try.vin
Log in

NHTSA vehicle safety data

2003 Tiffin Allegro Bay Recalls & Complaints

The 2003 Tiffin Allegro Bay has 5 NHTSA recall campaigns and 3 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Tiffin dealer.

NHTSA recall and complaint data for the 2003 Tiffin Allegro Bay. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2003 Tiffin Allegro Bay owner complaints

Owners have filed 3 complaints with NHTSA about the 2003 Tiffin Allegro Bay, describing incidents dated August 1, 2005 to April 23, 2009.

Most-cited components

  • Service Brakes 2 complaints
  • Engine 1 complaint

Newest complaints

  • ODI #10296078 · Filed

    SEVER BRAKE ROTOR DAMAGE, AND UNEVEN BRAKEPAD WEAR. *TR

  • ODI #10241592 · Filed

    TL*THE CONTACT OWNS A 2003 TIFFIN ALLEGRO BAY. WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE PULLED TO THE RIGHT WHEN THE BRAKE PEDAL WAS DEPRESSED. ALSO, THE REAR BRAKES LOCKED UP AND SMOKE APPEARED. THE FAILURES OCCURRED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THEY…

  • ODI #10131233 · Filed

    DT: 2003 TIFFIN ALLEGRO BAY MOTOR HOME. THE MOTOR HOME LODT POWER AND SHUT DOWN. THERE WERE NO NO POWER STEERING OR BRAKES. WHILE DRIVING UP A HILL THE MOTOR HOME STARTED TO JERK. FOUND A PLACE TO PULL OFF THE ROAD AND THE ENGINE DIED. THIS WAS THE FIRST TIME AND THE SECOND TIME WHILE DRIVING FELT…

Read all 3 complaints

REFRIGERATOR FIRE/NORCOLD

NHTSA #09V443000 · Equipment — Recreational Vehicle/Trailer · NHTSA notice

Reported November 17, 2009 · TIFFIN MOTORHOMES, INC.

Potentially affected: 528 vehicles

Owners notified December 7, 2009 · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

TIFFIN IS RECALLING CERTAIN RECREATIONAL VEHICLE EQUIPPED WITH NORCOLD MODEL 1200LR AND 1200LRIM REFRIGERATORS, MANUFACTURED FROM DECEMBER 1, 2001, WITH SERIAL NUMBERS BETWEEN 1273701 AND 1536607, NON-CONSECUTIVELY. A FATIGUE FAILURE IN THE SECTION OF THE COOLING UNIT WHICH CONTAINS THE REFRIGERANT COULD ALLOW THE LIQUID SOLUTION TO SLOWLY LEAK. IF A LEAK OCCURS AND THE REFRIGERATOR CONTINUES TO BE OPERATED AFTER SOLUTION CIRCULATION HAS CEASED THE HEAT SOURCE COULD GENERATE VERY HIGH TEMPERATURES. AT SUCH HIGH TEMPERATURES, THE COOLING UNIT COULD RUPTURE.

Safety consequence

IF A LEAK OCCURS AND THE UNIT IS CONTINUES TO OPERATE, HYDROGEN GAS MAY BE EXPELLED AND CAN BE IGNITED, RESULTING IN A FIRE, POSSIBLY CAUSING SERIOUS INJURY OR DEATH.

Manufacturer remedy

TIFFIN IS WORKING WITH NORCOLD AND TIFFIN WILL NOTIFY OWNERS AND THE VEHICLE'S REFRIGERATOR WILL BE REPAIRED FREE OF CHARGE BY NORCOLD. PLEASE SEE NORCOLD'S DEFECT REPORT 09E-027. OWNERS MAY CONTACT NORCOLD'S RECALL CENTER AT 1-800-767-9101.

Notes

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

OVERHEATED BRAKE CALIPERS/BOSCH/WORKHORSE

NHTSA #09V110000 · Service Brakes, Hydraulic · NHTSA notice

Reported April 3, 2009 · NAVISTAR, INC

Potentially affected: 48,876 vehicles

Manufacturer campaign 50901-C & 51101-C · Owners notified September 16, 2010 · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

NAVISTAR IS RECALLING CERTAIN MODEL YEAR MY 2001-2008 WORKHORSE W20, W21 AND W22 CHASSIS AND CERTAIN MODEL YEAR 2009 THROUGH 2011 MONACO RV ADMIRAL, ARISTA, MONARCH, AND RIPTIDE RECREATIONAL VEHICLES EQUIPPED WITH AXLES THAT INCLUDE BOSCH ZOPS OR ZOHT PIN SLIDE HYDRAULIC DISC BRAKES. WHEN COMBINED WITH OCCASIONAL OR SEASONAL VEHICLE OPERATION MAY EXPERIENCE CALIPERS STICKING IN THE APPLIED POSITION. THIS CAN RESULT IN ABNORMAL HEAT GENERATION AT THE WHEEL END CAUSING BRAKE DRAG. THE DRIVER WOULD NORMALLY HAVE WARNING OF THE BRAKE DRAG IF UNDETECTED BY THE DRIVER.

Safety consequence

THE TEMPERATURE INCREASE AT THE WHEEL END CAN EVENTUALLY LEAD TO SOFT PEDAL CONDITIONS DUE TO BRAKE FLUID BOIL, AND POSSIBLE EXTENDED STOPPING DISTANCE INCREASING THE RISK OF A CRASH.

Manufacturer remedy

WORKHORSE DEALERS WILL REPLACE ALL FOUR BOSCH BRAKE CALIPER ASSEMBLIES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2010. OWNERS MAY CONTACT WORKHORSE AT 1-877-246-7731.

Notes

WORKHORSE RECALL NO. 50901-C AND 51101-C.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

REFRIGERATOR/DOMETIC

NHTSA #07V517000 · Equipment — Recreational Vehicle/Trailer · NHTSA notice

Reported November 5, 2007 · TIFFIN MOTORHOMES, INC.

Potentially affected: 11,438 vehicles

Owners notified April 6, 2007 · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

ON CERTAIN MOTOR HOMES EQUIPPED WITH A TWO-DOOR REFRIGERATOR MANUFACTURED BY THE DOMETIC CORPORATION, THESE REFRIGERATORS MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

Safety consequence

RELEASE OF COOLANT UNDER CERTAIN CONDITIONS COULD IGNITE AND RESULT IN A FIRE.

Manufacturer remedy

TIFFIN MOTORHOMES WILL BE WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 06E076). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST THE OWNER IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR TIFFIN AT 1-256-356-8661.

Notes

CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

INSTRUMENT CLUSTER/FMVSS 101 & 105/ WORKHORSE

NHTSA #06V142000 · Electrical System · NHTSA notice

Reported April 28, 2006 · TIFFIN MOTORHOMES, INC.

Potentially affected: 1,594 vehicles

Recall influenced by NHTSA's Office of Defects Investigation

Defect description

CERTAIN MOTOR HOMES BUILT ON WORKHORSE CHASSIS AND EQUIPPED WITH ACTIA CORPORATE INSTRUMENT CLUSTERS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 101, CONTROLS AND DISPLAYS, AND NO. 105, HYDRAULIC AND ELECTRIC BRAKE SYSTEMS. IF THE BRAKE FAIL INPUT FALLS BELOW A VOLTAGE OF 1.5V, THE BRAKE FAILURE LAMP AND ALARM WILL BE ACTIVATED. ALSO ACTIVATION OF THE ABS TELLTALE WHEN THE ABS IS NOT PROPERLY FUNCTIONING DOES NOT ALWAYS OCCUR.

Safety consequence

AT NIGHT THE INSTRUMENT CLUSTER LIGHTS MAY FAIL AND THE DRIVER MAY NOT BE ABLE TO SEE THE INSTRUMENT PANEL GAUGES AND THE BRAKE WARNING LIGHT INDICATOR WHICH COULD INCREASING THE RISK OF A CRASH.

Manufacturer remedy

TIFFIN IS WORKING WITH WORKHORSE TO CONTACT THE OWNERS AND REMEDY THIS CAMPAIGN . WORKHORSE WILL REPROGRAM THE INSTRUMENT PANEL CLUSTER FREE OF CHARGE. OWNERS MAY CONTACT WORKHORSE AT 1-877-246-7731 OR TIFFIN AT 1-256-356-0205.

Notes

CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

TIFFIN/BRAKE SYSTEM WARNING INDICATOR

NHTSA #03V149000 · Service Brakes, Hydraulic — Brake Fluid Low Warning — Lamp · NHTSA notice

Reported April 14, 2003 · TIFFIN MOTOR HOMES

Potentially affected: 1,174 vehicles

Owners notified June 2, 2003 · Vehicles built August 1, 1999 – June 30, 2003 (per NHTSA)

Defect description

CERTAIN MOTOR HOME CHASSIS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 105, "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." THE BRAKE SYSTEM WARNING INDICATOR MAY NOT FUNCTION AS REQUIRED BY STANDARD.

Safety consequence

IN SOME OF THE AFFECTED VEHICLES, THE BRAKE SYSTEM WARNING INDICATOR WILL NOT ILLUMINATE WHEN THE IGNITION IS IN THE START POSITION OR FOR A LOW BRAKE FLUID CONDITION, IF THE BODY BUILDER RELIED SOLELY UPON FORD'S IVM COMPLIANCE STATEMENT FOR THE BRAKE SYSTEM WARNING INDICATOR.

Manufacturer remedy

DEALERS WILL REPAIR THE BRAKE WARNING LAMP CIRCUIT. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TIFFIN AT 1-256-356-8661.

Notes

CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Other Tiffin Allegro Bay model years

Check your 2003 Tiffin Allegro Bay VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Tiffin Allegro Bay at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Tiffin VIN