2016 Toyota Corolla Recalls, Ratings & Complaints

Incident: September 25, 2026 · Filed: October 13, 2026

While operating a vehicle through the peer-to-peer car-sharing platform Turo in Alaska (Reservation: 61060048), the vehicle experienced a sudden, catastrophic brake failure of the braking system while driving. The brakes completely failed to respond, creating an immediate loss of vehicle control. Immediately following the braking failure, upon exiting the vehicle, smoke erupted from the wheel well/undercarriage area. This subsequently led to a minor burn on one of the passenger's face and hand. Before this event occured, we had discussed an issue with the brake light remaining on. When discussing it with the host, she had assured me that the vehicle had been thoroughly inspected before renting it to us. She gave us a few DIY solutions we could try out, but we opted to not attempt anything of that nature. She did tell us we could take it to the mechanic if we were concerned, but we would have had to cover the cost of an inspection. After the event, the host had the car towed, but we are completely unaware if they had the vehicle inspected.

Incident: September 11, 2026 · Filed: September 11, 2026

The defrost no longer works. When I put on defrost it doesn't blow out of the defrost causing me not to be able to see out of my windshield. I have found other people online with this same issue. My heat and air conditioner work fine.

Incident: August 15, 2026 · Filed: August 26, 2026

Purchased set of 4 Cooper CS5 Ultra Touring 195/65R1591H tires on 26 Jun 2026 @ 48,847 miles on the odometer. Three of the tires had the same serial number of U9AE1CR2622, with the 4th of U9AE1CR4822. Brought car in for service on 20 Oct 2025 @ 65,340 due to a slow leak on the rear passenger and was informed the rear passenger and front driver tires had tread separation and needed replacing. The tires both had a serial number of U9AE1CR2622. Tires were replaced. 15 Aug 2026, the front driver tire (the remaining tire with the U9AE1CR2622 serial number; it had been rotated to that position during the 20 Oct 2025 service) the tire pressure indicator light came on and discovered a slight (~7 psi) drop and aired up to correct pressure. However the tread appears rounded as apposed to flat across like the other tires and have confirmed the tread has separated. The car is driven moderately on paved roads and does not sit for extended periods of times. The tread depth is still quite deep. I expected much more out of these tires and do not plan on buying Cooper again. I believe the Cooper CS5 Ultra Touring 195/65R1591H tires (and perhaps more specifically, the U9AE1CR2622 batch) is defective and dangerous.

Incident: January 8, 2024 · Filed: July 14, 2026

The CVT transmission on my 2016 Toyota Corolla initially suffered a complete mechanical failure and was repaired on 01/08/2024, forcing me to pay $3,696 out of pocket for a replacement at an independent shop. Last week, the transmission experienced issues again, and this time a certified Toyota dealership serviced it for free under an active factory recall. This proves the vehicle has a documented factory defect. However, Toyota is currently refusing to reimburse me for the original $3,696 repair expense incurred due to this exact defect.

Incident: March 16, 2026 · Filed: June 26, 2026

The factory-applied Super White (paint code 040) paint on my vehicle has peeled down to bare metal on multiple exterior body panels. The peeling is not the result of any collision damage, scratches, or external trauma — it is consistent with the known factory paint adhesion defect that Toyota itself acknowledged through Customer Support Program ZKG, which covered this exact vehicle model, year, and paint color. Toyota's own program documentation states the defect occurs when sunlight degrades adhesion between the factory paint primer coat and the base metal electrodeposition layer. With paint peeled to bare metal, the affected panels are now exposed to moisture and the elements, creating a risk of structural rust and corrosion over time. I purchased this vehicle used in 2023 and was never notified of the Customer Support Program. By the time I discovered the program existed, the coverage had expired. Toyota has declined to provide any assistance. Toyota acknowledged this as a manufacturing defect affecting approximately 1.74 million vehicles under Program ZKG. Owners of 2016 Corollas who purchased their vehicles used were not adequately notified, and coverage has now lapsed for recently expired vehicles despite the defect being identical to those Toyota previously covered. I am requesting that NHTSA investigate whether Toyota's Customer Support Program ZKG adequately covered all affected vehicles and owners, and whether an expanded or extended remedy is warranted.

Incident: May 18, 2026 · Filed: May 20, 2026

I was driving on the highway and the transmission gave completely out!! with no warning! No check engine light no error message. Car only has 160000 miles on it, if i wasn't calm as I was that could've been lethal!!!!

Incident: April 8, 2026 · Filed: April 20, 2026

I have super white (040) paint and it's flaking off due to original manufacturer paint defect. Paint is flaking off my passenger back door and a large piece/area of roof. flakes of paint will come off at highway speeds, creating a vision hazard for drivers behind me or a distraction when flakes hit the windshield.

Incident: October 24, 2024 · Filed: December 28, 2025

In 2024, my 2016 Toyota Corolla was involved in a collision. The airbags did not deploy. I went to the emergency room following the crash and later required additional medical treatment, including rehabilitation.

Incident: November 21, 2025 · Filed: December 2, 2025

My 2016 Toyota Corolla suddenly showed a Check Engine light, and the dealer diagnosed a CVT transmission failure with code P2757. This code is linked directly to Toyota’s own TSB T-SB-0150-16 for torque converter clutch/valve-body failure. The dealer confirmed the issue and quoted me $11K to fix it. This is frightening because a failing transmission can slip, hesitate, or lose power at any moment, which puts me and others at risk. There were no early warning signs, just the sudden light. I brought it in immediately, and the problem was fully reproduced and documented by Toyota. My car is available for inspection whenever needed. Toyota corporate reviewed my case but offered very little help since my vehicle is just outside the 7-year timeframe for CA. I bought the extended warranty when the car was brand new. I have done every single service at Toyota, always on time, and my car has never been in an accident. I’ve taken care of it exactly the way Toyota told me to. This is not normal wear. This is a documented defect that puts drivers at risk and places an enormous financial burden on owners who did everything right. I’m filing this complaint because people deserve protection, accountability, and fairness, especially when a safety-related failure happens in a well-maintained vehicle. I’m only [XXX] , and I expected to own many more Toyotas throughout my life. My whole family drives Toyotas. I grew up believing this brand meant safety, reliability, and loyalty in both directions. I honestly wanted to be a Toyota driver for life. But facing an $11K repair for a known issue that Toyota already acknowledged in a TSB—without meaningful support—has broken my trust in a way I never expected. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident: May 1, 2025 · Filed: November 17, 2025

The driver seat belt dont work and once in a great while it will work but even whenever it does latch it still shows the seat belt isn't on and that noise keeps going off but after a while the noise goes off but the symbol is still on the dash board. I recently got hit from behind (09/15/2025) at a red light and no air bags deployed. Im not sure if they were suppose to deploy but either way my seat belt dont work. And I know this isn't a safety matter but my radio doesn't turn off when I turn off my car and I can't lock/unlock my doors with the key fob I have to lock it with the key on the driver door. I have to take the fuse out for the radio so my battery won't die and so the radio turns off.