NHTSA vehicle safety data

2005 Toyota Corolla Recalls, Ratings & Complaints

The 2005 Toyota Corolla has 10 NHTSA recall campaigns and 854 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Toyota dealer.

NHTSA recall and complaint data for the 2005 Toyota Corolla, plus NCAP crash-test ratings. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2005 Toyota Corolla owner complaints

Owners have filed 854 complaints with NHTSA about the 2005 Toyota Corolla, describing incidents dated June 30, 2004 to June 14, 2026.

Most-cited components

Air Bags 457 complaints
Engine 120 complaints
Vehicle Speed Control 66 complaints
Electrical System 59 complaints
Power Train 37 complaints
Service Brakes 37 complaints

Of the 854 complaints on file, 114 report a crash and 4 a fire; across all 854 complaints, owners report 89 injuries and 1 death (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11770549 · Filed October 12, 2026
II own a 2005 Toyota Corolla. Since XXX, I have repeatedly asked Keating Toyota in [XXX], to complete the airbag and engine control module (ECM) recall repairs. As of XXX, the repairs remain incomplete. The dealership has either not obtained the needed parts or had parts available without calling me…
ODI #11744134 · Filed June 15, 2026
The contact owns a 2005 Toyota Corolla. The contact stated that while driving, the odometer failed to exceed 299,999. The local dealer was not contacted. The manufacturer was made aware of the issue. The failure mileage was 299,999.
ODI #11742121 · Filed June 4, 2026
See attached document for complaint.

Read all 854 complaints

Owner-reported

2005 Toyota Corolla mileage at failure

430 of the 854 complaints on file for the 2005 Toyota Corolla give the vehicle's mileage when the problem happened.

Mileage at failure by component, from owners' complaints to NHTSA
Component	Median	Middle half	Based on
Air Bags	Median 90,000 miles	Middle half 60,000–125,000 miles	Based on 108 complaints
Engine	Median 70,000 miles	Middle half 40,000–100,000 miles	Based on 100 complaints
Vehicle Speed Control	Median 40,000 miles	Middle half 20,000–55,000 miles	Based on 52 complaints
Electrical System	Median 90,000 miles	Middle half 50,000–115,000 miles	Based on 49 complaints
Power Train	Median 95,000 miles	Middle half 70,000–110,000 miles	Based on 34 complaints
Service Brakes	Median 50,000 miles	Middle half 9,000–95,000 miles	Based on 30 complaints

A component's median is its 50th percentile, and its middle half runs from its 25th to its 75th percentile.

Owners give the mileage themselves, often as a round number, and NHTSA doesn't check it. A complaint that names several components counts under each one, and mileages that can't be right, such as 999,999, or 50 miles on a five-year-old car, are left out.

These figures describe the complaints owners filed. They don't predict when a particular vehicle will have a problem, and vehicles that never had one aren't counted.

Mileage from NHTSA's complaints file of October 31, 2026. How these figures are worked out

NHTSA defect investigations

NHTSA's investigations file lists the 2005 Toyota Corolla in 4 investigations. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Engineering Analysis EA21-002: Desiccated Air Bag Inflator Rupture
Open since September 17, 2021
Engineering Analysis EA15-001: Air Bag Inflator Rupture
Open since February 24, 2015
- Recall 14V-668
- Recall 15V-284
- Recall 15V-285
- Recall 15V-286
- Recall 15V-287
- Recall 15V-312
- and 188 more on the investigation page
Preliminary Evaluation PE14-016: Air Bag Inflator Rupture
Closed March 2, 2015
- Recall 13V-172
- Recall 14V-428
- Recall 14V-700
- Recall 14V-763
- Recall 14V-770
- Recall 14V-787
- and 3 more on the investigation page
Engineering Analysis EA10-006: Engine Stall
Closed September 16, 2010
- Recall 10V-384
- Recall 10V-387

Open and recently closed NHTSA defect investigations

Frontal Air Bag Inflators May Explode

NHTSA #19V741000 · Air Bags — Frontal — Passenger Side — Inflator Module · NHTSA notice

Reported October 17, 2019 · Toyota Motor Engineering & Manufacturing

Potentially affected: 928,220 vehicles

Repair completion: 72.6% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Toyota campaign J0A, J0B, J0C, JLI · Owners notified November 20, 2019 · Vehicles built December 28, 2001 – July 12, 2013 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Recall group: Takata airbag inflators

Defect description

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2016 4Runner, 2003-2006 Tundra, 2003-2013 Corolla, 2009-2010 Corolla Matrix, 2004-2005 RAV4, 2002-2007 Sequoia, 2011-2013 Sienna, 2008-2012 Scion xB, 2008-2009 Lexus IS-F, 2007-2012 Yaris and Lexus ES350, 2010-2017 Lexus GX460, 2002-2010 Lexus SC430, 2006-2012 Lexus IS250 and IS350 and 2010-2015 Lexus IS250C and IS350C vehicles. These vehicles had their driver or passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.

Safety consequence

An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Manufacturer remedy

Toyota will notify owners. Depending on the vehicle model, dealers will replace the front driver inflator, front passenger airbag inflator, the airbag assembly, or the front passenger airbag sub-assembly and inflator. The recall began November 20, 2019. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are J0A, J0B, and J0C. Lexus' numbers for this recall are JLI, JLJ, and JLK.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Front Passenger Air Bag May Not Properly Inflate

NHTSA #19V627000 · Air Bags — Frontal — Passenger Side — Inflator Module · NHTSA notice

Reported August 28, 2019 · Toyota Motor Engineering & Manufacturing

Potentially affected: 229,460 vehicles

Repair completion: 36.19% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Toyota campaign K1Q / K0Q · Owners notified October 18, 2019 · Vehicles built January 4, 2002 – July 20, 2007 (per NHTSA)

Defect description

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2003-2008 Corolla, 2005-2008 Corolla Matrix, and Pontiac Vibe vehicles equipped with a front passenger air bag assembly replaced under a prior recall. The air bag may not unfold as designed during inflation under high temperature conditions, possibly resulting in the air bag not inflating properly.

Safety consequence

An improperly inflated air bag increases the risk of injury during a crash.

Manufacturer remedy

Toyota will notify their owners. Pontiac Vibe owners will be notified by GM. Dealers will replace the front passenger air bag assembly or sub-assembly, free of charge. Toyota owners may contact Toyota customer service at 1-888-270-9371. Toyota's numbers for this recall are K1Q and K0Q. Pontiac owners may contact GM customer service at 1-800-762-2737. GM's number for this recall is N192273760.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Passenger Frontal Air Bag Inflator May Explode

NHTSA #18V883000 · Air Bags — Frontal — Passenger Side — Inflator Module · NHTSA notice

Reported December 12, 2018 · Toyota Motor Engineering & Manufacturing

Potentially affected: 168,993 vehicles

Repair completion: 74.53% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Owners notified January 23, 2019 · Vehicles built December 28, 2001 – December 23, 2004 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Recall group: Takata airbag inflators

Defect description

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2002-2005 Lexus SC and Toyota Sequoia, 2003-2005 Toyota Corolla and Tundra, and 2003-2007 Pontiac Vibe vehicles. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation.

Safety consequence

An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Manufacturer remedy

Toyota will notify the Toyota and Lexus owners. General Motors will notify the Pontiac Vibe owners. Depending on the vehicle model, dealers will replace the front passenger air bag inflator with an alternate inflator, or replace the air bag assembly that includes an alternate inflator, free of charge. The recall began January 23, 2019. Owners may contact Toyota customer service at 1-888-270-9371, Lexus customer service at 1-800-255-3987 or Pontiac customer service at 1-800-762-2737. Toyota's numbers for these recalls are J0A (Zone A Toyota), J0B (Zone B Toyota), J0C (Zone C Toyota), JLI (Zone A Lexus), JLJ (Zone B Lexus), and JLK (Zone C Lexus). Note: This recall includes vehicles that have had their air bag previously replaced under an earlier air bag campaign.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Passenger Side Front Air Bag Inflator may Rupture

NHTSA #15V285000 · Air Bags · NHTSA notice

Reported May 13, 2015 · Toyota Motor Engineering & Manufacturing

Potentially affected: 1,973,468 vehicles

Repair completion: 89% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Owners notified July 13, 2015 · Vehicles built December 17, 2001 – July 4, 2007 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Recall group: Takata airbag inflators

Defect description

Toyota Motor Engineering & Manufacturing (Toyota) notified the agency on May 13, 2015 that they are recalling certain model year 2004 Sequoia vehicles manufactured August 18, 2003, to August 19, 2004, and 2003-2004 Tundra vehicles manufactured March 18, 2003, to August 25, 2004. On June 16, 2015, Toyota expanded the recall to include an additional 1,270,468 vehicles, including model year 2002-2003 and 2005-2007 Sequoia, 2005-2006 Tundra, 2003-2007 Corolla, 2003-2007 Corolla Matrix, 2003-2007 Pontiac Vibe and 2002-2007 Lexus SC vehicles. This is to address a safety defect in the passenger side frontal air bag inflator which may produce excessive internal pressure causing the inflator to rupture upon deployment of the air bag. This recall addresses both the passenger side frontal air bags that were originally installed in the vehicles, as well as replacement air bags that may have been installed as replacement service parts. A replacement air bag may have been installed, as one example, if a vehicle had been in a crash necessitating the replacement of the passenger side frontal air bag.

Safety consequence

In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.

Manufacturer remedy

2003-2004 Corolla and Corolla Matrix vehicles that are recalled under both 15V-043 and 15V-285 are under a Do Not Drive advisory. Owners of these vehicles are advised not to drive their vehicles until the recall remedy has been completed. Toyota will notify their owners. Pontiac Vibe owners will be notified by GM. Dealers will replace the front passenger air bag. The recall began on July 13, 2015. Toyota owners may contact Toyota customer service at 1-800-331-4331. Pontiac owners may call 1-800-762-2737. NOTE: This recall supersedes recall 14V-312 in its entirety.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Passenger Side Front Air Bag Inflator may Rupture

NHTSA #15V286000 · Air Bags · NHTSA notice

Reported May 13, 2015 · Toyota Motor Engineering & Manufacturing

Potentially affected: 1,069,055 vehicles

Repair completion: 86.72% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Toyota campaign 14491 · Owners notified July 13, 2015 · Recall influenced by NHTSA's Office of Defects Investigation

Recall group: Takata airbag inflators

Defect description

Toyota Motor Engineering & Manufacturing (Toyota) notified the agency on May 13, 2015, that they are recalling 2005-2007 Lexus SC, Toyota Corolla, Corolla Matrix, Sequoia, and Pontiac Vibe, and 2005-2006 Toyota Tundra vehicles that were originally sold, or ever registered, in Florida, along the Gulf Coast, Puerto Rico, Hawaii, the U.S. Virgin Islands, Guam, Saipan and American Samoa. On June 16, 2015 Toyota expanded the recall to cover an additional 769,055 vehicles, including certain model year 2002-2004 Lexus SC, Toyota Sequoia, 2003-2004 Toyota Corolla Matrix, Toyota Corolla, Pontiac Vibe, and Toyota Tundra vehicles, as well the vehicles covered by the May 13, 2015 notification in the portions of Georgia, Alabama, Louisiana, Mississippi and Texas that were not previously included. The inflators in the front passenger air bags are susceptible to rupture in the event of a crash necessitating the deployment of the front passenger air bag.

Safety consequence

Manufacturer remedy

2003-2004 Corolla and Corolla Matrix vehicles that are recalled under both 15V-043 and 15V-286 are under a Do Not Drive advisory. Owners of these vehicles are advised not to drive their vehicles until the recall remedy has been completed. Toyota will notify their owners. Pontiac Vibe owners will be notified by GM. Dealers will replace the passenger side front air bag, free of charge. Owners may contact Toyota customer service at 1-800-331-4331. Toyota began the recall on July 13, 2015. Pontiac Vibe owners may contact GM at 1-800-762-2737. GM began the recall on June 29, 2015. NOTE: This recacll supersedes recall 14V-655 in its entirety. For vehicles located in the U.S. states not listed above, please see Toyota recall 15V-285 which covers all other U.S. states.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

ENGINE STALLING

NHTSA #10V384000 · Engine and Engine Cooling · NHTSA notice

Reported August 26, 2010 · TOYOTA MOTOR NORTH AMERICA, INC.

Potentially affected: 1,128,659 vehicles

Owners notified November 29, 2010 · Vehicles built April 19, 2004 – January 2, 2008 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2008 COROLLA AND COROLLA MATRIX VEHICLES. THE ENGINE CONTROL MODULE (ECM) FOR THE SUBJECT MODELS EQUIPPED WITH THE 1ZZ-FE ENGINE AND TWO-WHEEL DRIVE MAY HAVE BEEN IMPROPERLY MANUFACTURED. THERE IS A POSSIBILITY THAT A CRACK MAY DEVELOP AT CERTAIN SOLDER POINTS OR ON VARISTORS ON THE CIRCUIT BOARD.

Safety consequence

THERE ARE A VARIETY OF WARNINGS AND CONSEQUENCES ASSOCIATED WITH THE DEFECT. THE ENGINE WARNING LAMP COULD BE ILLUMINATED, HARSH SHIFTING COULD RESULT, THE ENGINE MAY NOT START, OR THE ENGINE COULD SHUT OFF WHILE THE VEHICLE IS BEING DRIVEN. AN ENGINE SHUTOFF WHILE THE VEHICLE IS BEING DRIVEN INCREASES THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL INSPECT THE PRODUCTION NUMBER OF THE ECM AND REPLACE THE ECM IF NECESSARY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. TOYOTA WILL MAIL AN INTERIM OWNER NOTIFICATION THE MIDDLE OF SEPTEMBER 2010 TO ADVISE OWNERS OF THIS DEFECT AND RECALL. THIS INTERIM NOTIFICATION WILL INFORM OWNERS THAT THEY WILL RECEIVE A FUTURE NOTIFICATION WHEN PARTS BECOME AVAILABLE TO HAVE THE FREE REMEDY PERFORMED ON THEIR VEHICLE. THE SAFETY RECALL BEGAN ON NOVEMBER 29, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

Notes

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

FMVSS 108/REPLACEMENT HEADLAMPS/AMBER REFLECTOR

NHTSA #09E025000 · Exterior Lighting — Headlights · NHTSA notice

Reported May 11, 2009 · DOPE, INC.

Potentially affected: 42,540 vehicles

Owners notified July 28, 2009

Defect description

DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Safety consequence

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Manufacturer remedy

DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY DOPE, INC.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

FMVSS 108/AFTERMARKET COMBINATION LAMPS

NHTSA #09E012000 · Exterior Lighting · NHTSA notice

Reported April 7, 2009 · SABERSPORT

Potentially affected: 16,270 vehicles

Owners notified May 11, 2009

Defect description

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Safety consequence

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Manufacturer remedy

SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

FMVSS 108/AMBER SIDE REFLECTORS

NHTSA #06E064000 · Exterior Lighting · NHTSA notice

Reported July 17, 2006 · TRADESONIC

Potentially affected: 4,029 vehicles

Defect description

CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Safety consequence

LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.

Manufacturer remedy

TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.

Notes

THIS RECALL ONLY PERTAINS TO TRADESONIC AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

FMVSS 108/HEADLAMP/AMBER SIDE REFLEX REFLECTOR

NHTSA #06E023000 · Exterior Lighting — Headlights · NHTSA notice

Reported March 13, 2006 · ANZO USA, INC.

Potentially affected: 292,000 vehicles

Owners notified May 9, 2006

Defect description

CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."

Safety consequence

WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.

Manufacturer remedy

ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET HEADLAMP ASSEMBLIES MANUFACTURED BY ANZO AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

2005 Toyota Corolla 4-DR.

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 5, Passenger: 5

Side Crash

Not Rated

Driver: 4, Passenger: 4

Side Pole

Not Rated

Rollover

Not Rated

Safety Technology

4 investigations

854 owner complaints have been filed with NHTSA for the 2005 Toyota Corolla.

Electrical System; Air Bags

ODI #11770549

Incident: January 6, 2026 · Filed: October 12, 2026

II own a 2005 Toyota Corolla. Since XXX, I have repeatedly asked Keating Toyota in [XXX], to complete the airbag and engine control module (ECM) recall repairs. As of XXX, the repairs remain incomplete. The dealership has either not obtained the needed parts or had parts available without calling me to schedule the repair. Despite my repeated requests, these issues remain unresolved after approximately nine months. I've also asked then to keep me updated and they don't. They also told me they had the parts at one time and they sent them back because I did not get them. They never called me and if they did, they did not leave a message. The car will stop moving and I will have to pull to side of road. I keep shutting car off and on until it will drive. It goes into some kind of limp mode. Please review this failure to complete the recall repairs and assist in obtaining a written response from Toyota identifying the parts availability and a firm repair appointment. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Electrical System

ODI #11744134

Incident: June 14, 2026 · Filed: June 15, 2026

The contact owns a 2005 Toyota Corolla. The contact stated that while driving, the odometer failed to exceed 299,999. The local dealer was not contacted. The manufacturer was made aware of the issue. The failure mileage was 299,999.

Power Train

ODI #11742121

Incident: April 13, 2026 · Filed: June 4, 2026

See attached document for complaint.

Air Bags

ODI #11732299

Crash

Incident: April 18, 2026 · Filed: April 20, 2026

Was in a wreck where I ended up rear ending a truck. I dont know how fast I was at after putting on the brakes. But originally it was 60 mph speed limit. The air bags did not deploy at all

Air Bags

ODI #11706410

Incident: December 21, 2025 · Filed: December 21, 2025

I was in the middle lane and a car came into my lane so I swerved and a car came up on me in the right lane and my car did a 360 and ended up in a ditch

Air Bags

ODI #11698418

Crash

Incident: August 10, 2024 · Filed: November 9, 2025

The location of the collision sensors are positioned too low to allow consistent deployment of the airbags in the event of a collision with newer generation pickup trucks. The bumpers on the pickup trucks are too high, so a rear end collision results in the Toyota Corolla passing underneath the truck, and the air bag sensors do not sense the collision. The collision is only stopped when the windshield of the Toyota makes contact with the bumper, or the front of car impacts the axle of the pickup trucks.

Air Bags; Seat Belts

ODI #11685086

Incident: September 4, 2020 · Filed: September 4, 2025

The contact owns a 2005 Toyota Corolla. The contact stated after an air bag recall repair was performed on the vehicle, the front passenger's seat belt warning light illuminated. The dealer was notified of the failure, but no assistance was provided. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not notified of the failure. The failure mileage was unknown.

Air Bags

ODI #11662700

Incident: May 22, 2025 · Filed: May 23, 2025

My son drove the car to the store less than 2 miles from the house and the airbag light came on and stayed while he was driving. He looked up the light in the owners manual and it said take vehicle to the Toyota dealer immediately! I know multiple cars we have owned in the past have had airbag recalls. I can not remember if this one has ever been recalled and repaired in the past. I attached the photos of the light and the manual.

Steering; Service Brakes

ODI #11647693

Incident: January 3, 2025 · Filed: March 11, 2025

Complaint Against Ben Nielsen Skyline Automotive – Faulty Repairs & Lack of Response I am filing a complaint regarding incomplete and faulty repairs performed on my household’s 2005 Toyota Corolla CE at Ben Nielsen Skyline Automotive on November 22, 2024 (Invoice #1 attached) and January 3, 2025 (Invoice #2 attached). During my first visit, the mechanic identified an oil leak, added dye to locate the source, and instructed me to return after 100 miles for further repairs. I followed these instructions and returned on January 3, 2025, when the shop also adjusted the tie rod and installed new rear brakes. At the time, I trusted that the work had been completed to a professional standard and that my vehicle was safe to drive. However, during a visit to Shirlington Shell on February 22, 2025, for an unrelated inspection (Invoice #3 attached), their mechanic raised serious concerns about the quality of repairs done by Ben Nielsen Skyline Automotive: - The tie rod adjustment was not completed properly, which the second mechanic stated made the car potentially unsafe to drive (video evidence available upon request). - The fluid leak was not fully resolved. - The rear brakes installed by Ben Nielsen Skyline Automotive are making noise, suggesting they were not installed correctly. These issues indicate that the repairs I paid for were either incomplete or improperly performed, leading to safety concerns and additional costs to diagnose and correct the problems. After discovering these faults, I made multiple attempts to contact Ben Nielsen Skyline Automotive via phone and email to request a resolution, including a full reimbursement for the tie rod adjustment, fluid leak repair, and rear brake installation. Unfortunately, my email messages and calls have gone unanswered, leaving me no choice but to escalate this matter.

Unknown or Other

ODI #11628081

Incident: November 11, 2024 · Filed: November 30, 2024

Odometer on 2005 Corolla S stopped working at 299,999 miles. Will not roll over to 300,000. This has been a topic of discussion on many Toyota vehicle online forums and has been an ongoing issue for many similar makes/years/models. There were no prior warnings/messages related to the odometer not working any longer when it reaches any certain number. Several mechanics I have spoken to, including Toyota service advisors, have told me they are aware of this issue. No inspections have been done. Why would Toyota place an odometer in any of their vehicles that will stop working after reaching any specific number? They have prided themselves as cars that will go many miles. Why would they not disclose this to any Toyota owner? Why should the owner be liable for repairs on this issue when we did not install the part? Why has no recall been issued over this matter?

Other Toyota Corolla model years

Check your 2005 Toyota Corolla VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Toyota Corolla at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Toyota VIN