIN AND THE SUSPENSION LINK ARM, CAN EXPERIENCE INCREASED LOOSENESS.

Safety consequence

THIS CONDITION COULD AFFECT THE BALL JOINT'S DURABILITY AND PERFORMANCE.

Manufacturer remedy

DEALERS WILL REPLACE BOTH FRONT BALL JOINTS.

Notes

VOLVO RECALL NO. 99.OWNER NOTIFICATION BEGAN SEPTEMBER 18, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO AT 1-800-458-1552.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

2000 Volvo S80 4-DR. w/SAB

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: Not Rated, Passenger: Not Rated

Side Crash

Not Rated

Driver: 5, Passenger: 5

Side Pole

Not Rated

Rollover

Not Rated

Safety Technology

2 investigations

318 owner complaints have been filed with NHTSA for the 2000 Volvo S80.

Vehicle Speed Control

ODI #11494075

Incident: September 5, 2022 · Filed: November 18, 2022

The contact owns a 2000 Volvo S80. The contact stated that while at a complete stop, the vehicle intermittently hesitated in responding while depressing the accelerator pedal. The contact stated that the check engine warning light was illuminated during the failure. The contact called the dealer and the manufacturer and was informed that the vehicle was not included in NHTSA Campaign Number: 06V441000 (Vehicle Speed Control) which he linked to the failure. The vehicle was not repaired. The failure mileage was approximately 120,000.

Electrical System; Air Bags; Unknown or Other

ODI #11351616

Incident: August 7, 2020 · Filed: August 27, 2020

SWAPPED BATTERY AT O'REILLY'S AUTO PARTS. ALL MANUFACTURER SAFETY PROTOCOLS FOLLOWED. AFTER SWAPPING OUT W/NEW BATTERY: CLIMATE CONTROL MODULE NOT WORKING- SRS AIRBAG 'SERVICE URGENT' ERRORS. VOLVO QUOTING $2500 TO REPLACE CCM, $800 FOR REBUILD-PROCESS. DIM IS ALSO FRIED. NO HEAT OR A/C- AIRBAG ACCIDENTAL DEPLOYMENT RISK. QUICK SEARCH ONLINE SHOWS THIS IS A VOLVO ISSUE SPECIFIC TO S60, S80 & XC70 MODELS (ALL YEARS) FILED COMPLIANT W/VT STATE AG- CAP 2020-07438 ORIGINAL REPAIR ORDER ATTACHED

Service Brakes

ODI #11128657

Crash 3 injuries

Incident: September 5, 2018 · Filed: September 11, 2018

I WANT TO MAKE YOU AWARE OF A VERY SERIOUS CAR ACCIDENT THAT MY MOTHER HAD ON 9-5-18. SHE WAS DRIVING HER 2000 VOLVO S80 WHEN HER CAR BEGAN TO ACCELERATE ON ITS OWN. SHE WAS NOT ABLE TO CONTROL THE CAR. MY MOM HAD HER FOOT ON THE BRAKE BUT THAT DID NOT STOP THE VEHICLE. UNFORTUNATELY, AT THAT POINT THE CAR WAS OUT OF CONTROL HITTING AND BANGING UP ALL THE CARS AROUND IT. THEN THE CAR FINALLY SMASHED INTO ANOTHER CAR STOPPING THE OUT OF CONTROL CAR. MY MOM WAS SERIOUSLY HURT AND TAKEN TO THE HOSPITAL. SHE HAD EMERGENCY SURGERY TO REPAIR HER AORTA THAT TORE FROM THE CRASH. SHE ALSO BROKE HER STERNUM. I AM DEVASTATED BY WHAT HAPPENED TO MY MOM. I FEEL THAT IT IS EXTREMELY IMPORTANT THAT YOU AND VOLVO ARE MADE AWARE OF THIS TRAGIC SITUATION THAT OCCURRED BY THIS VOLVO S80.

Fuel System, Gasoline

ODI #10811616

Incident: December 21, 2015 · Filed: December 22, 2015

VEHICLE HAS THE SMELL OF FUEL. THE 2001-2005 MODELS HAVE A RECALL FOR THIS SAME ISSUE BECAUSE OF THE PLASTIC ON THE FUEL PUMP FLANGE CRACKING. MANY OWNERS OF THE 2000 MODELS ARE REPORTING THIS ISSUE. THE FUEL PUMP IS THE SAME USED ON THE 2000 YEAR MODEL AS THE 2001-2005 SO THE 2000 SHOULD BE PART OF THE RECALL ALSO. THE SMELL OF FUEL IS NOT JUST UNPLEASANT BUT DANGEROUS. I HAVE A 11 MONTH OLD SON WHO RIDES IN MY CAR AND IT WOULD BE TRAGIC IF SOMETHING HAPPENED TO MY FAMILY OR SOMEONE ELSE. YOU CAN SEARCH GOOGLE AND SEE MANY OTHER OWNERS REPORTING ISSUES IN THE 2000 MODEL VOLVO S80. PLEASE DO SOMETHING ABOUT THIS. THANK YOU! *TR

Electrical System; Unknown or Other; Fuel/Propulsion System

ODI #10788965

Incident: November 2, 2015 · Filed: November 7, 2015

I WAS DRIVING AND MY CAR LIGHTS AND ALL THE ELECTRONIC STOP WORKING AND TURN OFF

Fuel System, Gasoline

ODI #10782160

Incident: June 10, 2015 · Filed: October 14, 2015

TL* THE CONTACT OWNS A 2000 VOLVO S80. THE CONTACT NOTICED A FUEL ODOR NEAR THE REAR SEAT OF THE VEHICLE AND THE FUEL GAUGE INDICATOR DRASTICALLY DECREASED. THE CONTACT DISCOVERED AN EXCESSIVE AMOUNT OF FUEL LEAKING ON THE GROUND NEAR THE REAR SIDE OF THE VEHICLE UNDER THE FUEL TANK. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL PUMP FLANGE WAS CRACKED. THE MANUFACTURER STATED THAT THE VIN WAS EXCLUDED FROM NHTSA CAMPAIGN NUMBER: 09V483000 (FUEL SYSTEM, GASOLINE). THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 65,000. UPDATE 01/15/16 MA UPDATED 02/04/16. *JB UPDATED 03/04/16*LJ UPDATED 03/14/16.*JB

Engine and Engine Cooling; Visibility; Seat Belts

ODI #10702125

Incident: March 27, 2015 · Filed: March 27, 2015

MY DRIVER SEAT BELT JUST LOCKED UP AND I AM UNABLE TO GET IT TO RELEASE. ALL OF THE HOUSING INSIDE CAR APPEARS TO BE CRACKING. I HAVE HAD THE TWO FRONT WINDOWS REPAIRED OVER AND OVER AGAIN. AND NOW I CAN'T EVEN LET MY FRONT WINDOWS DOWN. I HAVE ALSO PAID TO HAVE THE THROTTLE BODY REPAIRED. NOT TO MENTION HOW MANY TIMES I HAVE HAD TO REPLACE THE O2 SENSORS. *TR

Fuel System, Gasoline

ODI #10644582

Incident: October 6, 2014 · Filed: October 14, 2014

WITHIN THE PAST FEW DAYS, I'VE GOTTEN MANY COMPLAINTS ABOUT THE FOUL SMELL OF GASOLINE LINGERING ON MY VEHICLE. SURE ENOUGH, I TAKE IT TO A MECHANIC AND THE FUEL PUMP IS VISIBLY MOIST ON THE EXTERIOR FROM AN OBVIOUS FUEL LEAKAGE. I RESEARCHED "VOLVO S80 FUEL PUMP" AND FOUND A RECALL IS IN PLACE. THE RECALL STARTS FROM 2001 MODELS AND RANGES UP TO 2005 MODELS AND IS DUE TO THE MATERIAL USED IN THE FUEL PUMP (RECALL CAMPAIGN 09V-483). SINCE MY VEHICLE IS A 2000 MODEL, MY LOCAL VOLVO DEALERSHIP SAID "I DO NOT MEET THE QUALIFICATIONS". MY CONCERN IS IF THE MATERIAL USED IN THE ASSEMBLY OF THE FUEL PUMP CHANGED FROM S80 2000 TO 2001 MODELS. I WOULD LIKE TO BE NOTIFIED WHAT MATERIAL WAS USED FOR S80 2000 MODELS VERSUS THE MATERIAL USED FOR S80 2001 MODELS AND MAKE SURE THAT THE MATERIAL FOR S80 2000 MODELS "MAY NOT DEVELOP CRACKS DUE TO EXPOSURE TO CERTAIN ENVIRONMENTAL CONDITIONS AND VARYING FUEL QUALITY" AS DOES THE S80 2001 MATERIAL. THANK YOU VERY MUCH. *TR

Fuel System, Gasoline

ODI #10637542

Incident: August 15, 2014 · Filed: September 19, 2014

COMPONENT: FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP THERE IS A STRONG SMELL OF RAW GASOLINE BOTH INSIDE AND OUTSIDE THE VEHICLE. GASOLINE IS DRIPPING FROM THE FUEL SYSTEM DIRECTLY BELOW THE POSITION OF THE FUEL PUMP. THE VEHICLE IS REGISTERED IN SARASOTA, FLORIDA, A WARM WEATHER CLIMATE. ALL INDICATIONS POINT TO RECALL NUMBER R220. THIS RECALL BEGINS WITH THE 2001 VOLVO S-80 AND THEREFORE DOES NOT INCLUDE MY 2000 MODEL YEAR. I CONTEND THAT THE RECALL SHOULD BE EXPANDED TO INCLUDE 2000 MODEL YEAR VOLVOS. V483000 VEHICLES IN WARM WEATHER CLIMATES MAY DEVELOP A FUEL LEAK CAR RECALLS VOLVO S80 RECALL 09V483000 VEHICLES IN WARM WEATHER CLIMATES MAY DEVELOP A FUEL LEAK ENGINE, JANUARY 15, 2010 REPAIRPAL EXPERT OVERVIEW OUR QUICK TAKE: VEHICLES OPERATED IN CERTAIN WARM WEATHER CLIMATES MAY DEVELOP A FUEL SMELL AND/OR LEAK. ORIGINAL RECALL FROM THE NHTSA MODEL YEAR(S): 2001, 2002, 2003, 2004, 2005 MFR'S REPORT DATE: JANUARY 15, 2010 NHTSA CAMPAIGN ID NUMBER: 09V483000 NHTSA ACTION NUMBER: PE09039. *TR

Fuel/Propulsion System

ODI #10628667

Incident: June 10, 2014 · Filed: August 27, 2014

TL* THE CONTACT OWNS A 2000 VOLVO S80. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 45 MPH, THE VEHICLE BEGAN TO SMELL OF FUEL. THE FAILURE RECURRED MULTIPLE TIMES. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS. THE MECHANIC STATED THAT THE FUEL PUMP NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 126,000.

Other Volvo S80 model years

Check your 2000 Volvo S80 VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Volvo S80 at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Volvo VIN