NHTSA vehicle safety data

2006 Volvo S80 Recalls, Ratings & Complaints

The 2006 Volvo S80 has 4 NHTSA recall campaigns and 12 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Volvo dealer.

NHTSA recall and complaint data for the 2006 Volvo S80, plus NCAP crash-test ratings. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2006 Volvo S80 owner complaints

Owners have filed 12 complaints with NHTSA about the 2006 Volvo S80, describing incidents dated February 2, 2008 to November 19, 2024.

Most-cited components

Electrical System 3 complaints
Engine 3 complaints
Vehicle Speed Control 3 complaints
Air Bags 2 complaints
Seat Belts 2 complaints
Service Brakes 2 complaints

Of the 12 complaints on file, 1 reports a crash (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11635682 · Filed January 13, 2025
on Tuesday 11/19/2024 i went to my car and saw that a lot of fluid had leaked out of it. i went to start my car and when the car came on the gas tank was empty, but i had just filled the tank up the day before and parked it. on monday the 11/18/2024 i had put gas in the tank. so on tuesday when i…
ODI #11500695 · Filed January 8, 2023
SAFETY RECALL R10125 for this vehicle has not been performed as of this date; received Safety Recall Notice letter from Volvo Car USA LLC 29 NOV 2021; have contacted dealer once immediately upon receipt of letter; Volvo Corporation 4 to 6 times telephonic and email with the last response (Volvo is…
ODI #11308320 · Filed February 10, 2020
TL* THE CONTACT OWNS A 2006 VOLVO S80. THE CONTACT STATED THAT WHILE DRIVING AND ATTEMPTING TO ACCELERATE, THE VEHICLE FAILED TO EXCEED 30 MPH. THE VEHICLE WAS TAKEN TO AN UNKNOWN DEALER IN BINGHAMTON, NEW YORK, TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT ACCELERATOR SENSOR-DIGITAL SENSOR NEEDED…

Read all 12 complaints

Driver's Air Bag Inflator May Explode

NHTSA #21V766000 · Air Bags — Frontal — Driver Side — Inflator Module · NHTSA notice

Reported September 30, 2021 · Volvo Car USA, LLC

Potentially affected: 259,383 vehicles

Repair completion: 21.58% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Volvo campaign R10125 · Owners notified November 29, 2021

Defect description

Volvo Car USA, LLC (Volvo Car) is recalling certain 2001-2006 S80 and 2001-2009 S60 vehicles. The driver's air bag inflator may explode during deployment, due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Safety consequence

An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

Manufacturer remedy

Dealers will replace the driver's air bag, free of charge. Owner notification letters were mailed November 29, 2021. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo's number for this recall is R10125.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

760 PORTABLE AUTOMOTIVE GPS UNITS/GARMIN

NHTSA #10V566000 · Equipment — Electrical — Navigational System(GLOBAL POSITIONING SYSTEM) · NHTSA notice

Reported November 8, 2010 · VOLVO CARS OF N.A. LLC.

Potentially affected: 416 vehicles

Volvo campaign R231 · Owners notified November 18, 2010

Defect description

VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.

Safety consequence

AN OVERHEATED BATTERY COULD LEAD TO A FIRE.

Manufacturer remedy

VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 18, 2010. OWNERS MAY CONTACT GARMIN AT 866-957-1981 OR VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.

Notes

VOLVO SAFETY RECALL NO. R231.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

MASTER CYLINDER LEAK

NHTSA #07E023000 · Service Brakes, Hydraulic — Foundation Components — Master Cylinder · NHTSA notice

Reported March 29, 2007 · CARDONE INDUSTRIES, INC.

Potentially affected: 13,128 vehicles

Owners notified April 2, 2007

Defect description

CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.

Safety consequence

LOSS OF BRAKE FLUID CAN RESULT IN POOR BRAKING PERFORMANCE, POSSIBLY RESULTING IN A VEHICLE CRASH.

Manufacturer remedy

CARDONE WILL NOTIFY OWNERS AND OFFER TO REPURCHASE ANY DEFECTIVE MASTER CYLINDERS. THE RECALL BEGAN DURING APRIL 2007. OWNERS CAN CONTACT CARDONE AT 1-800-777-4780.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET CARDONE MASTER CYLINDERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED ABOVE.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

TIRE CERTIFICATION LABEL/FMVSS 110

NHTSA #06V375000 · Equipment — Other — Labels · NHTSA notice

Reported October 3, 2006 · VOLVO CARS OF N.A. LLC.

Potentially affected: 19,700 vehicles

Volvo campaign 161 · Owners notified December 18, 2006 · Vehicles built May 16, 2005 – November 28, 2005 (per NHTSA)

Defect description

CERTAIN VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE LABEL DENOTING THE TIRE AND LOADING PRESSURE INFORMATION IS INCORRECT.

Safety consequence

A MISPRINTED LABEL WOULD LEAD TO IMPROPER VEHICLE LOADING SPECIFICATIONS OR TIRE INFLATION WHICH COULD RESULT IN A TIRE FAILURE, INCREASING THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL MAIL THE CORRECT LABELS FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 18, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.

Notes

VOLVO RECALL NO. 161.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

2006 Volvo S80 4-DR. w/SAB

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 5, Passenger: 5

Side Crash

Not Rated

Driver: 5, Passenger: 5

Side Pole

Not Rated

Rollover

Not Rated

Safety Technology

12 owner complaints have been filed with NHTSA for the 2006 Volvo S80.

Suspension; Service Brakes; Fuel/Propulsion System

ODI #11635682

Incident: November 19, 2024 · Filed: January 13, 2025

on Tuesday 11/19/2024 i went to my car and saw that a lot of fluid had leaked out of it. i went to start my car and when the car came on the gas tank was empty, but i had just filled the tank up the day before and parked it. on monday the 11/18/2024 i had put gas in the tank. so on tuesday when i had to go to the store i was pretty confused that the tank was low. this same thing had happened one time before but it never occurred that there was any kind of leak. but for an entire tank of gas to spill out is extremely concerning

Air Bags

ODI #11500695

Incident: January 4, 2022 · Filed: January 8, 2023

SAFETY RECALL R10125 for this vehicle has not been performed as of this date; received Safety Recall Notice letter from Volvo Car USA LLC 29 NOV 2021; have contacted dealer once immediately upon receipt of letter; Volvo Corporation 4 to 6 times telephonic and email with the last response (Volvo is looking into it) on 15 DEC 2022 upon which I have again responded with an email for a status check. My perception is that this VIN number has a three spoke steering wheel which would have to be manufactured (not four and requires different airbag) and that is not going to happen (last unoffical response from Volvo dealer in Jan 2022). Request assitance from NHTSA. Phone no is 5302647381 home or 7573282950 I could not find a way to report this failure to perform safety recall on your website

Vehicle Speed Control

ODI #11308320

Incident: January 22, 2020 · Filed: February 10, 2020

TL* THE CONTACT OWNS A 2006 VOLVO S80. THE CONTACT STATED THAT WHILE DRIVING AND ATTEMPTING TO ACCELERATE, THE VEHICLE FAILED TO EXCEED 30 MPH. THE VEHICLE WAS TAKEN TO AN UNKNOWN DEALER IN BINGHAMTON, NEW YORK, TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT ACCELERATOR SENSOR-DIGITAL SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE RECURRED. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 06V441000 (VEHICLE SPEED CONTROL) AS A POSSIBLE CAUSE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 86,000.

Electrical System

ODI #11287760

Incident: December 5, 2019 · Filed: December 8, 2019

WITHOUT PRECEDING EVENT, THE ELECTRICAL SYSTEMS MONITORING THE CAR-CHECK ENGINE LIGHTS, GAS GAUGE, VEHICLE RANGE, TIRE PRESSURE ETC HAVE CEASED TO FUNCTION. THE CAR WAS STATIONARY AT THE TIME THIS OCCURRED.

Visibility; Structure

ODI #11181984

Incident: February 20, 2019 · Filed: February 22, 2019

TL* THE CONTACT OWNS A 2006 VOLVO S80. WHILE DRIVING, THE CONTACT NOTICED A LARGE AMOUNT OF AIR ENTERING THE VEHICLE. SHE PULLED THE VEHICLE OVER AND NOTICED THAT THE FRONT EXTERIOR DRIVER'S SIDE DOOR PANEL, THE WINDSHIELD, AND THE ROOF WERE BECOMING DETACHED. THE VEHICLE WAS NOT TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 153,808.

Power Train; Vehicle Speed Control

ODI #10705105

Incident: May 28, 2008 · Filed: April 11, 2015

WHEN DRIVING THE TRANSMISSION SHIFT SLAMS / BUCKS FOR 2ND TO 3RD GEAR AT THE 20 TO 30 MILES PER HOUR. THE TRANSMISSION REVS AND THEN BANG?S INTO THE NEXT GEAR. THIS ALSO HAPPENS WHEN SLOWING DOWN AND COMING TO A STOP, YOU CAN FEEL IT BUCKING / JOLT (AS IF IT WAS SLIPPING) AS I APPLY THE BRAKE. I HAD REPORTED THIS TO THE VOLVO DEALER SEVERAL TIMES AND THEY SAID THAT NOTHING CAME UP ON THE CODES OR DIAGNOSTIC EQUIPMENT. I HAD THE TRANSMISSION OVERHAULED TOO IN APRIL 2013 AND IT RAN GOOD FOR ABOUT 12 MONTHS AND THAT BACK TO SAME SYMPTOMS / ISSUES. I ALSO BROUGHT IT BACK AGAIN AROUND AUGUST/SEPTEMBER 2014 TIME FRAME TO HAVE THE SOFTWARE UPDATED AND EXPLAINED THE TRANSMISSION SHIFTING PROBLEM AND AGAIN NO FAULT CODES. MY CONCERN IS THAT WHEN DRIVING THE VEHICLE IT COULD BE A HAZARD IF TRYING TO ACCELERATE QUICKLY OR TRYING TO STOP QUICKLY AND IT DOES NOT RESPOND AS IT SHOULD AND AN ACCIDENT OCCURS, AND A POSSIBLE FATALITY COULD RESULT. I ALSO DID SPEAK WITH VOLVO CUSTOMER SERVICES AND REGISTER A COMPLAINT WITH THEM. THIS IS NOT MY FIRST VOLVO, I HAVE OWNED VOLVOS SINCE 1988. PLEASE ADVISE OF FINDINGS AND RESOLUTION. *TR

Suspension; Service Brakes, Hydraulic; Engine and Engine Cooling; Air Bags

ODI #10514205

Incident: May 7, 2013 · Filed: June 3, 2013

2006 VOLVO S80 . CONSUMER WRITES IN REGARDS TO UNSATISFACTORY VEHICLE REPAIRS AND CUSTOMER SERVICE AT DEALERSHIP. *SMD THE FRONT BRAKES, PADS AND SHOCK ABSORBERS WERE REPLACED. ALSO, THE VEHICLE HAD AIR BAG PROBLEMS AND IT OVER HEATED.

Electrical System; Exterior Lighting

ODI #10386237

Incident: January 31, 2011 · Filed: March 2, 2011

FIRST THE HIGH BEAM HEADLIGHTS COULD NOT BE DIMMED AND CONSTANTLY REMAINED ON CREATING PROBLEMS FOR ONCOMING DRIVERS. NEXT THE HIGH BEAMS COULD NOT BE TURNED ON CREATING VISIBILITY ISSUES WHEN DRIVING THE CAR. THE COMPONENT THAT FAILED IS THE CENTRAL ELECTRONIC MODULE ( CEM ) . WHEN THE CEM FAILED IT ALSO BURNED OUT THE TURN SIGNAL BOARD. BOTH THE CEM AND THE TURN SIGNAL BOARD NEEDED TO BE REPLACED WITH NEW UNITS. *TR

Engine and Engine Cooling; Seat Belts

ODI #10364953

Incident: November 1, 2010 · Filed: November 9, 2010

2006 VOLVO S80. CONSUMER STATES DRIVER SEAT SIDE SEAT BELT WOULD STICK AND WOULD NOT RELEASE IMMEDIATELY. *TGW ALSO, THE RADIATOR LEAKED COOLANT DUE TO A LEAK. *JB

Seat Belts

ODI #10351450

Incident: March 5, 2010 · Filed: August 24, 2010

TL* THE CONTACT OWNS A 2006 VOLVO S80. THE CONTACT STATED THAT THE DRIVER SIDE SEAT BELT WOULD FAIL INTERMITTENTLY. WHEN DEPRESSING THE RELEASE BUTTON, THE SEAT BELT WOULD NOT IMMEDIATELY RELEASE THE CONTACT. THE SEAT BELT WOULD RELEASE AFTER SEVERAL ATTEMPTS. THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE AND THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS APPROXIMATELY 32,000.

Other Volvo S80 model years

Check your 2006 Volvo S80 VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Volvo S80 at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Volvo VIN