2007 Tiffin Allegro Bay Recalls & Complaints

Incident: August 21, 2016 · Filed: September 1, 2016

WE WERE TRAVELING IN THE SOUTH PASS OF BIG HORN NATIONAL PARK. THE GRADES WERE LONG AND STEEP. A PERSON PASSED US AND PULLED OVER AND STOPED US AND SAID WE WERE ON FIRE. THE COACH FILLED WITH SMOKE ND I GOT OUT AND FOUND THAT THE AREA ABOVE THE EXAUST PIPE HAD MELTED DOWN ON TO THE PIPE CATCHING ON FIRE AND BURNING UP EVERYTHING IN THE COMPARTMENT CAUSEING $3000.00 OF DAMAGE. ON MY OLDER MOTERHOME IT HAD HEAT SHEILDS ABOVE THE EXAUST TO PREVENT THIS. ALL THE OTHER BRANDS I HAVE LOOKED AT HAVE ALSO MADE PROVISIONS TO PREVENT THIS FROM HAPPENING. I HAVE ALSO LOOKED AT OTHER MOTORHOMS LIKE MINE AND SOME OF THEM ARE AT HIGER RISK THAN MINE. I HAVE TALKED TO TIFFIN BUT THEY SEEM TO BE "OH WELL" ABOUT THE ISSUE. I THINK ALL OF THIS MODEL AHOULD BE CHECKED AND MEASURES TAKEN. THE PEOPLE THAT HELPED ME OUT ON THAT MOUNTAIN SAID I WAS NOT THE ONLY ONE THAT HAS HAD THIS PROBLEM BUT I DON'T KNOW WHAT KIND OF MOTORHOMES THEY WERE.

Incident: July 10, 2015 · Filed: July 20, 2015

TL* THE CONTACT OWNS A 2007 TIFFIN ALLEGRO BAY. THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 12V327000 (SERVICE BRAKES, HYDRAULIC); HOWEVER, WHILE DRIVING APPROXIMATELY 55 MPH, THE SPEED DECREASED AFTER THE BRAKE WARNING INDICATOR ILLUMINATED. THE CONTACT DEPRESSED THE ACCELERATOR PEDAL TO THE FLOOR AND WAS ABLE TO PULL OVER. THE MOTOR HOME WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE PARKING BRAKE AND THE BRAKE CALIPERS FAILED AND NEEDED TO BE REPLACED. THE MOTOR HOME WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 30,000.

Incident: January 5, 2010 · Filed: March 5, 2012

HAD STOPPED FOR FUEL AFTER DRIVING APPROXIMATELY 150 MILES. SMELLED BURNING BUT WALK AROUND AND OBSERVATION FOUND NOTHING. DROVE APPROXIMATELY 10 MILES FURTHER AND PUSHED BRAKE PEDAL TO STOP. PEDAL WENT ALL THE WAY TO FLOOR. PUMPING THE BRAKES VIGOROUSLY RESTORED SOME BRAKING. WAS ABLE TO FINISH TRIP (APPROXIMATELY 1 BLOCK FURTHER) DRIVING VERY SLOWLY UNTIL UNIT PARKED IN STORAGE LOT. DURING THIS SMALL DISTANCE VEHICLE FELT LIKE BRAKE WAS LOCKED ON - AS IF EMERGENCY BRAKE DID NOT RELEASE. UPON DISEMBARKING PASSENGER OUTSIDE TIRE WAS SMOKING AND VERY HOT. *TR

Incident: March 1, 2010 · Filed: March 5, 2012

TL* THE CONTACT OWNS A 2007 TIFFIN ALLEGRO BAY MOTOR HOME. THE CONTACT STATED THAT WHILE DEPRESSING THE BRAKE PEDAL, THE ABS WARNING LIGHT WOULD ILLUMINATE AND THE BRAKE PEDAL WOULD GO STRAIGHT DOWN ONTO THE FLOORBOARD. THE DEALER AND THE MANUFACTURER WERE NOTIFIED OF THE FAILURE, BUT DENIED ANY ASSISTANCE WITH REPAIRS TO THE VEHICLE. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 15,000 AND THE CURRENT MILEAGE WAS 35,000. UPDATED 03/27/12*LJ THE CONSUMER STATED HE DID NOT EXPERIENCE A BRAKE FAILURE. HIS CALL TO NHTSA WAS OUT OF CONCERN FOR OTHER MODELS THAT DID HAVE A FAILURE BECAUSE THEY WERE EQUIPPED WITH THE SAME BOSCH BRAKES AS HIS RV. UPDATED 03/30/12 LJ ....UPDATED 04/09/12 *BF

Incident: January 2, 2012 · Filed: January 8, 2012

THIS IS A 38' MOTORHOME BUILT ON A FREIGHTLINER FRONT ENGINE DIESEL CHASSIS. THIS CHASSIS HAS HYDRAULIC BRAKES (NOT AIR BRAKES). BRAKES FAILED WHILE EXITING A FREEWAY - NARROWLY AVOIDING A CRASH. RETURNING HOME FROM A WEEK AWAY IN AN RV RESORT. STOPPED FOR FUEL ABOUT 10 MILES FROM HOME. NOTICED A SMELL OF HOT BRAKES, BUT NOTHING ELSE UNUSUAL. DID A COMPLETE WALKAROUND AFTER FUELING - ALL NORMAL. ABOUT 8 MILES LATER, WHEN EXITING THE FREEWAY, THE BRAKE PEDAL WENT COMPLETELY TO THE FLOOR WITH NO EFFECT. THE ENGINE BRAKE WAS ENGAGED QUICKLY AND AFTER SOME RAPID PUMPING ON THE PEDAL, GOT ENOUGH BRAKE EFFECT THAT I COULD AVOID A CRASH AT THE END OF THE RAMP AND MADE IT SAFELY TO A PLACE TO STOP AND GET OFF THE ROAD. UPON WALKAROUND, THERE WAS AN EXTREME SMELL OF HOT BRAKES, HEAVY BRAKE DUST INSIDE REAR RIMS, AND A PUDDLE OF HYDRAULIC FLUID (ABOUT 1 QUART) UNDER THE MASTER CYLINDER. NOTE THAT THERE WAS NO DOWNHILL OR OTHER EXTENDED BRAKING PRIOR. VEHICLE WAS PARKED OVERNIGHT. AFTER CALLING FOR A TOW IN THE MORNING AND RETURNING TO THE COACH, THERE WAS ENOUGH PEDAL TO NAVIGATE THE COACH TO A PLACE ACCESSIBLE TO THE TOW TRUCK AND IT WAS TOWED TO A FREIGHTLINER SERVICE CENTER. THE SERVICE CENTER FOUND THAT THERE WAS OBVIOUS SIGNS OF OVERHEATING. REAR ABS SENSORS WERE MELTED FROM HEAT. PADS AND ROTORS DESTROYED. TROUBLESHOOT SYSTEM AND FOUND NO PROBLEMS OTHER THAN APPARENTLY REAR CALIPER PISTONS HAD STUCK, CAUSING BRAKES TO DRAG, OVERHEATING THE SYSTEM, RESULTING IN FAILURE. UPON POSTING MY EXPERIENCE ON A TIFFIN WEB SITE, I LEARNED THAT THERE ARE DOZENS OF COACHES THAT HAVE HAD SAME EXPERIENCE. FREIGHTLINER KNOWS ABOUT IT - THEY INSTRUCTED SERVICE CENTER TO USE SPECIAL GREASE TO LUBE CALIPER (GREASE USED FOR AIRCRAFT APPLICATIONS). APPARENTLY SAME BRAKE CALIPERS SUBJECT OF RECALL IN GM WORKHORSE CHASSIS FOR MOTORHOMES. SIGNIFICANT SAFETY ISSUE-LUCKY TO AVOID CRASH! *TR

Incident: September 2, 2011 · Filed: January 5, 2012

BRAKES OVERHEATED, BURNED OUT ABS SENSORS, LOCKED UP REAR BRAKES. THIS RV HAS BOSCH BRAKES INSTALLED, AND WORKHORSE CHASSIS RV'S HAVE A RECALL FOR MOISTURE GETTING IN THE BRAKE SYSTEM AND HEATING UP AND NOT RELEASING THE BRAKES. FREIGHTLINER OR ANY RV COMPANY WITH BOSCH BRAKES NEEDS TO ISSUE A RECALL BEFORE SOME GETS KILLED OR HURT,[XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Incident: September 1, 2009 · Filed: June 22, 2010

TL* THE CONTACT OWNS A 2007 TIFFIN ALLEGRO BAY RV. THE CONTACT STATED WHILE DRIVING DOWNHILL AT APPROXIMATELY 40 MPH, THE CONTACT ATTEMPTED TO BRAKE BUT TO NO AVAIL. THE BRAKE PEDAL FELL INTO THE FLOORBOARD AND HE HAD TO USE THE EMERGENCY BRAKE TO STOP THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT WAS INFORMED THAT THE REAR CALIPERS WOULD NEED TO BE REPLACED. THE REPAIRS WERE MADE TO THE VEHICLE. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 30,000.